This document provides instructions for editing a road profile geometry in Civil 3D to address design check warnings. The steps include graphically editing the profile by moving curve grips and points of intersection, using the Profile Layout Tools toolbar to insert new points of intersection, and modifying values in the Profile Grid View. The completed exercise optimizes the design profile relative to the existing surface profile and removes warnings.
This document provides instructions for editing a road profile geometry in Civil 3D to address design check warnings. The steps include graphically editing the profile by moving curve grips and points of intersection, using the Profile Layout Tools toolbar to insert new points of intersection, and modifying values in the Profile Grid View. The completed exercise optimizes the design profile relative to the existing surface profile and removes warnings.
This document provides instructions for editing a road profile geometry in Civil 3D to address design check warnings. The steps include graphically editing the profile by moving curve grips and points of intersection, using the Profile Layout Tools toolbar to insert new points of intersection, and modifying values in the Profile Grid View. The completed exercise optimizes the design profile relative to the existing surface profile and removes warnings.
• Edit using the Profile Layout Tools toolbar and the Grid View vista. The completed exercise
1. Open the /Iowa City 04_09/04 Design
Models/road design.dwg drawing.
2. Zoom to the McCollister Blvd Profile View and
review the warnings.
Profiles: Edit profile geometry Page | 1
3. Select the McCollister Blvd design profile. • Select the point of intersection grip for the curve at station 15+50 and relocate to circle center point at station 19+50. • Select the curve circular grip and drag to increase the curve radius.
4. On McCollister Blvd design profile, the first
vertical curve, drag the circular grip to increase the curve radius to remove the warning.
5. From the Profile Contextual tab > Modify Profile
panel > click Geometry Editor. The Profile Layout Tools toolbar is displayed.
6. Click Insert PVI and click to snap to the
existing surface profile at station 29+42.
7. Open the Profile Grid View vista. On line 4,
modify the Grade In to be 0.50%, and then close the Panorama.
Profiles: Edit profile geometry Page | 2
8. Pan to the Sycamore Heights alignment, drag the start point to snap to McCollister Blvd alignment, and use the Nearest Object Snap.
9. Pan to the Sycamore Heights Profile View and
review the warnings.
10. Review and then dismiss the Horizontal
Change Notifications. In the Profile Contextual tab > Notification panel, click Horizontal Changes and choose Dismiss All Notifications.
11. Select the Profile View, and from the
Contextual tab > expanded Launch Pad panel, select Add Crossings To Profile View. • Select the McCollister Blvd alignment and press Enter. • In the Crossing To Profile View dialog, deselect Existing Ground. Click OK.
12. Drag the Sycamore Heights design profile start
to snap to the Crossing Marker.
Profiles: Edit profile geometry Page | 3
13. Adjust the curves point of intersection grip positions to optimize earthwork relative to the existing surface profile.
14. From the Profile Contextual tab > Modify Profile
panel, click Geometry Editor.
15. In the Profile Layout Tools toolbar, click Insert
PVI and click to snap to the existing surface profile at station 15+88