Professional Documents
Culture Documents
Page 1 of 18
SDS No. : 41762
V004.0
Tangit PVC-U Special Adhesive (formerly known as Tangit ALL Revision: 22.02.2018
PRESSURE) printing date: 17.05.2018
Replaces version from: 04.04.2017
Contains:
Tetrahydrofuran
Butanone
Cyclohexanone
1.2. Relevant identified uses of the substance or mixture and uses advised against
Intended use:
Pipe adhesive
Great Britain
ua-productsafety.uk@henkel.com
Classification (CLP):
Flammable liquids Category 2
H225 Highly flammable liquid and vapor.
Skin irritation Category 2
H315 Causes skin irritation.
Serious eye damage Category 1
H318 Causes serious eye damage.
Carcinogenicity Category 2
H351 Suspected of causing cancer.
Specific target organ toxicity - single exposure Category 3
H336 May cause drowsiness or dizziness.
Target organ: Central Nervous System
Specific target organ toxicity - single exposure Category 3
H335 May cause respiratory irritation.
Target organ: respiratory tract irritation
Hazard pictogram:
For full text of the H - statements and other abbreviations see section 16 "Other information".
Substances without classification may have community workplace exposure limits available.
General information:
In case of adverse health effects seek medical advice.
Inhalation:
Move to fresh air, consult doctor if complaint persists.
Skin contact:
Rinse with running water and soap. Skin care. Remove contaminated clothes immediately.
Eye contact:
Rinse immediately with plenty of running water (for 10 minutes), seek medical attention from a specialist.
Ingestion:
Rinse mouth, do not induce vomiting, consult a doctor.
SDS No.: 41762 V004.0 Tangit PVC-U Special Adhesive (formerly known as Tangit ALL Page 4 of 18
PRESSURE)
4.2. Most important symptoms and effects, both acute and delayed
Vapors may cause drowsiness and dizziness.
After eye contact: Corrosive, may cause permanent damage to eyes (impairment of vision).
4.3. Indication of any immediate medical attention and special treatment needed
See section: Description of first aid measures
Additional information:
Cool endangered containers with water spray jet.
Hygiene measures:
Do not eat, drink or smoke while working.
Wash hands before work breaks and after finishing work.
SDS No.: 41762 V004.0 Tangit PVC-U Special Adhesive (formerly known as Tangit ALL Page 5 of 18
PRESSURE)
Valid for
Great Britain
Ingredient [Regulated substance] ppm mg/m3 Value type Short term exposure limit Regulatory list
category / Remarks
Tetrahydrofuran 100 300 Short Term Exposure EH40 WEL
109-99-9 Limit (STEL):
[TETRAHYDROFURAN]
Tetrahydrofuran Skin designation: Can be absorbed through the EH40 WEL
109-99-9 skin.
[TETRAHYDROFURAN]
Tetrahydrofuran 50 150 Time Weighted Average EH40 WEL
109-99-9 (TWA):
[TETRAHYDROFURAN]
Tetrahydrofuran 50 150 Time Weighted Average Indicative ECTLV
109-99-9 (TWA):
[TETRAHYDROFURAN]
Tetrahydrofuran 100 300 Short Term Exposure Indicative ECTLV
109-99-9 Limit (STEL):
[TETRAHYDROFURAN]
Butanone 300 899 Short Term Exposure EH40 WEL
78-93-3 Limit (STEL):
[BUTAN-2-ONE (METHYL ETHYL
KETONE)]
Butanone Skin designation: Can be absorbed through the EH40 WEL
78-93-3 skin.
[BUTAN-2-ONE (METHYL ETHYL
KETONE)]
Butanone 200 600 Time Weighted Average EH40 WEL
78-93-3 (TWA):
[BUTAN-2-ONE (METHYL ETHYL
KETONE)]
Butanone 200 600 Time Weighted Average Indicative ECTLV
78-93-3 (TWA):
[BUTANONE]
Butanone 300 900 Short Term Exposure Indicative ECTLV
78-93-3 Limit (STEL):
[BUTANONE]
Cyclohexanone Skin designation: Can be absorbed through the ECTLV
108-94-1 skin.
[CYCLOHEXANONE]
Cyclohexanone Skin designation: Can be absorbed through the EH40 WEL
108-94-1 skin.
