Professional Documents
Culture Documents
input xlr
SPST SW
rear view (solder
side)
3
to put the ba6a at a usable output volume for modern recording , it is a good idea to pad the output from the get go .
for the output configuration we will use the pad shown in the awa schematic of their ba6a type compressor.
the 10 db pad consists of two 330 ohm resistors and one 470 ohm resistor .
RED
GREEN
BA6A heater DC refrence circuit .
installing the on board original
DC REFRENCE circuit.
input hi +
output tx
red
to attenuator INPUT +
back of DPDT switch
or
to c15 6H6 side
the normal compressor response frequency.
.001@600v 0.2@600v
replace C14 and C15 with this switch set up .
.001@600v 0.2@600v
this setup in tandem with the xlr pin 1 ground lifts with virtually eliminate ANY hum or noise due to
interfacing issues .
shown here is the jensen JT-11P-1 you may use almost any 1:1 transformer
red
TO 20DB PAD OR PCB XLR IN 2
1 2
JENSEN - JT-11P-1
3
TO 20DB PAD OR PCB XLR IN 3
brown
yellow
1 2
back of DPDT switch JENSEN - JT-11P-1
3
orange
brown