DEFINITION SURFACE PREPARATION Novo Prime ZP1 is a one component zinc phosphate • The surface of the substrate should be Primer based on a special modified synthetic resin and cleaned from oil, grease, dirt, and loose micro fine zinc phosphate, the coating film is quick particles. drying and matt in different colors. • Steel blasts clean to SIS-Sa2½: ADVANTAGES • The surface should be smoothed well by o Acquires a homogenous consistency by manual suitable putty and blasted to be smooth. mixing. • Mix well the contents of the can for use. o Fast dry one component, Easy to apply. o Economical. • One or two coats of Novo Prime ZP1 are o Good anti - corrosion primer for steel. recommended for applying. o Compatible with most coating systems. • Can be applied using brush, roller or o Can be spraying applied up to 75µm dft. spraying gun. o Over paintable with 1 & 2 top coats. • Can be thinned by Novo Sol X2 if necessary. USAGE Novo Prime ZP1 is specially produced for STORAGE CONDITIONS ➢ Protecting ferrous metals from corrosion. • Best stored at room temperature in dry ➢ Economical anti-corrosion coating in industrial conditions. and marine coatings. • Avoid humidity, cold freezing conditions ➢ Anti-corrosion coating for spot repair to steel and off concrete floors. Reinforcement of reinforced concrete. • Do not store in direct sunlight. PHYSICAL PROPERTIES @ 25 Cº • Temperature of storage (10 – 27) Cº DISCRIPTION VALUE SHELF LIFE Color Gray and others colors 12 months in original unopened packaging. Density (1.50 ±0.05) gm. / Cm 3 PRECAUTIONS & SAFETY Viscosity 25 ± 5 poise o Wear protective clothes, gloves, glasses Solid content (by and face protection. (70±2) % WT.) o Application should be carried out in well Solid content (by Vol.) (48 ±2) % ventilate place. o For skin contact, remove it with suitable Surface dry 20 Min. cream followed by soap and water Hard dry 2 hr. cleaning. Thinner Novo Sol X2 o Don’t eat or smoke during use. 4-5 m2 / kg / 75 µ- DFT Coverage (Depending on surface conditions)