Professional Documents
Culture Documents
NORMARC DME
Supplying ATM systems around the world for more than 100 years
indracompany.com
NORMARC DME
ATM
DME Antenna
System
Configuration Single or Dual
Standard Compliance ICAO Annex 10
ICAO Doc 8071,
EUROCAE ED-57
RCM & CE Marking
Aircraft Handling Capacity > 200 Interrogators
Design Full solid-state and modular
Module Hot Replacement Yes, Local & Remote
Status Indication Full Local and Remote indication
System Monitoring (BITE) Complete System & LRU Monitoring
based on HW
Remote/Local Control Interface Ethernet (RS-232 & RS-485)
Environmental Conditions Operating Temperature:
• -20ºC to +60°C for indoor installed parts
• -50ºC to +70°C for outdoor parts
Relative Humidity:
• 95% (-20ºC to 35ºC)
• 60% (35ºC to 60ºC)
Operating Altitude: 15,000 ft
Reliability MTBO > 20,000 hours for dual system
Power Consumption < 350 VA (dual System and hot standby)
Dimensions One19” standard rack:
600 mm (Wide)
600 mm (Deep)
1467 mm (High)
Indra’s NORMARC DME is the result of The system is available in two • Modular design
Indra´s extensive expertise in radio configurations: single, and dual DME, both • Solid state components
navigation aids that combines efficient employing the use of high quality electronic • Multiple interfaces (Ethernet, RS-232, RS-485)
operation and accurate distance components. • FPGA logic and embedded PC
measurement with an intuitive user friendly The equipment has a modern and modular • Friendly and intuitive user interface
interface. design which performs continuous • Easy and fast installation
It is a solid state system developed with monitoring of the main system parameters,
• Multiple configurations
state-of-the-art technology achieving including reply delay, pulse pair spacing,
high reliability. transmission power, reply efficiency, • Standard and flexible RMM architecture
receiver sensitivity and pulse shape. This • High level BITE
Its modular design in conjunction with its
powerful BITE system allows fast failure provides high reliability and fast failure
location and minimal repair time. location, as well as the ability to anticipate
critical parameter degradation.
The main characteristic of the Indra’s
NORMARC DME is its high reliability. With all these features, the equipment
operational availability is maximized.
Built In Test
The BITE (Built In Test) system reduces the In order to achieve this aim, critical The results of the BITE process are
requirement for routine maintenance to an parameters of the system are constantly available both remotely, at the Remote
absolute minimum. checked, giving the possibility to predict Monitoring and Maintenance system (RMM),
The BITE systems fault location facility degradation of the systems characteristics and locally.
allows dramatically reduced repair times to and minimizing the maintenance task.
be achieved.
Indra’s NORMARC DME offers high reliability Remote Maintenance Monitoring The software architecture is based on
that is reflected in its high MTBF and low The equipment can be integrated with a standard protocols which provide intuitive
MTTR, resulting in minimum maintenance. versatile and robust software architecture and simple operation.
Thanks to its integrated test system, it’s that allows control and supervision to be
possible to perform easy and fast maintenance performed locally or remotely, with several
procedures. security levels.
Characteristics
TRANSMITTER CHARACTERISTICS
Peak Power Output > 100W (terminal DME)
> 1kW (en-route DME)
Power Output Control 4 dB (0.25dB steps)
Frequency Range 960 MHz to 1215 MHz
Frequency Stability ± 2 ppm
Channels 252 (126 X and 126 Y)