CODE : 50-389-xxx/100 A weather resistance polyurethane enamel based on polyol resin and TYPE : aliphatic Polyisocyanate as Hardener CHARACTERISTICS : 1. Excellent gloss and retention 2. Excellent durability on chemicals and marine environment 3. Good applicability 4. High-build coatings 5. Provide hardness, abrasion resistance 6. Good adhesion to epoxy primer and polyurethane top coat 7. Quick drying COLOUR : White and colours APPEARANCE : Full gloss and Semi gloss APPLICATION METHOD : Airless spray and Brush THINNER : Retan Thinner THINNING RATIO : Airless Spray → (0 - 10 % by weight) Nozzle pressure : Not less than 10 Mpa Nozzle Tip : No. 163-515~621 Brush/Roller → (0 - 5 % by weight) Power mix thinner if required *Too much thinning results sagging and slower cure. MIXING RATIO : Base / Hardener 10 / 1 (by weight) POT LIFE : At temperature 5°C 20°C 30°C 8 hrs 5 hrs 3 hrs DRY FILM THICKNESS : 35 microns / coat THEORITICAL COVERAGE : 16.7 m2/L at 35 microns DFT 14 m2/Kg at 35 microns DFT *Practical coverage vary depending on loss factors. DRYING TIME : At temperature 5°C 20°C 30°C Surface dry 2 hrs 1 hrs 1 hrs Touch Dry 16 hrs 10 hrs 6 hrs OVERCOATING INTERVAL : At temperature 5°C 20°C 30°C Minimum : 24 hrs 16 hours 10 hrs Maximum : 7days 7 days 7 days VOLUME SOLID S : 58.00% SPECIFIC GRAVITY : 1.14 g /ml (mixture) FLASH POINT : Base : 28°C Hardener : 4°C TEMPERATURE RESISTANCE : Non-continuous : 200°C, Continuous : 100°C 5 Kg (4.06 L) Base in 5 liters container PACKAGING : 0.5 Kg (0.47 L) Hardener in 1 liter container SURFACE PREPARATION : - All surface to be coated should be completely clean, dry and free from contamination. - Remove Salt and other waters-soluble contaminants by fresh water. - Remove Oil and grease with suitable detergent or solvent - Remove rust , mill scale and others loose materials completely by abrasive blasting