You are on page 1of 100

Operating Instructions

Pressure transmitter with ceramic


measuring cell

VEGABAR 82
4 … 20 mA/HART

Document ID: 45028


Contents

Contents
1 About this document................................................................................................................ 4
1.1 Function............................................................................................................................ 4
1.2 Target group...................................................................................................................... 4
1.3 Symbols used................................................................................................................... 4
2 For your safety.......................................................................................................................... 5
2.1 Authorised personnel........................................................................................................ 5
2.2 Appropriate use................................................................................................................. 5
2.3 Warning about incorrect use.............................................................................................. 5
2.4 General safety instructions................................................................................................ 5
2.5 EU conformity.................................................................................................................... 5
2.6 NAMUR recommendations............................................................................................... 6
2.7 Installation and operation in the USA and Canada............................................................ 6
2.8 Environmental instructions................................................................................................ 6
3 Product description.................................................................................................................. 7
3.1 Configuration..................................................................................................................... 7
3.2 Principle of operation........................................................................................................ 8
3.3 Supplementary cleaning procedures............................................................................... 13
3.4 Packaging, transport and storage.................................................................................... 13
3.5 Accessories.................................................................................................................... 14
4 Mounting.................................................................................................................................. 16
4.1 General instructions........................................................................................................ 16
4.2 Instructions for oxygen applications................................................................................ 17
4.3 Ventilation and pressure compensation........................................................................... 18
4.4 Process pressure measurement...................................................................................... 20
4.5 Level measurement......................................................................................................... 22
4.6 External housing............................................................................................................. 23
5 Connecting to power supply.................................................................................................. 24
5.1 Preparing the connection................................................................................................ 24
5.2 Connecting...................................................................................................................... 26
5.3 Single chamber housing.................................................................................................. 27
5.4 Double chamber housing................................................................................................ 28
5.5 Ex-d-ia double chamber housing..................................................................................... 30
5.6 Double chamber housing with DIS-ADAPT..................................................................... 31
5.7 Housing IP66/IP68 (1 bar)............................................................................................... 32
5.8 External housing with version IP68 (25 bar).................................................................... 32
5.9 Connection example....................................................................................................... 34
5.10 Switch-on phase............................................................................................................. 35
6 Set up with the display and adjustment module................................................................. 36
6.1 Insert display and adjustment module............................................................................. 36
6.2 Adjustment system.......................................................................................................... 37
6.3 Measured value indication............................................................................................... 38
6.4 Parameter adjustment - Quick setup............................................................................... 39
45028-EN-220624

6.5 Parameter adjustment - Extended adjustment................................................................ 39


6.6 Menu overview................................................................................................................ 51
6.7 Save parameter adjustment data.................................................................................... 53
7 Setup with PACTware.............................................................................................................. 55

2 VEGABAR 82 • 4 … 20 mA/HART
Contents

7.1 Connect the PC............................................................................................................... 55


7.2 Parameterization............................................................................................................. 55
7.3 Save parameter adjustment data.................................................................................... 57
8 Set up with other systems..................................................................................................... 58
8.1 DD adjustment programs................................................................................................ 58
8.2 Field Communicator 375, 475......................................................................................... 58
9 Diagnosis, asset management and service......................................................................... 59
9.1 Maintenance................................................................................................................... 59
9.2 Cleaning - hygienic connection with compression nut..................................................... 59
9.3 Diagnosis memory.......................................................................................................... 60
9.4 Asset Management function............................................................................................ 61
9.5 Rectify faults.................................................................................................................... 64
9.6 Exchange process module on version IP68 (25 bar)....................................................... 65
9.7 Exchanging the electronics module................................................................................. 66
9.8 Software update.............................................................................................................. 66
9.9 How to proceed if a repair is necessary........................................................................... 66
10 Dismount................................................................................................................................. 67
10.1 Dismounting steps.......................................................................................................... 67
10.2 Disposal.......................................................................................................................... 67
11 Supplement............................................................................................................................. 68
11.1 Technical data................................................................................................................. 68
11.2 Calculation of the total deviation...................................................................................... 82
11.3 Calculation of the total deviation - Practical example....................................................... 83
11.4 Dimensions..................................................................................................................... 85
11.5 Industrial property rights.................................................................................................. 96
11.6 Trademark....................................................................................................................... 96
45028-EN-220624

