You are on page 1of 8

MAHARASHTRA STATE BOARD OF TECHNICAL EDUCATION, MUMBAI

PROJECT REPORT
On

“Advance Class Monitoring System”

Submitted By

SAGAR B. BOPCHE RAJIYAALAM S. SHEIKH


SHIVDAS S. JADHAV SHUBHAM S. GONDULE
HIMANSHU R. SANGITRAO SANJANA P. ZHADE
SWITI S. PISE SHISHMA R. SHAHU

For the partial fulfillment of Diploma in Engineering


in Computer Science and Engineering
Under the Guidance of
Ms. HEENA KACHHELA

DEPARTMENT OF COMPUTER SCIENCE AND ENGINEERING


TULSIRAMJI GAIKWAD-PATIL COLLEGE OF
ENGINEERING & TECHNOLOGY, NAGPUR

POLYTECHNIC
2021-22
TULSIRAMJI GAIKWAD-PATIL
of Engineering & Technology
Polytechnic, Nagpur

SESSION 2021-22

CERTIFICATE
Certified that the project titled “Advance Class Monitoring System” is a confide
work done under my guidance by VI semester student of this institute and is
submitted to Maharashtra State Board of Technical Education, Mumbai for the partial
fulfillment of the requirements for the award of Diploma in Engineering in Computer
Science & Engineering.

1. SHIVDAS S. JADHAV
2. SAGAR B. BOPCHE
3. RAJIYAALAM S. SHEIKH
4. SHUBHAM S. GONDULE
5. HIMANSHU R. SANGITRAO
6. SANJANA P. ZHADE
7. SHISHMA R. SHAHU
8. SWITI S. PISE

Ms. Heena Kachhela Mr. Abhay Rewatkar


Guide Head of Department

Prof. Niteen Kakde Dr. A. V. Kale


Dean Principal
Polytechnic TGPCET, Nagpur
DECLARATION
The project titled “Advance Class Monitoring System” is our own work carried out
under the guidance of Ms. Heena Kachhela Department of Computer Science and
Engineering at Tulsiramji Gaikwad-Patil College of Engineering& Technology
Polytechnic Nagpur. As far as our knowledge, this work in the same former any other
form is not submitted by us or anyone else for award of any diploma.

PROJECTEES

SHIVDAS S. JADHAV
SAGAR B. BOPCHE
RAJIYAALAM S. SHEIKH
SHUBHAM S. GONDULE
HIMANSHU R. SANGITRAO
SANJANA P. ZHADE
SWITI S. PISE
SHISHMA R. SHAHU
ACKNOWLEDGEMENT
With profound feeling of immense gratitude and affection, we would like to
thank our guide Ms. Heena Kacchela , Department of Computer Science and
Engineering for her continuous support, motivation, enthusiasm and guidance. Her
encouragement, supervision with constructive criticism and confidence enabled us
to complete this project.
We also wish to extend our reverences to Prof. Abhay Rewatkar, Head of
Computer Science and Engineering for providing necessary facilities to complete
our project.
We are also thankful to all the faculty members and all non-teaching staff of
the department & college for their co-operation throughout the project work.
We also put forth our deepest sense of gratitude towards Dr. A. V. Kale and
Prof. Niteen Kakde, Dean Polytechnic for constant motivation and providing
necessary infrastructure.

PROJECTEES

SAGAR B. BOPCHE
RAJIYAALAM S. SHEIKH
SHIVDAS S. JADHAV
SHUBHAM S. GONDULE
HIMANSHU R. SANGITRAO
SANJANA P. ZHADE
SWITI S. PISE
SHISHMA R. SHAHU
CONTENTS
Certificate
Declaration
Acknowledgement
Abstract
Figure Index

CHAPTER – I
Introduction 02-04
1.1 Introduction 02
1.2 Calculation 03
1.3 Objectives 04

CHAPTER - II
Literature Review 05-07

CHAPTER - III
Problem Statement 08-09
3.1 Problem Statement 08-09

CHAPTER - IV
Proposed Work 10-11
4.1 Proposed System 10
4.2 Advantages 10-11

CHAPTER - V
Implementation 12-44
5.1 Hardware/Software 12

5.2 Software Component 13


5.2.1 Web Portal 13-18

5.2.2 Application Portal 19-31


5.3 Flowchart 32
5.4 Result & Block Diagram 33
5.5 Verification Process 34
5.6 Requirement Specification 34
5.7 Hardware Components 35-42
5.8 Technologies Used 42-44

CHAPTER - VI
Source Code 45-79

CHAPTER - VII
Conclusion 80

CHAPTER - VIII
References 81-83

FIGURE INDEX
Fig. 5.1 Global Settings 14
Fig. 5.2 Masters 15

Fig. 5.3 Classification Master 16

Fig. 5.4 Punch Monitor 17


Fig. 5.5 Student Details 18
Fig 5.6 Front page of application 19
Fig5.7 QR Scanner 20
Fig 5.8 Scanning the QR Code 21
Fig 5.9 Camera Identification 22
Fig 5.10 Connect IPC Wi-Fi 23
Fig 5.11 Selecting the Wi-Fi network 24
Fig 5.12 Camera access password 25
Fig 5.13 Access of camera 26
Fig 5.14 Wi-Fi name and password 27
Fig 5.15 Configuring the network 28
Fig 5.16 Setting up the password 29
Fig 5.17 Camera has been added successfully 30
Fig 5.18 Creating group 31

Fig. 5.19 Flowchart 32


Fig. 5.20 Block Diagram 33
Fig. 5.21 Finger-Print Module 35
Fig 5.22 Cameras 36
Fig. 5.23 Real Time clock 37
Fig. 5.24 Power Supply 38
Fig. 5.25 Communication trough the network 39
Fig. 5.26 ATmega Microcontroller 40
Fig. 5.27 Arduino 41
Fig 5.28 SIM800L 42

You might also like