You are on page 1of 55

2016.

0 RANGE ROVER (LG), 205-01

DRIVESHAFT
S P E C I F I C AT I O N S

Front Drive (Propeller) Shaft

Item Specification

Type The front driveshaft is a one piece unit, connected to the transfer box and
front differential unit via Constant velocity (CV) joints.

Constant The front shaft assembly comprises of a DTF CV joint that is pushed into place
velocity on the front differential pinion shaft and secured by a retaining lock nut. The
joints front shaft is attached to the transfer box by a CV joint with a 6 bolt fixing.

Rear Drive (Propeller) Shaft Except GTDi and Hybrid Electric Vehicles
(HEV)

Item Specification

Type The rear driveshaft comprises of front and rear shaft assemblies and a centrally
mounted shaft bearing.

Constant The rear shaft comprises of an internal spline bore, which is attached to the
velocity input shaft of the front driveshaft assembly via the shaft bearing assembly and
joints a DTF CV joint that is pushed into place on the rear differential pinion shaft
and secured by a retaining lock nut.

Rear Drive (Propeller) Shaft GTDi and Hybrid Electric Vehicles (HEV)

Item Specification

Type The rear driveshaft comprises of front and rear shaft assemblies and a centrally
mounted shaft bearing.

Constant The rear shaft comprises of an internal spline bore, which is attached to the
velocity input shaft of the front driveshaft assembly via the shaft bearing assembly and
joints a CV joint that is fixed to the rear differential pinion using a 6 bolt fixing.

Torque Specifications

DESCRIPTION NM LB-FT

* Front driveshaft to front axle drive flange Torx bolts:

Stage 1 45 33

Stage 2 Further Further


90° 90°

* Rear driveshaft to rear axle drive flange Torx bolts - GTDi and Hybrid 73 54
Electric Vehicles (HEV) only

* Rear driveshaft to transfer case drive flange Torx bolts 150 111

Rear driveshaft center bearing bolts 48 35

Fuel tank heat shield bolts 5 4

+ Front driveshaft to front differential DTF CV joint lock nut 150 111

++ Rear driveshaft to rear differential DTF CV joint lock nut - except 150 111
GTDi and Hybrid Electric Vehicles (HEV)

* New 'Patched' Torx bolts must be installed

+ Refer to the front driveshaft tightening procedure in the workshop


manual

++ Refer to the rear driveshaft tightening procedure in the workshop


manual
2016.0 RANGE ROVER (LG), 205-01

DRIVESHAFT

FRONT DRIVESHAFT - TDV6


3.0L DIESEL (G1509295)

R E M O V A L A N D I N S TA L L AT I O N

DRIVESHAFT
3000 CC, USED
47.15.02 - FRONT - 1.3 +
TDV6 WITHINS
RENEW

SPECIAL TOOL(S)

!
303-1142
Viscous Coupling
Wrench
!
JLR-205-
993
Remover/Installer,
Driveshaft Nut

REMOVAL

NOTE:

Removal steps in this procedure may contain installation details.

1.
WARNING:

Make sure to support the vehicle with axle stands.

Raise and support the vehicle.

2. Refer to: Transmission Support Crossmember - TDV6 3.0L Diesel


(502-02 Full Frame and Body Mounting, Removal and Installation).
3.
!

Torque: 10 Nm

4.
CAUTION:

To avoid damage to the joint or gaiter, do not allow the


driveshaft to hang.
!

Special Tool(s): JLR-205-993, 303-1142

5.
CAUTIONS:

Mark the position of the driveshaft flange in relation to the


drive pinion flange.

To avoid damage to the joint or gaiter, do not allow the


driveshaft to hang.

Make sure that new bolts are installed.


!

Torque:
Stage 1: 45 Nm
Stage 2: 90°

6.
!

I N STA L L AT I O N
1.
CAUTION:

Make sure the torque wrench setting procedure is followed


correctly. Failure to follow this instruction may result in
damage to the vehicle.

1. Calculate the setting for the torque wrench:

2. Stage 1: Multiply the required torque by the effective length


of the torque wrench (1).

3. Stage 2: Add the effective length of the special tool (2) to


the effective length of the torque wrench.

