Professional Documents
Culture Documents
DIMENSIONS
MAX. 5800 MID. 4700 MIN. 3600
2490
00
30
2070
490
330
MIN. 8500 MAX. 26800
3420
OUTLINE SPEC.NO.
Jib which stores in boom TR-200M-4-00107
LME. Reg: 361
TADANO 20t Rough Terrain WORKING RADIUS – LIFTING HEIGHT
TR-200M-4-00107
0°
30°
35
82°
30
70°
7
,4
60°
m
JI
55°
B
25
50°
40°
m
BO
20
OM
20
,7
m
30°
BO
OM
15
14 25°
,
6
m
20°
BO
OM
8,
5 10
m
BO
10°
OM
0°
0
0 5 10 15 20 25 30
NOTES:
1. The deflection of the boom is not incorporated in the figure above.
2. The figure above is for the case where the outriggers are fully extended (360°).
LME. Reg: 361 TADANO 20t Rough Terrain TR 200M
0107
TR-200M-4-00107
TOTAL RATED LOADS
(1) With outriggers set
(i) Unit : ton
Outriggers fully extended – 360°
C 7.4m
A
8.5m 14.6m 20.7m 26.8m D
B 0° 30°
E (°)
2.5m 20.0 16.0 9.0 82 3.0 2.0
3.0m 20.0 16.0 9.0 75 3.0 2.0
3.5m 20.0 16.0 9.0 6.8 70 3.0 2.0
4.0m 18.5 15.5 9.0 6.8 65 2.6 1.85
4.5m 16.5 14.3 9.0 6.8 60 2.2 1.7
5.0m 15.0 13.2 9.0 6.8 55 1.8 1.55
5.5m 13.7 12.2 9.0 6.8 50 1.4 1.25
6.0m 12.5 11.4 9.0 6.8 45 1.05 1.0
6.5m 11.5 10.6 8.5 6.8 40 0.85 0.8
7.0m 9.9 8.1 6.8 35 0.7 0.65
8.0m 8.0 7.3 6.15 30 0.55 0.55
9.0m 6.5 6.5 5.55 25 0.45
10.0m 5.45 5.65 5.05 A = Boom length
11.0m 4.55 4.8 4.65 B = Working radius
C = Jib length
12.0m 3.8 4.15 4.25
D = Jib offset
13.0m 3.6 3.8 E = Boom angle
14.0m 3.15 3.25
15.0m 2.75 2.8
16.0m 2.4 2.5
17.0m 2.1 2.25
18.0m 1.85 2.0
19.0m 1.75
20.0m 1.55
22.0m 1.2
24.0m 0.9
25.0m 0.8
LME. Reg: 361
TR-200M-4-00107
2. The weights of the slings and hooks (main hook: 220kg, auxiliary hook: 60kg) are included in the total rated
loads shown.
3. The total rated load is based on the actual working radii including the deflection of the boom.
4. The chart below shows the standard number of part lines for each boom length. The load per line should
not exceed 2.9t for the main winch and 3.0t for the auxiliary winch.
5. As a rule, free-fall operation should be performed only when lowering the hook alone. If a hoisted load must
be lowered by free-fall operation, the load must be kept below 1/5th of the total rated load and sudden
braking operations must be avoided.
6. The total rated load for the single top shall be the value obtained by subtracting 160kg from the total rated
load of the boom and must not exceed 3.0t.
LME. Reg: 361 TADANO 20t Rough Terrain
2. The weights of the slings and hooks are included in the total rated loads shown.
3. The total rated loads are based on the actual working radii into which are included the deflection of the
boom and the tyres.
4. The chart below shows the standard number of part lines for each boom length. The load per line should
not exceed 2.9t (for the main winch).
5. The total rated load for the single top shall be the value obtained by subtracting 120kg from the total rated
load of the boom and must not exceed 3.0t.
7. The 26.8m boom and the jib should not be used without the outriggers.
8. The boom must be kept inside a 2° area (1° each to the left and right) over front of the carrier when performing
“Over front” crane operations without the outriggers.
Approx. 2°
9. When creeping while hoisting a load, the swing brake should be applied, the load should be kept as close
to the ground as possible but not touching the ground and the speed should be kept at 1.6km/h or less. In
particular, any abrupt steering, starting or braking must be avoided.
10. Crane operations should not be performed when creeping while hoisting a load.
LME. Reg: 361 TADANO 20t Rough Terrain
CRANE SPECIFICATIONS
TR-200M-4-00107
TR-200M-4-00107
Suspension:
Front Parallel leaf spring type
Rear Parallel leaf spring type
Steering:
Fully hydraulic power steering – With reverse steering correction
mechanism
Brake System:
Service brake: Hydro-pneumatic brake
Disk brake
Parking brake: Mechanically operated, internal expanding
duo-servo shoe type acting on drum at
transmission case rear.
Auxiliary brake: Electro-pneumatic operated exhaust brake
Auxiliary braking device for operations
Electrical system:
12 V DC. 2 batteries of 24V (120Ah)
Tyres:
Front: 14.00R24✮✮✮(OR)
Rear 14.00R24✮✮✮(OR)
Cab:
Two-man type – With sun visor and trim
Rubber mounted type
Fully adjustable seat (with headrest and seat belt)
Adjustable handle (tilt, telescoping)
Roof windshield lock warning
Safety Devices:
Emergency steering device
Spring lock device
Rear wheel steering lock device
Engine over-run alarm
Overshift prevention device
Parking brake alarm