Professional Documents
Culture Documents
Oxyg
Technical specifications Version 1.0
Top View
Dimensions are in millimetres (± 0.15 mm). Bottom View Side View
PERFORMANCE
Output µA @ 20.9%O2 190 to 240
Performance Response time
Output t90 (s) from 20.9% to 0%
μA @ 20.9% O O2 2 < 15
190 to 240
Zero currentResponse time µA in N2 t90 (s) from 20.9% to 0% O 2 <<152.5
Linearity Zero current % O2 deviation μA @in10%N O2 2 <<2.50.6
Linearity % O2 deviation @ 10% O2 < 0.6
LIFETIME
Lifetime Output drift % change in output @ 3 months <1
Output drift Operating life % change in output
Months@ 385%
until months
original output in 20.9% O 2 > 12<1
Operating life months until 85% original output of 20.9% O2 > 12
O2-A1 P erf
Perf ormance Da
erformance
Figure 1 Temperature Dependence in Air
ta
Data
Figure 2 Temperature Dependence in Air
O2-A1 Perf
Performance Da
erformance ta
Data 110
Figure 2 shows the variation
C) output at 20oC)
105
.
O2-A1 Perf
Performance Da
erformance ta
Data
Figure 2 Temperature Dependence in Air
110
100
This data is taken from a
typical
Figure 2batch
Figure shows of the
1 shows sensors.
thevariation
variation of sensor output in clean
at 20oto
of sensor
air dueoutput in clean changes.
to temperature air
(relative
Theto mean
due and changes
temperature ± 95%
tion
"-95 conf."
100
90 of typical
sensorbatch
outputof in clean air
sensors.
ica
105
Mean . The mean and ± 95%
95
85
"+95 conf." This data is taken
confidence from are
intervals a
-30 -20 -10 0 10 100 20 30 40 50typical
shown.batch of sensors.
"-95 conf."
Temperature (oC) 90
ica
"+95 conf."
23.0
85
"-95 conf." shown.
-30 -20 -10 0 10 20 30 40 50 Many gas detectors use either
Specifica
Figure
22.5
2 Aspirated Gas Transients 90
Temperature (oC) pumps or hand aspirators to
sample gases remotely.
22.0 Pressure transients, caused
Figure 3 Aspirated Gas Transients 85
Specif
Temperature (oC)
22.5
21.0
pumps or hand aspirators to
Alphasense
sample gasesoxygen sensors
remotely.
Specif
21.5
60detectors into alarm.
transients.
Output (%O2)
0 10 20 30 40 50
20.0
Time (s) pressure transients.
21.0
19.5
Alphasense oxygen sensors
Figure
20.5 4 Response to Hydrogen are 100% tested for pressure
21.5
19.0 transients.
Hydrogen reduces the
hnical
20.0 0 10 20 30 40 50 60
21 oxygen sensor output by
Time (s)
19.5
6.5%.
20.5
Figure
19.0 4 Response to Hydrogen
Technical
hnical
0 10 20 30 40 50 60
Output (%O2)Output (%O2)
20
21.5
Time (s)
Hydrogen reduces the
Figure
19.5
21
3 Response to Hydrogen oxygen sensor output by
Figure194 Response to Hydrogen 6.5%.
20.5
Tec
21.5
Hydrogen reduces the
18.5
20
21 oxygen sensor output by
18
19.5 6.5%.
20.5
17.5
19
Tec
Output (%O2)
Alphasense
17.5 Ltd. For Application Notes visit “www.alphasense.com”.
In18.5 0 of continued
the interest 0.2 0.4 improvement,
product 0.6 we0.8 1 right to 1.2
reserve the 1.4 features
change design 1.6and specifications
1.8 2
without prior notification. The data contained in this
document is for guidance only. Alphasense Ltd accepts no liability for any consequential losses, injury or damage resulting from the use of this document or the informa-
tion contained within. ( ©ALPHASENSE LTDConcentration H (%)
) Doc. Ref. O2-A1/JUL17
18 2
For
17.5further information on the performance of this sensor, on other sensors in the range or any other subject, please contact
Alphasense
0 Ltd.
0.2 For0.4
Application
0.6 Notes
0.8 visit “www.alphasense.com”.
1 1.2 1.4 1.6 1.8 2
Concentration H2 (%)
In the interest of continued product improvement, we reserve the right to change design features and specifications without prior notification. The data contained in this
document is for guidance only. Alphasense Ltd accepts no liability for any consequential losses, injury or damage resulting from the use of this document or the informa-
tion contained within. ( ©ALPHASENSE LTD ) Doc. Ref. O2-A1/JUL17
AtFor further
the end of theinformation
product’s life,on
do the performance
not dispose of this sensor,
of any electronic on other or
sensor, component sensors in the
instrument range
in the or any
domestic other
waste, subject,
but contact theplease contact
instrument manufacturer, Alphasense or its distributor for disposal
Alphasense
instructions. NOTE: Ltd. For Application
All sensors are tested atNotes
ambientvisit “www.alphasense.com”.
environmental conditions, with 47 ohm load resistor, unless otherwise stated. As applications of use are outside our control, the information provided is
given without
In the interestlegal responsibility.
of continued product Customers should
improvement, test under
we reserve their
the right own conditions,
to change to ensure
design features that the sensors
and specifications areprior
without suitable for their
notification. Theown
datarequirements.
contained in this
In document
the interest of guidance
is for continued product
only. improvement,
Alphasense Ltd acceptswenoreserve theany
liability for right to change losses,
consequential designinjury
features and specifications
or damage resulting from without prior
the use of notification.
this document Theinforma-
or the data contained in this document is for guidance only.
tion contained
Alphasense Ltd within.
accepts( ©ALPHASENSE
no liability forLTD
any) consequential
Doc. Ref. O2-A1/JUL17
losses, injury or damage resulting from the use of this document or the information contained within.(©ALPHASENSE LTD) Doc. Ref. O2-A1/JUL22
T: +44 (0)1376 556700 E: sensors@alphasense.com W: www.alphasense.com For further information on the performance of this sensor, on other sensors in the range or any other
subject, please contact Alphasense Ltd. or visit our website at “www.alphasense.com”.