Fee evil
ECC Ref. Code No. RO3-1102-0079
EFREN L. ALVAREZ, D. Hum.
(Owner/Manager
ELA AGRICULTURAL ENTERPRISES
Brgy: Villa Isla, Science City of Nuftoz
Nueva Ecija
Dear Mayor Alvarez,
This refers to your application for an Environmental Compliance Certificate (ECC) for the
proposed Livestock (Piggery Farm) Project to be located at Bray. Villa Isla, Science
City of Munoz, Nueva Ecija.
After satisfying the requirements of the said application, this Office has decided to grant
an Environmental Compliance Certificate (ECC) to the above-mentioned project.
In issuing this CERTIFICATE, it should be understood that the same is a PLANNING
TOOL and not a PERMIT, It is expected that you will diligently secure pertinent
PERMITS/CLEARANCES from all concerned government agencies.
With the issuance of this ECC, you are expected to implement the measures presented
in the Initial Environmental Examination (IEE) Checklist, intended to protect and mitigate
the project's adverse impacts on community health, welfare and the environment.
Environmental considerations shall be incorporated in all phases and aspects of the
project. You may proceed with project implementation, after securing all the necessary
permits from the pertinent government agencies. This Office will be monitoring the
project periodically to ensure your compliance with the stipulations cited in the attached
Ecc.
Please be guided accordingly.
Very truly yours,
Al
LORMELYN E. CLAUDIO
Regional Director sadENVIRONMENTAL COMPLIANCE CERTIFICATE
(Issued under Presidential Decree 1586)
RO3-1102-0079
THIS IS TO CERTIFY THAT ELA AGRICULTURAL ENTERPRISES is granted
this Environmental Compliance Certificate (ECC) for the proposed Livestock (Piggery
Farm) Project to be located at Brgy. Villa Isla, Science City of Muiioz, Nueva Ecija,
by the Department of Environment and Natural Resources (DENR), through the
Environmental Management Bureau, Region Ill.
SUBJECT ONLY to the conditions and restrictions set-out in this ECC and in the
attached document labeled as Annex A. Recommendations have been provided in
Annex B as guidance to concemed government agencies and local government units
for consideration in their decision making.
't shall cover the operation of a piggery farm (Gi<3__-D.4.a) with a population of
three thousand (3,000) heads to be housed in three (3) units tunnel ventilated
building in an area of two hundred twenty two thousand six hundred thirty six
(222,636) square meters the boundary of which is defined under TCT No. NT-21763.
Project Geographical Coordinates/Location
North Latitude ~ 18°46'26.5"
East Longitude = - 120°52'45.7"
This certification is issued in compliance to the requirements of Presidential
Decree No. 1586, in accordance to Department Administrative Order No. 30-2003. The
Bureau, however, is not precluded from reevaluating, adding, removing, and correcting
any deficiencies or errors that may be found after issuance of this certificate.
ce
Issued at City of San Fernando, Pampanga, this FEB 28 201
Recommending Approval:
vw
DENNIS 0. CELESTIAL
Chief, Environmental impact Assessment Approved by:
& Management Division Ir
LORMELYN E. CLAUDIO
Regional Director
Ece-R03-1102-0079
{ECC is only a Planning Tool and not a Permit)
Livestock (Piggory Farm) Project
ELA AGRICULTURAL ENTERPRISES.
Paget of 5SWORN STATEMENT OF OWNER/AUTHORIZED REPRESENTATIVE
' &. SVANGELICTR, proponent of this i
located in VILLA [SR _- SCIBNE TY OF MUO? takes full responsibility in
complying with all conditions contained in this Environmental Compliance Commitment
(Environmental Compliance Certificate or ECC).
nature
TIN _208 - 0S6~- S97
26200
Subscribed and sworn to before me thige® 2 ® day of 2014, the
above-named affiant taking oath presenting Residence Certificate No. _O4281000
issued on_1 [uuu 2011 at Somme ae
Doe. No.
Page No.
Book No.
Series of 2011
ECC-ROS-1102-0079EcC-R0s-1102-0079
ON
Annex A
CONDITIONS
A. ENVIRONMENTAL MANAGEMENT and MONITORING PLAN (EMMoP)
1. All mitigating measures in the submitted Initial Environmental Examination
(IEE) Checklist shall be implemented;
2. Implement proper housekeeping practices to prevent generation of obnoxious
odor and proliferation of flies in the project area and adjacent vicinities;
3. Ensure that no wastes shall be burned in the area and that ecological waste
management measures such as waste segregation, minimization, re-use,
composting, etc., are implemented
4. The Wastewater Treatment Facility (WTF) shall operate effectively to ensure
compliance with the effluent standards of the DENR;
5. Provide an accessible walk-way leading to the WTF or effluent outfall area
and the periphery of the project site for easy conduct of monitoring and water
sampling.
6. Mortality pit shall be provided with adequate lining to prevent contamination of
groundwater.