Safety instructions for Ex areas:


Take note of the Ex specific safety instructions for Ex applications.
These instructions are attached as documents to each instrument
with Ex approval and are part of the operating instructions.
Editing status: 2022-04-20

VEGABAR 82 • 4 … 20 mA/HART 3
1 About this document

1 About this document


1.1 Function
This instruction provides all the information you need for mounting,
connection and setup as well as important instructions for mainte-
nance, fault rectification, the exchange of parts and the safety of the
user. Please read this information before putting the instrument into
operation and keep this manual accessible in the immediate vicinity
of the device.

1.2 Target group


This operating instructions manual is directed to trained personnel.
The contents of this manual must be made available to the qualified
personnel and implemented.

1.3 Symbols used


Document ID
This symbol on the front page of this instruction refers to the Docu-
ment ID. By entering the Document ID on www.vega.com you will
reach the document download.
Information, note, tip: This symbol indicates helpful additional infor-
mation and tips for successful work.
Note: This symbol indicates notes to prevent failures, malfunctions,
damage to devices or plants.
Caution: Non-observance of the information marked with this symbol
may result in personal injury.
Warning: Non-observance of the information marked with this symbol
may result in serious or fatal personal injury.
Danger: Non-observance of the information marked with this symbol
results in serious or fatal personal injury.
Ex applications
This symbol indicates special instructions for Ex applications.
• List
The dot set in front indicates a list with no implied sequence.
1 Sequence of actions
Numbers set in front indicate successive steps in a procedure.
Disposal
This symbol indicates special instructions for disposal.
45028-EN-220624

4 VEGABAR 82 • 4 … 20 mA/HART
2 For your safety

2 For your safety


2.1 Authorised personnel
All operations described in this documentation must be carried out
only by trained, qualified personnel authorised by the plant operator.
During work on and with the device, the required personal protective
equipment must always be worn.

2.2 Appropriate use


The VEGABAR 82 is a pressure transmitter for process pressure and
hydrostatic level measurement.
You can find detailed information about the area of application in
chapter " Product description".
Operational reliability is ensured only if the instrument is properly
used according to the specifications in the operating instructions
manual as well as possible supplementary instructions.

2.3 Warning about incorrect use


Inappropriate or incorrect use of this product can give rise to applica-
tion-specific hazards, e.g. vessel overfill through incorrect mounting
or adjustment. Damage to property and persons or environmental
contamination can result. Also, the protective characteristics of the
instrument can be impaired.

2.4 General safety instructions


This is a state-of-the-art instrument complying with all prevailing
regulations and directives. The instrument must only be operated in a
technically flawless and reliable condition. The operator is responsi-
ble for the trouble-free operation of the instrument. When measuring
aggressive or corrosive media that can cause a dangerous situation
if the instrument malfunctions, the operator has to implement suitable
measures to make sure the instrument is functioning properly.
The safety instructions in this operating instructions manual, the na-
tional installation standards as well as the valid safety regulations and
accident prevention rules must be observed by the user.
For safety and warranty reasons, any invasive work on the device
beyond that described in the operating instructions manual may be
carried out only by personnel authorised by the manufacturer. Arbi-
trary conversions or modifications are explicitly forbidden. For safety
reasons, only the accessory specified by the manufacturer must be
used.
To avoid any danger, the safety approval markings and safety tips on
the device must also be observed.
45028-EN-220624

2.5 EU conformity
The device fulfils the legal requirements of the applicable EU direc-
tives. By affixing the CE marking, we confirm the conformity of the
instrument with these directives.

VEGABAR 82 • 4 … 20 mA/HART 5
2 For your safety

The EU conformity declaration can be found on our homepage.


Due to the design of its process fittings, the device does not subject
of EU pressure device directive if it is operated at process pressures
≤ 200 bar.

