Professional Documents
Culture Documents
SMS012R0
SMS012R0
Chemical Composition :
Carbon : C (max. %) 0.08
Manganese : Mn (max. %) 2.00
Phoshorus : P (max. %) 0.045
Sulphur : S (max. %) 0.03
Silicon : Si (max. %) 1.0
Chromium : Cr (%) 16-18
Nickle : Ni( %) 10-14
Nitrogen : N (max. %) 0.10
Molybdenum : Mo (max %) 2-3
Heat Treatment : Solution Annealed. Solution annealing will consist of heating to a min. temp. of 1040 deg.C,
and cooling rapidly to prevent grain boundary carbide precipitation.
Mechanical Properties :
Tensile Strength ( Mpa / Psi ) 515 / 75000
Yield Strength ( Mpa / Psi) 205 / 30000
Elongation in 2” or 50 mm ( min. %) 30
Reduction of area (min %) 40
*Impact Strength (Toughness ) The energy measured on an ISO ‘V’ test-piece should not be
less than 27 J at a temperature not greater than 20 °C.
The reference standards used will be
Property Reference Standard
General requirements ASTM A479/A479M-1999 / ASTM A484/A484M – 1998
Chemical analysis ASTM A479/A479M-1999 / ASTM A751-1996
Tensile test / Yield strength / Elongation /
ASTM A370-1997
Impact Test / Hardness
Note:
1. * marked item is mandatory for bars, highlighted specifically in Purchase Order as per Pressure
Equipment Directive (PED) 97/23/EC – May 1997.
2. For above bars, Material Test Certificates should be as per EN 10204-3.1.B & the bars should be suitably
identified.