4. Stage 3: Divide the total of stage 1 by the total of stage 2.

5. Stage 4: Set the torque wrench to the figure arrived at in


stage 3.

2.
CAUTION:

Make sure the torque wrench setting procedure is followed


correctly. Failure to follow this instruction may result in
damage to the vehicle.
!

Special Tool(s): JLR-205-993, 303-1142


Torque: 150 Nm

3. To install, reverse the removal procedure.


2016.0 RANGE ROVER (LG), 205-01

DRIVESHAFT

REAR DRIVESHAFT - TDV6


3.0L DIESEL (G1875551)

R E M O V A L A N D I N S TA L L AT I O N

3000 CC,
TDV6,
DIESEL, WITH
DRIVESHAFT
PARTICUL ATE USED
47.15.03 - REAR - 1.7 +
FILTER, WITH WITHINS
RENEW
DIESEL
EXHAUST
FLUID

SPECIAL TOOL(S)

!
303-1142
Viscous Coupling
Wrench
!
JLR-205-
993
Remover/Installer,
Driveshaft Nut

REMOVAL

NOTE:

Removal steps in this procedure may contain installation details.

1.
WARNING:

Make sure to support the vehicle with axle stands.

Raise and support the vehicle.

2. Refer to: Exhaust System - Vehicles Without: Diesel Particulate Filter


(DPF) (309-00A Exhaust System - TDV6 3.0L Diesel, Removal and
Installation).
Refer to: Exhaust System - Vehicles With: Diesel Particulate Filter
(DPF) (309-00A Exhaust System - TDV6 3.0L Diesel, Removal and
Installation).
Refer to: Exhaust System - Vehicles With: Diesel Exhaust Fluid (309-
00A Exhaust System - TDV6 3.0L Diesel, Removal and Installation).
3.
!

Torque: 5 Nm

4.
!

Torque: 5 Nm
5.
CAUTIONS:

Mark the position of the driveshaft flange in relation to the


drive pinion flange.

To avoid damage to the joint or gaiter, do not allow the


driveshaft to hang.

Make sure that new bolts are installed.

Torque: 150 Nm

6.
CAUTION:

To avoid damage to the joint or gaiter, do not allow the


driveshaft to hang.
!

Special Tool(s): JLR-205-993, 303-1142

7.
CAUTION:

Note the fitted position of the component prior to removal.

I N STA L L AT I O N
1.
!

Torque: 48 Nm

2.
CAUTION:

Make sure the torque wrench setting procedure is followed


correctly. Failure to follow this instruction may result in
damage to the vehicle.

!
1. Calculate the setting for the torque wrench:

2. Stage 1: Multiply the required torque by the effective length


of the torque wrench (1).

3. Stage 2: Add the effective length of the special tool (2) to


the effective length of the torque wrench.

4. Stage 3: Divide the total of stage 1 by the total of stage 2.

5. Stage 4: Set the torque wrench to the figure arrived at in


stage 3.

3.
CAUTION:

Make sure the torque wrench setting procedure is followed


correctly. Failure to follow this instruction may result in
damage to the vehicle.

Special Tool(s): JLR-205-993, 303-1142


Torque: 150 Nm

4. To install, reverse the removal procedure.


PUBLISHED: 11-SEP-2012
2015.0 RANGE ROVER (LG), 205-01

DRIVESHAFT

FRONT DRIVESHAFT - TDV8 4.4L


DIESEL (G1509296)
REMOVAL AND INSTALLATION

DRIVESHAFT
4400 CC, USED
47.15.02 - FRONT - 1
TDV8 WITHINS
RENEW

SPECIAL TOOL(S)

303-1142
Viscous Coupling
Wrench

JLR-205-993
Remover/Installer,
Driveshaft Nut

GENERAL EQUIPMENT

EQUIPMENT NAME

Transmission jack
REMOVAL

NOTE:

Removal steps in this procedure may contain installation details.

1.

WARNING:

Make sure to support the vehicle with axle stands.

Raise and support the vehicle.

2.

Torque: 60 Nm

3.
Torque: 24 Nm

4.

General Equipment: Transmission jack


Torque: 175 Nm

5.