2.6 NAMUR recommendations


NAMUR is the automation technology user association in the process
industry in Germany. The published NAMUR recommendations are
accepted as the standard in field instrumentation.
The device fulfils the requirements of the following NAMUR recom-
mendations:
• NE 21 – Electromagnetic compatibility of equipment
• NE 43 – Signal level for fault information from measuring transduc-
ers
• NE 53 – Compatibility of field devices and display/adjustment
components
• NE 107 – Self-monitoring and diagnosis of field devices
For further information see www.namur.de.

2.7 Installation and operation in the USA and


Canada
This information is only valid for USA and Canada. Hence the follow-
ing text is only available in the English language.
Installations in the US shall comply with the relevant requirements of
the National Electrical Code (ANSI/NFPA 70).
Installations in Canada shall comply with the relevant requirements of
the Canadian Electrical Code
A Class 2 power supply unit has to be used for the installation in the
USA and Canada.

2.8 Environmental instructions


Protection of the environment is one of our most important duties.
That is why we have introduced an environment management system
with the goal of continuously improving company environmental pro-
tection. The environment management system is certified according
to DIN EN ISO 14001.
Please help us fulfil this obligation by observing the environmental
instructions in this manual:
• Chapter " Packaging, transport and storage"
• Chapter " Disposal"
45028-EN-220624

6 VEGABAR 82 • 4 … 20 mA/HART
3 Product description

3 Product description
3.1 Configuration
Scope of delivery The scope of delivery encompasses:
• VEGABAR 82 pressure transmitter
• Ventilation valves, closing screws – depending on version (see
chapter " Dimensions")
The further scope of delivery encompasses:
• Documentation
–– Quick setup guide VEGABAR 82
–– Test certificate for pressure transmitters
–– Instructions for optional instrument features
–– Ex-specific " Safety instructions" (with Ex versions)
–– If necessary, further certificates

Information:
Optional instrument features are also described in this operating
instructions manual. The respective scope of delivery results from the
order specification.

Scope of this operating This operating instructions manual applies to the following instrument
instructions versions:
• Hardware from 1.0.0
• Software from 1.3.6

Note:
You can find the hardware and software version of the instrument as
follows:

• On the type plate of the electronics module


• In the adjustment menu under " Info"

Type label The type label contains the most important data for identification and
use of the instrument:
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 7
3 Product description

1
2
7
3 6

5
4
Fig. 1: Layout of the type label (example)
1 Product code
2 Field for approvals
3 Technical data
4 Serial number of the instrument
5 QR code
6 Symbol of the device protection class
7 ID numbers, instrument documentation

Serial number - Instru- The type label contains the serial number of the instrument. With it
ment search you can find the following instrument data on our homepage:
• Product code (HTML)
• Delivery date (HTML)
• Order-specific instrument features (HTML)
• Operating instructions and quick setup guide at the time of ship-
ment (PDF)
• Test certificate (PDF) - optional
Move to " www.vega.com" and enter in the search field the serial
number of your instrument.
Alternatively, you can access the data via your smartphone:
• Download the VEGA Tools app from the " Apple App Store" or the
" Google Play Store"
• Scan the QR-code on the type label of the device or
• Enter the serial number manually in the app

3.2 Principle of operation


Application area VEGABAR 82 is suitable for applications in virtually all industries. It is
used for the measurement of the following pressure types.
• Gauge pressure
• Absolute pressure
• Vacuum

Measured products Measured products are gases, vapours and liquids.


Depending on the process fitting and measurement setup, measured
products can be also viscous or contain abrasive substances.
45028-EN-220624

Measured variables The VEGABAR 82 is suitable for the measurement of the following
process variables:
• Process pressure
• Level

8 VEGABAR 82 • 4 … 20 mA/HART
3 Product description

Fig. 2: Process pressure measurement VEGABAR 82

Electronic differential Depending on the version, the VEGABAR 82 is also suitable for
pressure electronic differential pressure measurement. For this, the instrument
is combined with a Secondary sensor.

Fig. 3: Electronic differential pressure measurement via a Primary/Secondary


sensor combination

You can find detailed information in the operating instructions of the


respective Secondary sensor.

