Professional Documents
Culture Documents
When you are finished PCs on the Student VLAN should be able to ping each other and so
should the PCs on the Faculty VLAN. The Admin PC should be able to SSH into S1 and S2
from the command prompt (Eg. PC>ssh -l admin 192.168.99.2)
PCs
S1 & S2
1. name: S1, S2
8. SSH version 2
13. Interface VLAN 99: S1-IP address 192.168.99.2, S2-IP address 192.168.99.3
Figure 7: Create Vlan and assign the name for the Vlan and assign the IP address to Vlan 99
Figure 8: Assign the port for Vlan 10, Vlan 20 and vlan 99 for Switch1
Figure 9: G0/1 switchport port-security and mac-address sticky configuration and saving the configuration
Figure 11: Create Vlan and assign the name for the Vlan
and assign the IP address to Vlan 99 & configure the F0/1 as a trunk port
Figure 12: Assign the port for Vlan 10, Vlan 20 and vlan 99 for Switch 2
S1 Only
Take a screenshot of all the steps together with your final results and attach with the
Learning activity and submit it to your Trainer/Assessor.
Answer:
What I have learnt with this activity first is on how to set the IP address and default gateway
address on each PC and on how to set the basic configuration for the Switches. In this
activity it helps me on how to configure the switched with the VLAN and trunking. It shows
how to create each Vlan (vlan 10, vlan 20 and vlan 99) and to assign name as the vlan name
and to assign the ports to vlan. I’ve learnt also how to configure fasthethernet as a trunk port.
Lastly I learn what the switchport Port-Security, sticky is and Mac address sticky, it means
that if you connect any device to the switchport it will automatically store permanently.