Professional Documents
Culture Documents
Siga Dsi
Siga Dsi
Intelligent Smoke
Detector
SIGA-DSI
The SIGA-DSI notifies the control panel of changes in sensitivity • Two levels of dirty detector warning
due to environmental conditions such as dirt, smoke, temperature, • Two pre-alarm settings
and humidity. When it reaches its preset limit, the detector issues
a maintenance warning that alerts maintenance personnel of the • Two sensitivity settings
need for service. The SIGA-DSI remains operational with enough • Non-volatile memory
of a safety margin to allow for a service call before performance is
affected. This avoids downtime and trouble conditions. • Electronic addressing
• Identification of dirty or defective detectors
Like all Signature Series detectors, the SIGA-DSI is an intelligent
device that gathers analog information from its optical smoke • Automatic day/night sensitivity adjustment
sensor, converting this data into digital signals. To make an alarm
• Bicolor (green/red) status LED
decision, the detector’s on-board microprocessor measures and
analyzes sensor readings and compares this information to histori- • Standard, relay, fault isolator, and audible mounting bases
cal data. Digital filters remove signal patterns that are not typical of • Normal Polling Flash Disable Selection
fires, thus virtually eliminating unwanted alarms.
• UL268 Listed
• Removable cover and chamber provides for easy cleaning
Compatible
base
Tamper-resist
lever arm
LED light
pipe
Compatibility
Relay Detector Base, SIGA-RB, SIGA-RB4 Signature detectors are compatible with control panels using Sig-
This base includes a relay. Nor- nature Series loop controllers. Siga-DSI and Siga-DHI are sup-
mally open or closed operation ported on EST3 and EST3X loop controllers using 5.2 or greater.
is selected during installation.
The dry contact is rated for 1 amp
(pilot duty) @ 30 Vdc. The relay’s
position is supervised to avoid ac- Warnings & Cautions
cidentally jarring it out of position. This detector will not operate without electrical power. As fires fre-
The SIGA-RB can be operated as quently cause power interruption, we suggest you discuss further
a control relay if programmed to safeguards with your fire protection specialist.
do so at the control panel (EST3
V.2 only). The relay base does not This detector will NOT sense fires that start in areas where smoke
Term Description
support the SIGA-LED Remote 1 Normally Open
cannot reach the detector. Smoke from fires in walls, roofs, or on
LED. CONTACT RATING 2 DATA IN/OUT (+) the opposite side of closed doors may not reach the detector.
1.0 Amp @ 30 VDC 3 Common
(Pilot Duty) 4 DATA IN (-)
5 Not Used
6 Normally-Closed
7 DATA OUT (-)
Ordering Information
Catalog Ship Wt.
Description
Number lbs (kg)
SIGA-DSI Intelligent Optical Detector 0.4 (0.16)
Accessories
SIGA-SB Detector Mounting Base - Standard
SIGA-SB4 4-inch Detector Mounting Base c/w Trim Skirt
SIGA-RB Detector Mounting Base w/Relay
SIGA-RB4 4-inch Detector Mounting Base w/Relay, c/w Trim Skirt 0.2 (.09)
SIGA-IB Detector Mounting Base w/Fault Isolator
SIGA-IB4 4-inch Detector Mounting Base w/ Fault Isolator, c/w Trim Skirt
SIGA-LED Remote Alarm LED (not for EN54 applications)
SIGA-AB4G Audible (Sounder) Base for Fire Detectors 0.3 (0.15)
SIGA-TS4 Trim Skirt (supplied with 4-inch bases) 0.1 (.04)
11-22-13