Professional Documents
Culture Documents
Dust Control Program Version 1 English - Proposal Bogdan Radu 15.05.2023
Dust Control Program Version 1 English - Proposal Bogdan Radu 15.05.2023
A systematic review of
the effectiveness of dust
control measures
adopted to reduce
workplace exposure.
Radu Bogdan
Safety Manager
s
1.0 INTRODUCTION.................................................................................................................................... 2
1
1.0 INTRODUCTION
The purpose of the dust control and air monitoring plans are to identify the measures
that will be taken to minimize and monitor emissions associated with remediation
activities at …Project Name…
Specifically, this Dust Control Plan outlines the requirements and methods for minimizing
dust generation during planned slag excavation and treatment activities. This plan works
in conjunction with the Air Monitoring Plan which describes the air monitoring activities
that will be performed during the work.
The Dust Control Plan provides specific information about the generation and control of
dust emissions during excavation, milling, stockpiling, stabilization, back filling and
associated activities. This plan is to be used in conjunction with the Site Safety and
Health Plan. The following sections detail potential dust sources and dust control means
and methods.
This Dust Control Plan (DCP) had been produced in accordance with the Environment
Agency’s Dust and Particulate Emission Management Plan Guidance, and relates to the
waste materials imported to, and permanently deposited on, this site.
The DCP identifies the potential sources of dust emissions, the possible impacts
associated with dust emissions and details the measures required to prevent and
minimize the dust and particulate emissions.
2
2.0 SITE SETTING
1 4
5
3
2
106
15 8
14 11 9
1312
3
Example of sensitive receptors
Information on wind direction has been derived from a weather station at ……………………..
Figure 2 - Windrose showing the number of hours the wind has blown from each direction over the last
30 years in ……………………
Example of windrose
4
3.0 DUST CONTROL MEASURES
The following section details the control measures that will be implemented on site to
prevent or minimize dust emissions from the identified dust sources on site.
During all materials handling activities, one or more large area misters will be utilized as an
airborne dust wet suppression system to ensure full, overlapping coverage of active work
areas, mitigating fugitive emissions. The airborne dust wet suppression system resembles a
snow making machine and can cover a large area (approximately ½-acre per machine) with a
fine mist of water, effectively controlling dust.
In addition, water trucks with a spray bar and spray hose(s) will be used to wet work areas
prior to beginning work and as a supplemental dust control mechanism during the activities.
Only potable water will be used for dust control purposes.
Proactive controls will be instituted to reduce the amount of dust generation during site
activities, including enforcement of low speed limits for vehicular traffic and the application
of water to access/haul roads.
If enhanced dust suppression is required by ambient conditions, emulsifiers or surfactants
may be added to improve the “wettability” of water spays, and paper mulch mixed with a
tackifier may be used on slag stockpiles. Section 3.0 describes the additional dust control
measures to be used.
If the sustained wind speed (the wind speed obtained by averaging the measured values over
a one minute period) exceeds 30 km per hour, it is a “high wind condition.” When there is a
high wind condition, all waste-disturbing activities must cease until the sustained wind speed
declines to 30 km per hour or lower for at least 15 consecutive minutes. Non-dust producing
activities (equipment maintenance, etc.) may still be conducted during these periods.
BBGS will implement a dust control training program for all Site personnel. This
training program will review the potential sources of dust, individual responsibilities,
and actions for controlling dust as described in this plan. The training will emphasize
the importance of dust control to the overall success of the remediation activities and
familiarize Site personnel with the air monitoring requirements and appropriate dust
control procedures that must be adhered to in accordance with this plan.
Dust suppression equipment will be inspected at least once a week and properly
maintained. BBGS will maintain records of the weekly inspections.
Site remediation activities will have the potential to generate emissions in the form
of fugitive dust. Dust control methods will vary based on the activities occurring at the
site. Dust control methods are summarized by source below. Table 3-1 describes the
activities to be conducted during the remedial activities which have the potential to
5
generate dust and the respective dust control measures.
A site speed limit of 10 km\h will be enforced for vehicles to reduce the likelihood of
dust or particulates being emitted into the atmosphere and dispersing further.
The speed limit can be reduced during dry weather or strong wind.
BBGS shall continue to run a controlled traffic system to limit the amount of vehicle
movements on site at any one time to reduce dust production.
Site remediation activities will have the potential to generate emissions in the form of
fugitive dust. Dust control methods will vary based on the activities occurring at the site. Dust
control methods are summarized by source below. Table 3-1 describes the activities to be
conducted during the remedial activities which have the potential to generate dust and the
7
respective dust control measures.
3.4.7 Dampening
Dampening of material will be carried out in the following situations:
8
Figure 3 - Dust monitoring locations
Example of dust monitoring locations
Operational staff will report if there are significant dust or particulate emissions during
the handling and movement of waste on site. Where dust emissions are high during the
handling and movement of waste, operations will cease, and the site boundary will be
inspected to ensure that dust isn’t being emitted from the site. If dust emissions are
observed outside of the downwind site boundary then material shall be dampened before
works can recommence.
Dust monitoring will only be carried out during operational hours, when waste is being
imported to site and used in landscaping works, when the potential for dust generation is
greatest. Where regular complaints are received over a two-week period the dust
mitigation measures will be reviewed.
Dust monitoring results, including the dates, times, wind direction, weather conditions
and observations will be recorded and retained on the site.
If the dust emissions are attributed to an activity on the site and mitigation measures
have failed, the activities that are the source of the emissions will cease until remedial
measures have been implemented. Visual monitoring will be increased as necessary along
the site boundary until the dust problem is resolved.
Where dust emissions are continually identified as excessive on site or complaints are
received repeatedly, the Site Manager will review the mitigation measures and
monitoring strategy detailed in this DCP to prevent emissions from being released from
the site.
Due to the remote location of the site, the likelihood of dust and particulate emissions
impacting sensitive receptors in close proximity to the site is considered low, therefore
no additional forms of dust monitoring are proposed for this site.
4.3 Recording
The dust monitoring results from the daily inspection including the dates, times, wind
direction, weather conditions and observations will be recorded and retained on the site.
See Annex A for the recording form.
4.4 Complaints
All complaints received concerning dust emissions from the site will be dealt with in
accordance with the company’s environmental management system complaints
procedure.
BBGS shall decide and implement any necessary action in response to any complaints or
concerns expressed by interested parties, including operatives, customers, clients and
regulatory authorities.
9
The operator shall record the:
Name and contact details of the person who expressed concern or made a
complaint;
Specific subject(s) of the concern or complaint;
4.5 Responsibility
The Site Manager is responsible for this Dust Control Plan and the procedures within it.
Should the Site Manager be away from the site, responsibility will rest with the
designated deputy
10
ANNEX A – DUST MONITORING FORM
Time of test
Receptor Sensitivity
Low e.g. footpath, road Medium e.g. industrial High e.g. housing, pub, hotel
11
workplace etc.
12
ANNEX B – COMPLAINTS FORM
Action taken
Final outcome
13