Measuring system pres- The sensor element is the CERTEC® measuring cell with robust
sure ceramic diaphragm. The process pressure deflects the ceramic
diaphragm and causes a capacitance change in the measuring cell.
This capacitance change is converted into an electrical signal and
outputted as measured value via the output signal.
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 9
3 Product description

3
2

16 µm
1

Fig. 4: Configuration of the CERTEC® measuring cell


1 Process diaphragm
2 Glass joint
3 Base element

The measuring cell is available in two sizes: CERTEC® (ø 28 mm) and


Mini-CERTEC® (ø 17.5 mm).

Measuring system tem- Temperature sensors in the ceramic diaphragm and on the ceramic
perature body of the CERTEC® measuring cell or on the electronics of the
Mini-CERTEC® measuring cell detect the current process tempera-
ture. The temperature value is output via:
• The display and adjustment module
• The current output or the additional current output
• The digital signal output
Even extreme jumps in process temperature are immediately de-
tected by the CERTEC® measuring cell. The values in the ceramic
diaphragm are compared with those on the ceramic base body. Within
a few measuring cycles, the intelligent sensor electronics compen-
sates for otherwise unavoidable measurement deviations caused by
temperature shocks in the range. Depending on the adjusted damp-
ing, these cause only slight and brief changes in the output signal. 1)

Pressure types The measuring cell design depends on the selected pressure type.
Relative pressure: the measuring cell is open to the atmosphere.
The ambient pressure is detected in the measuring cell and compen-
sated. It thus has no influence on the measured value.
Absolute pressure: the measuring cell contains vacuum and is
encapsulated. The ambient pressure is not compensated and does
hence influence the measured value.
Relative pressure, climate-compensated: the measuring cell is
evacuated and encapsulated. The ambient pressure is detected
through a reference sensor in the electronics and compensated. It
thus has no influence on the measured value.

Seal concepts The following presentations show examples for the installation of the
45028-EN-220624

ceramic measuring cell into the process fitting and the different seal
concepts.

1)
At temperatures above 100 °C the function is automatically deactivated, at
temperatures below 95 °C it is automatically reactivated.

10 VEGABAR 82 • 4 … 20 mA/HART
3 Product description

Recessed installation The recessed installation is particularly suitable for applications with
gases, vapours and clear liquids. The measuring cell seal is posi-
tioned laterally as well as in addition in front.

3
5 4
6

Fig. 5: Recessed installation of the measuring cell (example: manometer con-


nection G½)
1 Measuring cell
2 Seal for the measuring cell
3 Additional, front seal for measuring cell
4 Diaphragm
5 Process fitting
6 Seal for the process fitting

Front-flush mounting with The front-flush installation is particularly suitable for applications with
single seal viscous and abrasive media and in case of buildup. The measuring
cell seal is positioned laterally.

1
4 2
5 3

Fig. 6: Front-flush installation of the measuring cell (example: thread G1½)


1 Seal for the process fitting
2 Measuring cell
3 Seal for the measuring cell
4 Process fitting
5 Diaphragm

Completely front-flush The completely front-flush mounting is particularly suitable for ap-
mounting with single seal plications in the paper industry. The diaphragm is in the pulp flow, is
hence cleaned and protected against buildup.
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 11
3 Product description

4 2
5 3
Fig. 7: Front-flush installation of the measuring cell (example: M30 x 1.5)
1 Measuring cell
2 Seal for the measuring cell
3 Seal for the process fitting
4 Process fitting
5 Diaphragm

Front-flush mounting with The front-flush installation is particularly suitable for applications with
double seal viscous media. The additional, front sealing protects the glass joint
of the measuring cell against chemical attack and the measuring cell
electronics against diffusion of aggressive gases from the process.

1
3
2
4
5
Fig. 8: Front-flush installation of the measuring cell with double seal (example:
flange connection with extension)
1 Measuring cell
2 Seal for the measuring cell
3 Process fitting
4 Additional, front seal for measuring cell
5 Diaphragm

Installation in hygienic The front-flush, hygienic installation of the measuring cell is particu-
fitting larly suitable for food applications. The sealings are installed gap-free.
The form seal of the measuring cell protects also the glass joint.

