Professional Documents
Culture Documents
Version: 01
Released on: 19.Mar.2019
CONTENTS
1. Process Information................................................................................................................................. 2
2. Equipment ............................................................................................................................................... 2
3. Make-Up .................................................................................................................................................. 2
4. Application Guidelines ............................................................................................................................. 2
5. Material No. for Make-Up and Maintenance Products ............................................................................ 3
6. Document History .................................................................................................................................... 3
Page: 1
Anokleen®
Chemical cleaner for lead alloy anodes of chromium acid
containing solutions
1. Process Information
Anokleen® is a powder used to make a solution to provide an effective immersion method of removing scale
that forms on lead alloy anodes during chromium plating.
2. Equipment
Tank Steel.
Heater Steel immersion heater.
Agitation Increases the cleaning effect.
Exhaust Not necessary.
3. Make-Up
Attention:
The solution heats up during make-up!
Anokleen® is very alkaline (caustic)!
During make-up and usage protect eyes and hands!
4. Application Guidelines
Effect
Remove sludge and encrustation from lead anodes by a simple immersion (dip) process.
The necessary time required to clean an anode depends on the thickness of the scale present on the anode.
Normally at room temperature the anodes should be immersed in the Anokleen® bath for 20-30 minutes to
loosen the scale sufficiently that it can be brushed off easily, while still wet.
By increasing the temperature to as high as 55°C in creases the rate of cleaning so that the scale can be
removed after only 5 – 10 minutes of soaking.
If so desired, the anodes can stay for a longer period time or even overnight in the Anokleen® bath, without
excessive chemical attack of the anodes.
Page: 2
Anokleen®
Chemical cleaner for lead alloy anodes of chromium acid
containing solutions
Procedure
When handling any chromium bath make sure you adhere to all regulations regarding chromic acid
6. Document History
This sheet shall serve for your information. The content of the sheet is based on our best Atotech Deutschland GmbH
knowledge. We do not undertake any duty to advise. The contents of the sheet shall not P.O. Box: 21 07 80
be considered as an agreement on condition and quality of the goods delivered. 10507 Berlin, Germany
The decision to use our products for its production purposes is the responsibility of our Erasmusstraße 20
customer. We can accept liability only for the quality of our products at delivery. If 10553 Berlin, Germany
difficulties arise in the application of our products, we propose that you contact our phone +49 (0) 30 349 85 0
technical service department. fax +49 (0) 30 349 85 777
Page: 3