Professional Documents
Culture Documents
Page 1 of 6
WCDMA RAN, Rel. WCDMA 16, Operating Documentation, Issue 04 (HTML) > Install >
BTS > Installing Flexi Multiradio Base Station and Flexi Multiradio 10 Base Station
Optional Items
https://online.networks.nokia.com/pic/infocenterproxy/wcdma16_issue04_... 5/18/2016
Installing GPS Antenna Kit (FYGA) or GPS GLONASS Receiver Antenna... Page 2 of 6
Follow the general guidelines for locating the GPS/GNSS antenna to provide safe and clear satellite visibility. Se
section Satellite visibility below for more details.
Satellite visibility
Note that a 180º clear sky view is the optimum case from the signal quality and accuracy point of view. If the cle
sky view is smaller than 180º (for example urban canyons), the GPS/GNSS receiver operation might suffer from
poor satellite visibility, depending on the sky view angle and location on the globe (especially latitude). The
GPS/GNSS receiver might be operational, especially after the survey, even with smaller than a 180º sky view,
however, this cannot be guaranteed. Furthermore, the survey time might be longer and the accuracy of the PPS
signal poorer than with a full 180º sky visibility.
https://online.networks.nokia.com/pic/infocenterproxy/wcdma16_issue04_... 5/18/2016
Installing GPS Antenna Kit (FYGA) or GPS GLONASS Receiver Antenna... Page 3 of 6
Procedure
https://online.networks.nokia.com/pic/infocenterproxy/wcdma16_issue04_... 5/18/2016
Installing GPS Antenna Kit (FYGA) or GPS GLONASS Receiver Antenna... Page 4 of 6
2. To attach the kit to a pole, use the bands and fasten them with screws.
The following table presents the GPS/GNSS pole mounting band cutting rule.
Note that the 25 mm (0.9 in) bending lengths for both ends are included in the cutting lengths.
The metal band folds must be inwards folded and so that folds are compressed against the pole while tightening the band.
https://online.networks.nokia.com/pic/infocenterproxy/wcdma16_issue04_... 5/18/2016
Installing GPS Antenna Kit (FYGA) or GPS GLONASS Receiver Antenna... Page 5 of 6
Tip: To ease the tightening of the bands, locate the worm screw on the other side of the pole than the fastener.
3 Secure the GPS/GNSS receiver using the mounting kit locking nut.
7 Connect the other end of the GPS/GNSS cable to the Sync In port on the System Module front panel.
Expected outcome
https://online.networks.nokia.com/pic/infocenterproxy/wcdma16_issue04_... 5/18/2016
Installing GPS Antenna Kit (FYGA) or GPS GLONASS Receiver Antenna... Page 6 of 6
Id: DN09142359 © 2016 Nokia Solutions and Networks. All rights reserved.
https://online.networks.nokia.com/pic/infocenterproxy/wcdma16_issue04_... 5/18/2016