Professional Documents
Culture Documents
2
3
Neck stretch measurement must meet as per
given measurement sheet
Measurement minus is not allowed
Required force to achieve minimum neck
stretch
Size 50 to 80 86 to 188 Adult
Max. required 12N (1.2 15N (1.5 15N
force (N) kg) kg) (1.5 kg)
4
User or Use Requirement
7
Waist Area
Visible length (functional) should be 20
cm in waist relax position
Visible length can not 1 mm plus than
20 cm. For safe side we will keep
17cm – 18 cm
For non functional we will be less than
14 cm or will follow spec
8
Non-functional cord, chain, ribbon, string or tape, made of any textile or
non-textile material including elastic material, with free end with or without
intended to be used to adjust the size of the garment opening or fasten the
garment itself
For baby club & young children draw cord is not allowed
Decorative cord shall not permitted at hood area baby club & young
children
For older children (size 140 & above) draw string is allowed but length
11
A minimum of 8 stitches through each is to
be used
Minimum removal force is 90N if diameter
is >6mm & 70N if <6mm
Two hole button not allow in Baby club &
young children
Result should be at button breakage point
Placement of button should be on uniform
place in placket area
12
Need to use Bingo card for hole button
For metal component need to follow
Data Sheet to set pinch setting
After each two hours need to check pull
test & pinch setting on mock-up (mock
up construction will be same as
approved sample)
Press fasten must unfasten with a force
between 10N – 20N
13
Bobbin thread should be contrast than
body fabric of button attach machine
from size 56 – 182.
Baby Club
Palomino
H&T
14
There can not be any sharpness of glitter print
Glitter/stone can not be removed easily
Should pass endurance wash test
Stone/stud need to paste on even place
15
Velcro need to attach by zigzag machine not
allowed single needle lock stitch.
16
Fusing machine need to calibrate prior to
each shift begin
Machine should be set as per proper time,
temperature & pressure by following data
sheet
Bond strength data need to be recorded
17
THANK YOU FOR YOUR PATIENCE !!
18