1
4 2
5 3

Fig. 9: Hygienic installation of the measuring cell (example: hygienic fitting with
compression nut)
45028-EN-220624

1 Measuring cell
2 Form seal for the measuring cell
3 Gap-free seal for process fitting
4 Process fitting
5 Diaphragm

12 VEGABAR 82 • 4 … 20 mA/HART
3 Product description

Installation in hygienic The front-flush, hygienic installation of the measuring cell acc. to 3A
fitting acc. to 3-A is particularly suitable for food applications. The sealings are installed
gap-free. The additional front sealing for the measuring cell protects
also the glass joint. A hole in the process fitting is used for leakage
detection.
1
6 2
3
5 4
Fig. 10: Hygienic installation of the measuring cell acc. to 3-A (example: Clamp
connection)
1 Measuring cell
2 Seal for the measuring cell
3 Process fitting
4 Additional, front seal for measuring cell
5 Diaphragm
5 Hole for leakage detection

3.3 Supplementary cleaning procedures


The VEGABAR 82 is also available in the version " Oil, grease and
silicone-free" or cleaning for paint compatible version (LABS). These
instruments have passed through a special cleaning procedure to
remove oil, grease and paint-wetting impairment substances (PWIS).
The cleaning is carried out on all wetted parts as well as on surfaces
accessible from outside. To keep the purity level, the instruments are
immediately packed in plastic foil after the cleaning process. The
purity level remains as long as the instrument is kept in the closed
original packaging.
Caution:
The VEGABAR 82 in these versions must not be used in oxygen
applications. For this purpose, devices in the special version "
Resistance to Internal Ignition in oxygen operation according to BAM
certification" are available.

3.4 Packaging, transport and storage


Packaging Your instrument was protected by packaging during transport. Its
capacity to handle normal loads during transport is assured by a test
based on ISO 4180.
The packaging consists of environment-friendly, recyclable card-
board. For special versions, PE foam or PE foil is also used. Dispose
of the packaging material via specialised recycling companies.

Transport Transport must be carried out in due consideration of the notes on the
transport packaging. Nonobservance of these instructions can cause
45028-EN-220624

damage to the device.

Transport inspection The delivery must be checked for completeness and possible transit
damage immediately at receipt. Ascertained transit damage or con-
cealed defects must be appropriately dealt with.

VEGABAR 82 • 4 … 20 mA/HART 13
3 Product description

Storage Up to the time of installation, the packages must be left closed and
stored according to the orientation and storage markings on the
outside.
Unless otherwise indicated, the packages must be stored only under
the following conditions:
• Not in the open
• Dry and dust free
• Not exposed to corrosive media
• Protected against solar radiation
• Avoiding mechanical shock and vibration
Storage and transport • Storage and transport temperature see chapter " Supplement -
temperature Technical data - Ambient conditions"
• Relative moisture 20 … 85 %

Lifting and carrying With instrument weights of more than 18 kg (39.68 lbs) suitable and
approved equipment must be used for lifting and carrying.

3.5 Accessories
Display and adjustment The display and adjustment module is used for measured value indi-
module cation, adjustment and diagnosis.
The integrated Bluetooth module (optional) enables wireless adjust-
ment via standard adjustment devices.

VEGACONNECT The interface adapter VEGACONNECT enables the connection of


communication-capable instruments to the USB interface of a PC.

Secondary sensors Secondary sensors of VEGABAR series 80 enable in conjunction with


VEGABAR 82 an electronic differential pressure measurement.

VEGADIS 81 The VEGADIS 81 is an external display and adjustment unit for VEGA
plics® sensors.

VEGADIS adapter The VEGADIS adapter is an accessory part for sensors with double
chamber housings. It enables the connection of VEGADIS 81 to the
sensor housing via an M12 x 1 plug.

VEGADIS 82 VEGADIS 82 is suitable for measured value indication and adjustment


of sensors with HART protocol. It is looped into the 4 … 20 mA/HART
signal cable.

PLICSMOBILE T81 The PLICSMOBILE T81 is an external GSM/GPRS/UMTS radio unit


for transmission of measured values and for remote parameter adjust-
ment of HART sensors.

