Professional Documents
Culture Documents
Manic Installation Guide
Manic Installation Guide
Assembly Instructions
Saddle Mounting:
page 1
Loosen seatpost collar on frame Level Saddle to your preference and
and install post into frame Torque bolts to 8 to 10 N-M
page 3
Mimic location the housing Mimic cable routing up to
would route in frameh tape mark on seat tube
Run the cable through the hous- Pull cable through housing
ing completely
Pulling firmly at this point will
eliminate any slack
page 5
Locking Cable End
2MM
3MM Wire
Ferrule
Cable Housing
Cut cable, leaving extra cable at Push cable end into frame and
the end lower post into frame
This extra cable will be routed Pulling the housing from below will
into frame ease this process
page 6
Put post to correct height and Re-Install remote to handlebar
tighten clamp clamp and tighten clamp to 3.5
N-M
page 7