[CYCLOHEXANONE]
Cyclohexanone 20 82 Short Term Exposure EH40 WEL
108-94-1 Limit (STEL):
[CYCLOHEXANONE]
Cyclohexanone 10 41 Time Weighted Average EH40 WEL
108-94-1 (TWA):
[CYCLOHEXANONE]
Cyclohexanone 10 40,8 Time Weighted Average Indicative ECTLV
108-94-1 (TWA):
[CYCLOHEXANONE]
Cyclohexanone 20 81,6 Short Term Exposure Indicative ECTLV
108-94-1 Limit (STEL):
[CYCLOHEXANONE]
Polyvinyl chloride 10 Time Weighted Average EH40 WEL
9002-86-2 (TWA):
[POLYVINYL CHLORIDE, INHALABLE
DUST]
Polyvinyl chloride 4 Time Weighted Average EH40 WEL
9002-86-2 (TWA):
[POLYVINYL CHLORIDE, RESPIRABLE
DUST]
Silicon dioxide 6 Time Weighted Average EH40 WEL
112945-52-5 (TWA):
SDS No.: 41762 V004.0 Tangit PVC-U Special Adhesive (formerly known as Tangit ALL Page 7 of 18
PRESSURE)
Valid for
Ireland
Ingredient [Regulated substance] ppm mg/m3 Value type Short term exposure limit Regulatory list
category / Remarks
Tetrahydrofuran 50 150 Time Weighted Average Indicative OELV IR_OEL
109-99-9 (TWA):
[TETRAHYDROFURAN]
Tetrahydrofuran 100 300 Short Term Exposure Indicative OELV IR_OEL
109-99-9 Limit (STEL):
[TETRAHYDROFURAN]
Tetrahydrofuran Skin designation: Can be absorbed through the IR_OEL
109-99-9 skin.
[TETRAHYDROFURAN]
Tetrahydrofuran 50 150 Time Weighted Average Indicative ECTLV
109-99-9 (TWA):
[TETRAHYDROFURAN]
Tetrahydrofuran 100 300 Short Term Exposure Indicative ECTLV
109-99-9 Limit (STEL):
[TETRAHYDROFURAN]
Butanone 200 600 Time Weighted Average Indicative OELV IR_OEL
78-93-3 (TWA):
[METHYL ETHYL KETONE (MEK)]
Butanone 300 900 Short Term Exposure Indicative OELV IR_OEL
78-93-3 Limit (STEL):
[METHYL ETHYL KETONE (MEK)]
Butanone Skin designation: Can be absorbed through the IR_OEL
78-93-3 skin.
[METHYL ETHYL KETONE (MEK)]
Butanone 200 600 Time Weighted Average Indicative ECTLV
78-93-3 (TWA):
[BUTANONE]
Butanone 300 900 Short Term Exposure Indicative ECTLV
78-93-3 Limit (STEL):
[BUTANONE]
Cyclohexanone Skin designation: Can be absorbed through the ECTLV
108-94-1 skin.
[CYCLOHEXANONE]
Cyclohexanone 10 40,8 Time Weighted Average Indicative OELV IR_OEL
108-94-1 (TWA):
[CYCLOHEXANONE]
Cyclohexanone 20 81,6 Short Term Exposure Indicative OELV IR_OEL
108-94-1 Limit (STEL):
[CYCLOHEXANONE]
Cyclohexanone Skin designation: Can be absorbed through the IR_OEL
108-94-1 skin.
[CYCLOHEXANONE]
Cyclohexanone 10 40,8 Time Weighted Average Indicative ECTLV
108-94-1 (TWA):
[CYCLOHEXANONE]
Cyclohexanone 20 81,6 Short Term Exposure Indicative ECTLV
108-94-1 Limit (STEL):
[CYCLOHEXANONE]
Polyvinyl chloride 1 Time Weighted Average IR_OEL
9002-86-2 (TWA):
[POLYVINYL CHLORIDE (PVC),
RESPIRABLE DUST]
Polyvinyl chloride 10 Time Weighted Average IR_OEL
9002-86-2 (TWA):
[POLYVINYL CHLORIDE (PVC), TOTAL
INHALABLE DUST]
Silicon dioxide 6 Time Weighted Average IR_OEL
112945-52-5 (TWA):
[SILICA, AMORPHOUS, TOTAL
INHALABLE DUST]
SDS No.: 41762 V004.0 Tangit PVC-U Special Adhesive (formerly known as Tangit ALL Page 8 of 18
PRESSURE)
Ingredient [Regulated Parameters Biological Sampling time Conc. Basis of biol. Remark Additional
substance] specimen exposure index Information
Butanone Butan-2-one Urine Sampling time: End of UKEH40BMG
78-93-3 shift. V
[BUTAN-2-ONE]
Cyclohexanone cyclohexanol Creatinine in Sampling time: End of UKEH40BMG
108-94-1 urine shift. V
[CYCLOHEXANONE]
Respiratory protection:
Suitable breathing mask when there is inadequate ventilation.