PLICSMOBILE 81 PLICSMOBILE 81 is an internal GSM/GPRS/UMTS radio unit for


45028-EN-220624

HART sensors for transmitting measured values and for remote


parameterization.

Overvoltage protection The overvoltage arrester B81-35 is used instead of the terminals in
the single or double chamber housing.

14 VEGABAR 82 • 4 … 20 mA/HART
3 Product description

Protective cover The protective cover protects the sensor housing against soiling and
intense heat from solar radiation.

Flanges Screwed flanges are available in different versions according to the


following standards: DIN 2501, EN 1092-1, BS 10, ASME B 16.5,
JIS B 2210-1984, GOST 12821-80.

Welded socket, threaded Welded sockets are used to connect the devices to the process.
and hygienic adapter Threaded and hygienic adapters enable simple adaptation of devices
with standard threaded fittings to process-side hygiene connections.
The instructions for the listed accessories can be found in the down-
load area on our homepage.
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 15
4 Mounting

4 Mounting
4.1 General instructions
Process conditions Note:
For safety reasons, the instrument must only be operated within the
permissible process conditions. You can find detailed information on
the process conditions in chapter " Technical data" of the operating
instructions or on the type label.
Hence make sure before mounting that all parts of the instrument ex-
posed to the process are suitable for the existing process conditions.
These are mainly:
• Active measuring component
• Process fitting
• Process seal
Process conditions in particular are:
• Process pressure
• Process temperature
• Chemical properties of the medium
• Abrasion and mechanical influences

Protection against mois- Protect your instrument against moisture ingress through the following
ture measures:
• Use a suitable connection cable (see chapter " Connecting to
power supply")
• Tighten the cable gland or plug connector
• Lead the connection cable downward in front of the cable entry or
plug connector
This applies mainly to outdoor installations, in areas where high
humidity is expected (e.g. through cleaning processes) and on cooled
or heated vessels.
Note:
Make sure that during installation or maintenance no moisture or dirt
can get inside the instrument.
To maintain the housing protection, make sure that the housing lid is
closed during operation and locked, if necessary.

Screwing in Devices with threaded fitting are screwed into the process fitting with
a suitable wrench via the hexagon.
See chapter " Dimensions" for wrench size.
Warning:
The housing or the electrical connection may not be used for screw-
45028-EN-220624

ing in! Depending on the device version, tightening can cause dam-
age, e. g. to the rotation mechanism of the housing.

Vibrations Avoid damages on the device by lateral forces, for example by vibra-
tions. It is thus recommended to fix the devices with process fitting

16 VEGABAR 82 • 4 … 20 mA/HART
4 Mounting

thread G½ of plastic at the installation site via a suitable measuring


instrument holder.
If there is strong vibration at the mounting location, the instrument
version with external housing should be used. See chapter " External
housing".

Permissible process The permissible process pressure range is specified by "MWP" (Maxi-
pressure (MWP) - Device mum Working Pressure) on the type label, see chapter " Structure".
The MWP takes the element of the measuring cell and processing
fitting combination with the weakest pressure into consideration and
may applied permanently. The specification refers to a reference
temperature of +20 °C (+68 °F). It also applies when a measuring cell
with a higher measuring range than the permissible pressure range of
the process fitting is installed order-related.
In order to prevent damage to the device, a test pressure may only
exceed the specified MWP briefly by 1.5 times at reference tempera-
ture. The pressure stage of the process fitting as well as the overload
resistance of the measuring cell are taken into consideration here
(see chapter " Technical Data").
In addition, a temperature derating of the process fitting, e. g. with
flanges, can limit the permissible process pressure range according
to the respective standard.

Permissible process The permissible process pressure range is stated on the type label.
pressure (MWP) - Mount- The instrument should only be operated with these pressures if the
ing accessory mounting accessory used also fulfils these values. This should be en-
sured by suitable flanges, welded sockets, tension rings with Clamp
connections, sealings, etc.

Temperature limits Higher process temperatures often mean also higher ambient
temperatures. Make sure that the upper temperature limits stated in
chapter " Technical data" for the environment of the electronics hous-
ing and connection cable are not exceeded.