Torque: 110 Nm

6.
7.

Torque: 10 Nm
8.

CAUTION:

To avoid damage to the joint or gaiter, do not allow the driveshaft to


hang.

Special Tool(s): JLR-205-993 , 303-1142

9.

CAUTIONS:
Mark the position of the driveshaft flange in relation to the drive
pinion flange.

To avoid damage to the joint or gaiter, do not allow the driveshaft to


hang.

Make sure that new bolts are installed.

Torque:
Stage 1: 45 Nm
Stage 2: 90°

10.
INSTALLATION

1.

CAUTION:

Make sure the torque wrench setting procedure is followed correctly.


Failure to follow this instruction may result in damage to the vehicle.

Calculate the setting for the torque wrench:

Stage 1: Multiply the required torque by the effective length of the


torque wrench (1).

Stage 2: Add the effective length of the special tool (2) to the effective
length of the torque wrench.

Stage 3: Divide the total of stage 1 by the total of stage 2.


Stage 4: Set the torque wrench to the figure arrived at in stage 3.

2.

CAUTION:

Make sure the torque wrench setting procedure is followed correctly.


Failure to follow this instruction may result in damage to the vehicle.

Special Tool(s): JLR-205-993 , 303-1142


Torque: 150 Nm
3.
To install, reverse the removal procedure.
PUBLISHED: 07-NOV-2012
2015.0 RANGE ROVER (LG), 205-01

DRIVESHAFT

REAR DRIVESHAFT - TDV8 4.4L


DIESEL (G1509299)
REMOVAL AND INSTALLATION

4400 CC,
DRIVESHAFT
TDV8, WITH USED
47.15.03 - REAR - 1.5
PARTICULATE WITHINS
RENEW
FILTER

SPECIAL TOOL(S)

303-1142
Viscous Coupling
Wrench

JLR-205-993
Remover/Installer,
Driveshaft Nut

REMOVAL
NOTE:

Removal steps in this procedure may contain installation details.

1.

WARNING:

Make sure to support the vehicle with axle stands.

Raise and support the vehicle.

2.
Refer to: Exhaust System - Vehicles With: Diesel Particulate Filter (DPF) (309-
00D Exhaust System - TDV8 4.4L Diesel, Removal and Installation).
Refer to: Exhaust System - Vehicles Without: Diesel Particulate Filter (DPF)
(309-00D Exhaust System - TDV8 4.4L Diesel, Removal and Installation).

3.

Torque: 5 Nm

4.
Torque: 5 Nm

5.

CAUTIONS:

Mark the position of the driveshaft flange in relation to the drive


pinion flange.

To avoid damage to the joint or gaiter, do not allow the driveshaft to


hang.

Make sure that new bolts are installed.


Torque: 150 Nm

6.

CAUTION:

To avoid damage to the joint or gaiter, do not allow the driveshaft to


hang.
Special Tool(s): JLR-205-993 , 303-1142

7.

CAUTION:

Note the fitted position of the component prior to removal.


INSTALLATION

1.
Torque: 48 Nm

2.

CAUTION:

Make sure the torque wrench setting procedure is followed correctly.


Failure to follow this instruction may result in damage to the vehicle.
Calculate the setting for the torque wrench:

Stage 1: Multiply the required torque by the effective length of the


torque wrench (1).

Stage 2: Add the effective length of the special tool (2) to the effective
length of the torque wrench.

Stage 3: Divide the total of stage 1 by the total of stage 2.

Stage 4: Set the torque wrench to the figure arrived at in stage 3.

3.

CAUTION:

Make sure the torque wrench setting procedure is followed correctly.


Failure to follow this instruction may result in damage to the vehicle.
Special Tool(s): JLR-205-993 , 303-1142
Torque: 150 Nm

4.
To install, reverse the removal procedure.
PUBLISHED: 11-SEP-2012
2014.0 RANGE ROVER (LG), 205-01

DRIVESHAFT

FRONT DRIVESHAFT - V6 S/C 3.0L


PETROL /V8 N/A 5.0L PETROL/V8 S/C
5.0L PETROL (G1509297)
REMOVAL AND INSTALLATION

DRIVESHAFT
5000 CC, USED
47.15.02 - FRONT - 1.1
AJ V8 WITHINS
RENEW

SPECIAL TOOL(S)

303-1142
Viscous Coupling
Wrench

JLR-205-993
Remover/Installer,
Driveshaft Nut

REMOVAL
NOTE:

Removal steps in this procedure may contain installation details.

1.
WARNING:

Make sure to support the vehicle with axle stands.

Raise and support the vehicle.

2. Refer to: Transmission Support Crossmember - V8 5.0L Petrol/V8 S/C 5.0L


Petrol (502-02, Removal and Installation).

3.

Torque: 10 Nm

4.
CAUTION:

To avoid damage to the joint or gaiter, do not allow the driveshaft to


hang.

Special Tool(s): JLR-205-993 , 303-1142

5.
CAUTIONS:
Mark the position of the driveshaft flange in relation to the drive
pinion flange.

To avoid damage to the joint or gaiter, do not allow the driveshaft to


hang.

Make sure that new bolts are installed.

Torque:
Stage 1: 45 Nm
Stage 2: 90°

6.
INSTALLATION

1.
CAUTION:

Make sure the torque wrench setting procedure is followed correctly.


Failure to follow this instruction may result in damage to the vehicle.

Calculate the setting for the torque wrench:

Stage 1: Multiply the required torque by the effective length of the


torque wrench (1).

Stage 2: Add the effective length of the special tool (2) to the effective
length of the torque wrench.
Stage 3: Divide the total of stage 1 by the total of stage 2.

Stage 4: Set the torque wrench to the figure arrived at in stage 3.

2.
CAUTION:

Make sure the torque wrench setting procedure is followed correctly.


Failure to follow this instruction may result in damage to the vehicle.
Special Tool(s): JLR-205-993 , 303-1142
Torque: 150 Nm

3. To install, reverse the removal procedure.


PUBLISHED: 12-JUN-2017
2014.0 RANGE ROVER (LG), 205-01

DRIVESHAFT

REAR DRIVESHAFT - V6 S/C 3.0L


PETROL /V8 N/A 5.0L PETROL/V8 S/C
5.0L PETROL (G1509300)
REMOVAL AND INSTALLATION

DRIVESHAFT
5000 CC, USED
47.15.03 - REAR - 0.8
AJ V8 WITHINS
RENEW

SPECIAL TOOL(S)

303-1142
Viscous Coupling
Wrench

JLR-205-993
Remover/Installer,
Driveshaft Nut

REMOVAL
NOTE:

Removal steps in this procedure may contain installation details.

1.
WARNING:

Make sure to support the vehicle with axle stands.

Raise and support the vehicle.

2. Refer to: Front Muffler (309-00B, Removal and Installation).


Refer to: Front Muffler (309-00C, Removal and Installation).

3.

Torque: 5 Nm
4.

Torque: 5 Nm

5.
CAUTIONS:

Mark the position of the driveshaft flange in relation to the drive


pinion flange.

To avoid damage to the joint or gaiter, do not allow the driveshaft to


hang.

Make sure that new bolts are installed.


Torque: 150 Nm

6.
CAUTION:

To avoid damage to the joint or gaiter, do not allow the driveshaft to


hang.
Special Tool(s): JLR-205-993 , 303-1142

7.
CAUTION:

Note the fitted position of the component prior to removal.


INSTALLATION

1.

Torque: 48 Nm

2.
CAUTION:

Make sure the torque wrench setting procedure is followed correctly.


Failure to follow this instruction may result in damage to the vehicle.
Calculate the setting for the torque wrench:

Stage 1: Multiply the required torque by the effective length of the


torque wrench (1).

Stage 2: Add the effective length of the special tool (2) to the effective
length of the torque wrench.

Stage 3: Divide the total of stage 1 by the total of stage 2.

Stage 4: Set the torque wrench to the figure arrived at in stage 3.

3.
CAUTION:

Make sure the torque wrench setting procedure is followed correctly.


Failure to follow this instruction may result in damage to the vehicle.
Special Tool(s): JLR-205-993 , 303-1142
Torque: 150 Nm

4. To install, reverse the removal procedure.

You might also like