Professional Documents
Culture Documents
ZTE ZXMW NR8120D 1+0 Configuration Guide
ZTE ZXMW NR8120D 1+0 Configuration Guide
Configuration (1+0)
In LTE Smartfren Project Ph2C, NR8120D equipment will use more sites; this
guideline will descript how to configure 1+0. After finish installation, we can
1+0 Connection
IDU 1 1 2
ODU 1 1 2
IF Cable 1 1 2
Single Polarization Antenna 1 1 2
Component Material
IDU View
Log in IDU
3 Configuration Procedure
3.1 Configure Parameter
Parameter
IDU Version
Setting time
VLAN NMS
Create Network Management VLAN ID base on Vlan planning. Exp Vlan Mng planning is
41
Setting Network Management Bandwidth 2M
Radio Modulation
ACM Function
Radio Parameter
Channe
l
Bandwidt Spacin Sub Channe
Freq h g band l Low High
1 14417 14907
2 14445 14935
3 14473 14963
4 14501 14991
A
5 14529 15019
6 14557 15047
7 14585 15075
8 14613 15103
15GHz 28 490000
9 14641 15131
10 14669 15159
11 14697 15187
12 14725 15215
B
13 14753 15243
14 14781 15271
15 14809 15299
16 14837 15327
Frequency scanning
Fill Start frequency and end frequency refer to DGPT Channel list range. But only for the RX.
For Exp you are in Low position and the sub-band is A, fill the star frequency with 14907
and end frequency with 15103, then fill the Sweep Step fill 28MHz then click Start.
Port Configuration
Configure Status port become Enable if you want to active the port
Configure Status port become Disable if you want to non active the port
Configure Auto-Negotiation Status become Enable
Select the port that you want configure then click Modify
Port configuration
Configure the port type Access or Trunk then click Apply, Exp Gbe 1
Create the Vlan ID at the VLAN ID column refer to Vlan MW & EnodeB plan and click Add.
Exp we will add Vlan 200, write 200 at column VLAN ID then click Add.
After that you must also create the VLAN at Radio port. Exp we use port 5 as radio port.
Click AIR-5-1 then click Modify
Create the Vlan ID at the VLAN ID column refer to Vlan MW & EnodeB plan and click Add.
Exp we will add Vlan 200, write 200 at column VLAN ID then click Add.
Finish