1
Fig. 11: Temperature ranges
1 Process temperature
2 Ambient temperature
45028-EN-220624

4.2 Instructions for oxygen applications


Oxygen applications Oxygen and other gases can be explosive when brought into contact
with oils, grease and plastics, so the following measures must also be
taken:

VEGABAR 82 • 4 … 20 mA/HART 17
4 Mounting

• All components of the system, e.g. measuring instruments, must


be cleaned in accordance with the requirements of recognized
regulations or standards
• Depending on the seal material, certain temperatures and pres-
sures must not be exceeded in oxygen applications, see chapter "
Technical data"

Danger:
Instruments for oxygen applications must be unpacked just before
mounting. After removing the protective cover of the process fitting,
the label "O2" will be visible on the process fitting. Penetration of oil,
grease and dirt should be avoided. Danger of explosion!

4.3 Ventilation and pressure compensation


Filter element - Function The filter element in the electronics housing has the following func-
tions:
• Ventilation of the electronics housing
• Atmospheric pressure compensation (with relative pressure meas-
uring ranges)

Caution:
The filter element causes a time-delayed pressure compensation.
When quickly opening/closing the housing cover, the measured value
can change for approx. 5 s by up to 15 mbar.
For an effective ventilation, the filter element must be always free from
buildup. In case of horizontal mounting, turn the housing so that the
filter element points downward after the instrument is installed. This
provides better protection against buildup.
Caution:
Do not use a high-pressure cleaner. The filter element could be dam-
aged, which would allow moisture into the housing.
The following paragraphs describe how the filter element is arranged
in the different instrument versions. 45028-EN-220624

18 VEGABAR 82 • 4 … 20 mA/HART
4 Mounting

Filter element - Position

6 6 6

1 2 3

6 6

4 5
Fig. 12: Position of the filter element
1 Plastic, stainless steel single chamber (precision casting)
2 Aluminium - single chamber
3 Stainless steel single chamber (electropolished)
4 Plastic double chamber
5 Aluminium, stainless steel double chamber housing (precision casting)
6 Filter element

With the following instruments a blind plug is installed instead of the


filter element:
• Instruments in protection IP66/IP68 (1 bar) - ventilation via capillar-
ies in non-detachable cable
• Instruments with absolute pressure
Filter element - Position → Turn the metal ring in such a way that the filter element points
Ex-d version downward after installation of the instrument. This provides better
protection against buildup.

Fig. 13: Position of the filter element - Ex-d version


45028-EN-220624

1 Rotatable metal ring


2 Filter element

Instruments with absolute pressure have a blind plug mounted


instead of the filter element.

VEGABAR 82 • 4 … 20 mA/HART 19
4 Mounting

Filter element - Position The Second Line of Defense (SLOD) is a second level of the process
Second Line of Defense separation in form of a gas-tight leadthrough in the housing neck,
preventing products from penetrating into the housing.
With these instruments, the process assembly is completely en-
capsulated. An absolute pressure measuring cell is used so that no
ventilation is required.
With relative pressure measuring ranges, the ambient pressure is
detected and compensated by a reference sensor in the electronics.
1

2
2

Fig. 14: Position of the filter element - gastight leadthrough


1 Filter element
2 Gas-tight leadthrough

Filter element - Position


IP69K version

Fig. 15: Position of the filter element - IP69K version


1 Filter element

Instruments with absolute pressure have a blind plug mounted


instead of the filter element.

4.4 Process pressure measurement


Measurement setup in Keep the following in mind when setting up the measuring system:
gases
• Mount the instrument above the measuring point
Possible condensation can then drain off into the process line.
45028-EN-220624

20 VEGABAR 82 • 4 … 20 mA/HART
4 Mounting

Fig. 16: Measurement setup for process pressure measurement of gases in


pipelines
1 VEGABAR 82
2 Blocking valve
3 Pipeline

Measurement setup in Keep the following in mind when setting up the measuring system:
vapours
• Connect via a siphon
• Do not insulate the siphon
• Fill the siphon with water before setup

1 1

2 2

3 3

4 4

Fig. 17: Measurement setup for the process pressure measurement of gases in
pipelines
1 VEGABAR 82
2 Blocking valve
3 Siphon in U or circular form
45028-EN-220624

4 Pipeline

A protective accumulation of water is formed through condensation


in the pipe bends. Even in applications with hot steam, a medium
temperature < 100 °C on the transmitter is ensured.

