TESTING AND ADJUSTING AND TESTING PPC SHUlTLE VALVE
MEASURING PPC VALVE OUTPUT PRESSURE AND TESTING
PPC SHUTTLE VALVE
PCIOO-6 Serial No. : 40001-41229
PC120-6 Serial No. : 45001-49820
* Hydraulic oil temperature when measuring:
45 - 55°C
1. Measuring PPC valve output pressure
I) Disconnect the hose of the circuit to be mea- sured (see next page). 2) Install adapter C3 between the hose and el- bow. 3) Install oil pressure gauge Cl (5.9 MPa (60 kg/ cm*)) to adapter C3. 4) Run the engine at high idling, operate the con- trol lever of the circuit to be measured;and measure the oil pressure.
2. Checking PPC shuttle valve
If the output pressure at the control valve end is low, check for leakage of oil from the PPC shuttle valve as follows. I) Disconnect the hose between the PPC valve and the shuttle block at the block end. 2) Install an adapter for measuring the oil pres- sure to the tip of the hose, then install blind $ plugs to the tip and shuttle block end. z 8 3) Operate the control lever and measure the output pressure. * If the output pressure becomes normal, there is leakage from the PPC shuttle valve; if there is no change, the PPC valve is defective.
3. Checking defective operation of PPC shuttle valve
1) Remove the oil pressure switch, fit adapter C5, then install oil pressure gauge Cl (5.9 MPa (60 kg/cm*)). 2) Operate the applicable lever. j, If no oil pressure is generated or if oil pressure is generated when another lever is operated, the operation of the PPC shuttle valve is defective.