Professional Documents
Culture Documents
Used names:
ISP as P for MPLS: ISP router
WAN routers as PE for MPLS: WAN-W1, WAN-W2, WAN-E1, WAN-E2
Nexus nodes as CE for MPLS: NX-W1/W2, NX-E1/2
4. Configure ISP router BGP 65001 family ipv4 mdt and peer it with WAN routers using
loopback 0, ISP is route reflector for wan peers.
5. Configure WAN routers BGP 65001 family ipv4 mdt and peer it with ISP router using
loopback 0
6. On all WAN and ISP routers configure ip pim rp-address 1.1.1.1 override
7. On all WAN routers configure additional loopback1.
7.1 Assign it in vrf eve.
7.2 Enable ip pim sparse-mode
7.3 Assign ip addresses
WAN-W1 11.11.11.11/32
WAN-W1 22.22.22.22/32
WAN-W1 33.33.33.33/32
WAN-W1 44.44.44.44/32
7.3 WAN-W1 and WAN-W2 loopback1 must be assigned in ospf 20 vrf eve area 1
7.4 WAN-E1 and WAN-E2 loopback1 must be assigned in ospf 20 vrf eve area 0
F Nexus Multicast
1. Configure Nexus NX-W1/W2, NX-E1/E2 and NX-EE1/EE2 L3 interfaces in ip pim sparse mode
2. Configure Nexus NX-W1/W2, NX-E1/E2 and NX-EE1/EE2 loopback100 in ip pim sparse mode
3. Configure all Nexus with RP: ip pim rp-address 1.1.1.255 group-list 224.0.0.0/4 override
G Nexus VXLAN
1. Configure Nexus NX-W1/W2 looback100 with secondary ip 30.30.30.30/32
2. Configure Nexus NX-EE1/EE2looback100 with secondary ip 60.60.60.60/32
3. Configure Nexus NX-W1/W2 and NX-EE1/EE2
3.1 Configure vlan 10 in vni segment 10000
3.2 Configure vlan 20 in vni segment 10001
3.3 Configure nve1 interface with source loopback100
3.4 Configure nve1 interface as member for vni segments 10000-10001 and mcast group
232.1.1.1
Verify ip mroute on NX-W1/W2 and NX-EE1/EE2, you must see secondary loopback in mroutes nve
members.
NOW, if you can ping from VPC-1011 to VPC10-12 and VPC20-10 to VPC20-12, YOU Lab is
completed!!!
Good Luck