EXAMPLE 3 Determine the voltage drop across each resistor in the circuit of Figure. EXAMPLE 3 EXAMPLE 3 EXAMPLE 3 EXAMPLE 3 By using the voltage divider formula to find the voltages EXAMPLE 3 EXAMPLE 3 Now apply the voltage divider formula to the R5 and R6 to find the V5 and V6. Review Determine the voltage drop across each resistor in the circuit of Figure. VOLTAGE DIVIDERS WITH RESISTIVE LOADS The voltage divider in figure a produced an output voltage Vout of 5V because the two resistors are of equal value. This voltage is the unloaded output voltage. When a load resistor RL is connected from the output to the ground as shown in figure b, the output voltage is reduced by an amount that depends on the value of RL. The load resistor is in parallel with R2. VOLTAGE DIVIDERS WITH RESISTIVE LOADS The larger RL is compared to R2, the less the output voltage is reduced from its unloaded value as shown in figure. VOLTAGE DIVIDERS WITH RESISTIVE LOADS Determine the unloaded output voltage of the voltage divider in Figure? and find the loaded output voltages of the voltage divider for the following two values of load : RL = 10 kΩ and RL = 100 kΩ. VOLTAGE DIVIDERS WITH RESISTIVE LOADS V(unloaded) =? V(loaded) =? RL = 10 kΩ RL = 100 kΩ VOLTAGE DIVIDERS WITH RESISTIVE LOADS VOLTAGE DIVIDERS WITH RESISTIVE LOADS VOLTAGE DIVIDERS WITH RESISTIVE LOADS VOLTAGE DIVIDERS WITH RESISTIVE LOADS VOLTAGE DIVIDERS WITH RESISTIVE LOADS VOLTAGE DIVIDERS WITH RESISTIVE LOADS REVIEW Determine the unloaded O/P voltage with respect to ground. Determine the O/P volt with a 10 kΩ load resistor.