Professional Documents
Culture Documents
FACULTY OF ENGINEERING
DEPARTMENT OF ELECTRICAL / ELECTRONICS ENGINEERING
YEAR: 100 LEVEL
SESSION: 2021/2022 BETA SEMESTER EXAMINATION
COURSE: ENGINEERING DRAWING 2 (2 CREDIT UNITS)
INSTRUCTIONS: ALL Questions in Section A are Compulsory, answer one (1) question in Section B
TIME ALLOWED: 2HRS
QUESTION 3:
A cone of base diameter 80mm and axis 100mm is resting on its base on the horizontal Plane. It is completely
penetrated by a cylinder of base diameter 40mm and axis 100mm. The axes of the solids intersect each other
at right angle 30mm above the base of the cone. Draw the projections of the combination and show the curves
of intersections. (30marks)
QUESTION 4:
A cone of base diameter 60mm and axis 60mm long resting on its base is sectioned at 30o to the horizontal
from the point 20mm from the base by a plane XX’. Draw:
(i). The front view looking from your left hand side (ii). The complete plan (iii). The end elevation of the
frustum. (iv). The true shape of the cut surface (iv). The development of the frustum opening from X point
closer to the base.
(30 marks)
Good luck