Professional Documents
Culture Documents
Burdick Quest Bio Setting
Burdick Quest Bio Setting
Power up the motherboard and wait for the prompting to press "Del" to enter into the SYSTEM
CONFIGURATION main menu.
Choose Standard CMOS Features from the main menu.
Set the date and time.
Set the primary Hard drive to auto and disable all other drives.
The table above.shows the standard configured items. Listed below are the
changes that need to be made.
The table above lists the standard configured items. Below is a list of the
changes that need to be made.
IntegratedPeripherals
OnChip IDE Channel 0 Enabled Onboard Parallel Port :378/IRQ7
OnChip IDE Channel 1 Disabled Onboard Parallel Mode ECP
Primary Master PIO Auto ECP Mode Use DMAA :3
Primary Slave PIO Auto Parallel Port EPP Type :EPP1.9
Secondary Master PlIO Auto Onboard Serial Port 3 Disabled
Secondary Slave PlO Auto Serial Port 3 Use IRQ : IRO¢
Primary Master UDMA Auto Onboard Serial Port 4 Disabled
Primary Slave UDMA :Disabled Serial Port 4 Use IRQ :IRQ10
Secondary Master UDMA Auto Onboard Parallel Port 2 :278H
Secondary Slave UDMA Auto Parallel Port 2 Use IRQ :IRQ9
IDE HDD Block Mode Disabled Parallel Port 2 Mode Normal
Onboard FDD Controller :Disabled
Onboard Serial Port 1 :3F8/IRQ4
Onboard Serial Port 2 :2F8/IRQ3
UART 2 Mode :Standard
IR Function Duplex :Half
TX,RX Inverting Enable No,Yes
The table above lists the standard configured items. Below is a list of the
changes that need to be made.
The table above lists the standard configured items. Below is a list of the
changes that need to be made.
PnP/PCI Configuration
PNP OS Installed No PCI/VGA Palette Snoop :Disabled
Reset Configuration Data Disabled OnChip USB :Enabled
Resources Controlled By Manual USB Keyboard Support :Disabled
IRQ Resources Press Enter Assign IRQ For USB Enabled
IRQ-3 Assigned to Legacy ISSA Assign IRQ For VGA Disabled
IRQ-4 Assigned to Legacy 1SA
IRQ-5 Assigned to Legacy 1SA
IRQ-7 Assigned to Legacy 1SA
IRQ-9 Assigned to :Legacy ISA
IRQ-10 Assigned to PCI/ISA PnP
IRQ-11 Assigned to :Legacy SA
IRQ-12 Assigned to PCI/ISA PnP
IRQ-14 Assigned to PCI/ISA PnP
IRQ-15 Assigned to :Legacy lISA
DMA Resources Press Enter
DMA-0 Assigned to PCIISA PnP
DMA-1 Assigned to PCI/ISA PnP
DMA-3 Assigned tob PCI/ISA PnP
DMA-5 Assigned to PCI/ISA PnP
DMA-6 Assigned to :PCI/ISA PnP
DMA-7 Assigned to :PCIISA PnP
The table above lists the standard configured items. Below is a list of the
changes that need to be made
Select the IRQ Resources menu and press Enter. Make the
IRQ-5 Assigned to change to Legacy ISA
following changes.
IRQ-9 Assigned to change to Legacy ISAA
IRQ-11 Assigned to change to Legacy ISA
IRQ-15 Assigned to change to Legacy 1SA