Professional Documents
Culture Documents
Bladder Tanks Type
Bladder Tanks Type
DESCRIPTION The tanks are provided with four (4) legs for
greater stability.
Buckeye Bladder Tanks store foam concentrate
Tanks are supplied with brass trim valves with
and are one component of a Balanced Pressure
Teflon seats and permanently mounted to the
Foam System. They require no external power, other
tank.
than a supply of water to ensure proper operation.
The Vertical and Horizontal Bladder tanks are All valves are labeled showing normal working
designed and constructed in accordance with the position.
latest revisions to ASME code, Section VIII for
unfired pressure vessels. They have a working Lifting lugs are permanently welded to the
presure of 175 PSI and they are tested to one and tank with eyes of approximately 11/2" in
one half times this pressure. diameter.
Both the vertical and horizontal tanks contain
SPECIFICATIONS a perforated PVC center tube that permits
full agent discharge.
The tank shell is constructed of steel, complying
All tanks are approximately 10% oversized to
with ASME specifications, possessing a tensile
allow for any thermal expansion of the foam
strength of not less than 70,000 PSI. The
concentrate.
circumferential, as well as the longitudinal body
seam, shall be machine welded. The tank interior All tanks supplied with a label identifying type
shall be sand blasted white and have all welds of foam concentrate the system is designed
and edges ground smooth. for, the percentage ratio and tank size.
The tank shell water inlet will be screened to Standard tanks are painted red enamel.
prevent bladder blow out or the entrapment of
debris between the tank shell and the bladder. All
OPTIONS
other openings greater than 1" shall be screened
to prevent bladder blowout.
1. Coal tar epoxy for coating the interior shell of
The vertical tank assembly is supported the tank (for use in a salt water environment).
by four legs providing easy access to the
2. Sight glass.
bladder drain/fill valve and the tank shell drain/
fill valve. Four mounting holes are provided for 3. Proportioner pre-piped onto tank assembly.
anchoring the tank. The horizontal tank assembly
is supported on two saddles welded to the tank 4. Primed red epoxy finish.
and fitted with anchoring holes.
5. Custom fabrication of specialty materials
FEATURES dimensions and capacities.
U.L. Listed & F. M. Approved. 6. Actuated valves water/concentrate.
Bladder is manufactured of nylon reinforced
7. Stainless steel trim.
Buna-N. The bladder material shall have a
Mullen burst pressure in excess of 800 PSI 8. Special paint colors.
and constructed to conform to the inside
dimensions of the tank. 9. Insulation and heater packages.
DIMENSIONS ORDERING INFORMATION
110 Kings Road, Kings Mountain, NC 28086-0428 • Tel (704) 739-7415 • Fax (704) 739-7418 • www.buckeyef.com
FOAM PROPORTIONING EQUIPMENT
HORIZONTAL BLADDER TANK
110 Kings Road, Kings Mountain, NC 28086-0428 • Tel (704) 739-7415 • Fax (704) 739-7418 • www.buckeyef.com
FOAM PROPORTIONING EQUIPMENT
HORIZONTAL BLADDER TANK
110 Kings Road, Kings Mountain, NC 28086-0428 • Tel (704) 739-7415 • Fax (704) 739-7418 • www.buckeyef.com