Professional Documents
Culture Documents
2021-11-09
Thanks for choose our TBS modulator cards here is the detail specification for every cards
Level 5-120
FEC 16QAM,32QAM,64QAM,128QAM,256QAM
Power 12V/9W
Level 5-120
FFT 2K,8K
FEC QPSK,16QAM,64QAM
Power 10W
interleave: 0-15
Power 10W
Modulation 8VSB
interleave: 0-15
Power 10W
When using TBS modulator cards with kylone here is the brief process
1. Add the source from DVB or IP or local file
2. Home Page
Home page you can get the server CPU and Memory Usage status and Ethernet Input and Output status
3. Content Setting
3.1.1 Summary
Here you can see all channels status which process profile it is using and you can click the button direct go to
the detail setting page.
Streaming Configuration: this is the HTTP output option you can choose which Ethernet used to streaming. our
default mode is HTTP output.
Broadcasting (System Defaults): This is the global multicast output option. You can choose which Ethernet used
to streaming multicast.
Here you can create manage all the DVB-S/S2, DVB-T/T2, DVB-C, ISDB-T, ATSC transponders, let us create one
DVB-S2 transponder as example
If you are using TBS Multi Standard Tuner card such as TBS6590, TB6528, TBS6522,TBS6504,TBS6508 when
you lock DVB-S/S2 transponder the Frontend Number value you need to set to 1 like this:
after press scan then you can choose the tuner you want to use to scan this transponder, please choose the
one which is not in use:
9 / 34 TBS Modulator User Guide
The satellite tuner waits for a few seconds of scanning and it will automatically display the scan results. If the
signal is good, you will see the following scan results:
after success scan press ok then you can go to All Channels to configure the channels
When create new transponder if success scan then assign the transponder to the tuners ,press save then go
back to setting to commit:
You can input the unicast stream here, press New Recorder to create a new one.
as our server IP is 10.47.48.1 let us take this udp stream as example udp://@10.47.48.1:4001
You can input the multicast stream here, press New Recorder to create a new one.
Let us using one MPTS for test the address is multicast: udp://@239.255.0.1:5002, press New Recorder then
input like this:
after this close the window then go back to Content->Settings->Commit to let it work
3.4.1 Multiplexers
Here you can create the MPTS the channels inside this server, Press New record start configuration:
After add then go to Commit page press commit to take effect, wait a while you can check the status at status
page:
The first time if you have not seen your modulator card you can press Scan button it will refresh the page
And list the cards inside the server.
4. Status Page
4.1 Monitoring
DVBT Status
ATSC Status
5. System Page
5.1.1 Settings
5.1.2 Tools
5.3 Services
5.3.1 SNMP
If you need put local TS file to the server you can use this. after you put the files to server you can disable the
service.
5.4.1 Interface
You can click the port you want to configuration such as enp8s0:
In some case you want to check the server status with ping, DNS, HTTP let us take example with Ping:
Press ping wait a few seconds then you will get the result:
Any change you need commit here to let it work, after press Commit wait about a few seconds then
All stream will auto Restart: