Professional Documents
Culture Documents
Hilliard Fire Clutch Installation
Hilliard Fire Clutch Installation
Slide the chamfered crankshaft Install a ¾”x 1 1/16”O.D. x .04” Install the bearing race. Lubricate the needle bearing with Assemble the sprocket and drum, Install the drum/sprocket
MOUNTING OF THE spacer on the engine. The large thick steel washer against the a small amount of high install the retaining ring bowed assembly. The sprocket will slide
SPROCKET chamfer on the inside is designed crankshaft spacer. temperature bearing grease and side up. The snap ring is bowed over the needle bearing easier if
to give clearance over the radius install the bearing. and acts like a spring to keep the you rotate the drum while
on the crankshaft. sprocket tight in the drum. installing.
8444-7F-025 Rev.0