7. Planting of trees shall be undertaken either within the project site and/or in
other areas as part of the proponent's social and environmental program;
B, GENERAL CONDITIONS
8. The proponent shall comply with the requirements of other environmental
laws, i.e. Republic Act (RA) 8749 or “The Clean Air Act of 1999", RA 6969 or
“Toxic Substances and Hazardous and Nuclear Wastes Control Act of 1990”,
RA 9003 or “Ecological Solid Waste Management Act of 2000” and RA 9275
or "Clean Water Act of 2004’, among which are
Facilities (WPSCF)
Designate Pollution Control Officer (PCO)
Submit quarterly Self Monitoring Report (SMR)
Submit semi-annual Compliance Monitoring Report (CMR)
Register as Hazardous Waste Generator
/e Secure Permit to Operate Air Pollution Source Control Installations
eg (APSCl) and Discharge Permit for Water Pollution Source/Control
9. Copy of Environmental Compliance Certificate (ECC) shall be posted in a
conspicuous area in the project site;
10.An Abandonment Plan shall be submitted to this Office ninety (90) days prior
to the project's abandonment. The plan shall include remediation, clean-up
and rehabilitation measures of contaminated areas and proposed alternative
project or activity suitable in the area.
11.The proponent shall set up a Multipartite Monitoring Team (MMT) composed
of representatives from the proponent, concerned LGU, stakeholders and this
Office within sixty (60) days upon receipt of this Certificate. Likewise, an
Environmental Monitoring Fund (EMF) shall be established to cover all costs
attendant to the operation of the MMT;
30f5‘Non-compliance with any of the provisions of this certificate shall be a sufficient cause for the
et | cancellation or suspension of this certificate and/or imposition of a fine in an amount not t0
EC0-R03-1102.0079
(ECC is onty a Planning Tool and not a Permit)
12.The proponent shall formulate and implement Information Education
Campaign (IEC) programs incorporating recommended environmental
management practices through but shall not be limited to various advertising
media (i.e., posters, billboards, etc)
13.That should there be any complaint from the community related to
environmental sanitation problem brought about by the piggery farm's
operation, the proponent shall be held responsible to address such problem;
14.The proponent shall allow inspection or monitoring that will be conducted by
this Office anytime in coordination with concemed groups;
RESTRICTIONS
15.Any expansion or modification of the approved project shall be subject to new
EIA requirement; and
16.In case of transfer of ownership of this project, these same conditions and
restrictions shall apply and the transferee shall be required to notify this Office
within fifteen (15) days as regards to the transfer of ownership.
exceed Fifty Thousand Pesos (50,000.00) for every violation thereof.
OR No. 6853066,
Proposed fee 4,000
Date : February 114, 2011 eas.
[RE D BY
| eRe
re 2baly
Page 4 ofAnnex B
PROJECT ASSESSMENT PLANNING TOOL
For the assistance of the Proponent and government agencies concerned in the
management of the project and for better coordination in mitigation on the impact of the
project on its surrounding areas and to the environment.
By way of recommendation, the following have been taken notice by the
undersigned and are forwarding these recommendations to the parties and authorities
concerned for proper appreciation and action.
RECOMMENDATIONS TO CONCERNED oe
GOVERNMENT AGENCY/LGUs | AGENCIES/ENTITIES
1. Provision of drainage canal, concrete culverts, and| | City/Municipal
other flood control measures to adequately receive and| | Engineers Office/
channel the run-off of silt-laden rain water to the nearby |_| Proponent
receiving body of water.
2. Provision of a segregation, collection, recycling, and| | LGU/Proponent
disposal mechanism for solid waste.
3. Compliance with the Sanitation Code of the Philippines, || DOH, DOLE- Bureau
Labor Code of the Philippines including Occupational | | of Working Condition
Health and Safety Standards and Building Code of the | | and Municipal
Philippines. Planning & Devt
Office/GU/Proponent
4, Observe and protect legal easement along rivers and| | HLURB/DENR-LMS/
creeks i.e. establishment of linear park along the| | LGU/Proponent
easement, construction of boundary wall to prevent
encroachment of the required legal easement of
adjacent creek/river and regular clean-up and desilting
of adjacent creek/river to prevent clogging.
ENVIRONMENTAL PLANNING RECOMMENDATIONS FOR THE PROPONENT
The following are recommendations for the Proponent for the protection of the project
area and the affected environment. It is strongly recommended that the same be
strictly complied by the Proponents.
/1. Ensure efficient use of energy and other resources, i.e. rainwater collecting
reservoir, pressure cleaners, nozzles, scraper systems, automatic drinking system,
use of partially/fully elevated slatted floorings, etc.
2.Ensure that the best available technologies shall be adopted and promote the use of
renewable energy, i.e. solar cell panel, solid/liquid separator, biogas digester with
methane recovery, tunnel ventilated pig buildings to minimize use of water, prevent
obnoxious odor and flies and ensure compliance with the effluent standards
3. Donate collectible recyclables to Local Government Unit (LGU)
4. Close monitoring by the proponent to maintain a high level of safety & efficiency to
immediately address any environmental hazards or change that may take place
5. Mitigating measures in the submitted EMP shall be implemented to include the
regular and proper cleaning of the area, using disinfectants to prevent proliferation of
flies, proper collection of pig manure and proper disposal of dead pigs.
For dissemination and proper action of the parties concemed
DENNIS 0. CELESTIAL LORMELYN E. CLAUDIO
Chief, EAMD f Regional Director
ECO-RO3-1102.0079
Page Sof 5