Combination filter: ABEKP (EN 14387)
This recommendation should be matched to local conditions.
Hand protection:
Recommended are gloves made from Nitril rubber ( Material thickness >0,1 mm, Perforation time < 30s).Gloves should be
replaced after each short time contact or contamination. Available at laboratory specialized trade or at pharmacies / chemist's
shops.
In the case of longer contact protective gloves made from butyl rubber are recommended according to EN 374.
material thickness > 0,3 mm
Perforation time > 10 minutes
In the case of longer and repeated contact please note that in practice the penetration times may be considerably shorter than
those determined according to EN 374. The protective gloves must always be checked for their suitability for use at the specific
workplace (e.g. mechanical and thermal stress, product compatibility, antistatic effects, etc.). The gloves must be replaced
immediately at the first signs of wear and tear. The information provided by the manufacturers and given in the relevant trade
association regulations for industrial safety must always be observed. We recommend that a hand care plan is drawn up in
cooperation with a glove manufacturer and the trade association in accordance with the local operating conditions.
Eye protection:
Goggles which can be tightly sealed.
Protective eye equipment should conform to EN166.
Skin protection:
Suitable protective clothing
Protective clothing should conform to EN 14605 for liquid splashes or to EN 13982 for dusts.
The mixture is classified based on calculation method referring to the classified substances present in the mixture.
The mixture is classified based on calculation method referring to the classified substances present in the mixture.
The toxicity of the product is due to its narcotic effect after inhalation.
In the event of protracted or repeated exposure, damage to health cannot be excluded.
Skin corrosion/irritation:
The mixture is classified based on calculation method referring to the classified substances present in the mixture.
The mixture is classified based on calculation method referring to the classified substances present in the mixture.
The mixture is classified based on threshold limits referring to the classified substances present in the mixture.
The mixture is classified based on threshold limits referring to the classified substances present in the mixture.
Carcinogenicity
The mixture is classified based on threshold limits referring to the classified substances present in the mixture.
Reproductive toxicity:
The mixture is classified based on threshold limits referring to the classified substances present in the mixture.
STOT-single exposure:
No data available.
STOT-repeated exposure::
The mixture is classified based on threshold limits referring to the classified substances present in the mixture.
Aspiration hazard:
No data available.
SDS No.: 41762 V004.0 Tangit PVC-U Special Adhesive (formerly known as Tangit ALL Page 15 of 18
PRESSURE)
12.1. Toxicity
Toxicity (Fish):
The mixture is classified based on calculation method referring to the classified substances present in the mixture.
Toxicity (Daphnia):
The mixture is classified based on calculation method referring to the classified substances present in the mixture.
No data available.
Toxicity (Algae):
The mixture is classified based on calculation method referring to the classified substances present in the mixture.
Toxicity to microorganisms
The mixture is classified based on calculation method referring to the classified substances present in the mixture.
No data available.
No data available.
Waste code
080409
SDS No.: 41762 V004.0 Tangit PVC-U Special Adhesive (formerly known as Tangit ALL Page 17 of 18
PRESSURE)
14.1. UN number
ADR 1133
RID 1133
ADN 1133
IMDG 1133
IATA 1133
ADR ADHESIVES
RID ADHESIVES
ADN ADHESIVES
IMDG ADHESIVES
IATA Adhesives
ADR 3
RID 3
ADN 3
IMDG 3
IATA 3
ADR II
RID II
ADN II
IMDG II
IATA II
14.7. Transport in bulk according to Annex II of Marpol and the IBC Code
not applicable
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
VOC content 77,8 %
(VOCV 814.018 VOC regulation
CH)
SDS No.: 41762 V004.0 Tangit PVC-U Special Adhesive (formerly known as Tangit ALL Page 18 of 18
PRESSURE)
Further information:
This information is based on our current level of knowledge and relates to the product in the state in which it is delivered. It is
intended to describe our products from the point of view of safety requirements and is not intended to guarantee any particular
properties.
Relevant changes in this safety data sheet are indicated by vertical lines at the left margin in the body of this document.
Corresponding text is displayed in a different color on shadowed fields.