VEGABAR 82 • 4 … 20 mA/HART 21
4 Mounting

Measurement setup in Keep the following in mind when setting up the measuring system:
liquids
• Mount the instrument below the measuring point
The effective pressure line is always filled with liquid and gas bubbles
can bubble up to the process line.

Fig. 18: Measurement setup for the process pressure measurement of liquids in
pipelines
1 VEGABAR 82
2 Blocking valve
3 Pipeline

4.5 Level measurement


Measurement setup Keep the following in mind when setting up the measuring system:
• Mount the instrument below the min. level
• Do not mount the instrument close to the filling stream or emptying
area
• Mount the instrument so that it is protected against pressure
shocks from the stirrer

Fig. 19: Measurement setup for the level measurement


45028-EN-220624

22 VEGABAR 82 • 4 … 20 mA/HART
4 Mounting

4.6 External housing


Configuration

2 5

Fig. 20: Configuration, process module, external housing


1 Pipeline
2 Process module
3 Connection cable process assembly - External housing
4 External housing
5 Signal cable
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 23
5 Connecting to power supply

5 Connecting to power supply


5.1 Preparing the connection
Safety instructions Always keep in mind the following safety instructions:
• Carry out electrical connection by trained, qualified personnel
authorised by the plant operator
• If overvoltage surges are expected, overvoltage arresters should
be installed

Warning:
Only connect or disconnect in de-energized state.

Voltage supply Power supply and current signal are carried on the same two-wire
cable. The operating voltage can differ depending on the instrument
version.
The data for power supply are specified in chapter " Technical data".
Provide a reliable separation between the supply circuit and the
mains circuits according to DIN EN 61140 VDE 0140-1.
Power the instrument via an energy-limited circuit acc. to IEC 61010-
1, e.g. via Class 2 power supply unit.
Keep in mind the following additional factors that influence the operat-
ing voltage:
• Lower output voltage of the power supply unit under nominal load
(e.g. with a sensor current of 20.5 mA or 22 mA in case of fault
signal)
• Influence of additional instruments in the circuit (see load values in
chapter " Technical data")

Connection cable The instrument is connected with standard two-wire cable without
shielding. If electromagnetic interference is expected which is above
the test values of EN 61326-1 for industrial areas, shielded cable
should be used.
Use cable with round cross section for instruments with housing and
cable gland. Use a cable gland suitable for the cable diameter to
ensure the seal effect of the cable gland (IP protection rating).
We generally recommend the use of shielded cable for HART
multidrop mode.

Cable screening and If shielded cable is required, we recommend connecting the cable
grounding screening on both ends to ground potential. In the sensor, the cable
screening must be connected directly to the internal ground terminal.
The ground terminal on the outside of the housing must be connected
to the ground potential (low impedance).
In Ex systems, the grounding is carried out according to the installa-
45028-EN-220624

tion regulations.
In electroplating plants as well as plants for cathodic corrosion protec-
tion it must be taken into account that significant potential differences

24 VEGABAR 82 • 4 … 20 mA/HART
5 Connecting to power supply

exist. This can lead to unacceptably high currents in the cable screen
if it is grounded at both ends.
Note:
The metallic parts of the instrument (process fitting, sensor, concen-
tric tube, etc.) are connected with the internal and external ground
terminal on the housing. This connection exists either directly via
the conductive metallic parts or, in case of instruments with external
electronics, via the screen of the special connection cable.
You can find specifications on the potential connections inside the
instrument in chapter " Technical data".

Cable glands Metric threads:


In the case of instrument housings with metric thread, the cable
glands are screwed in at the factory. They are sealed with plastic
plugs as transport protection.
Note:
You have to remove these plugs before electrical connection.

NPT thread:
In the case of instrument housings with self-sealing NPT threads, it is
not possible to have the cable entries screwed in at the factory. The
free openings for the cable glands are therefore covered with red dust
protection caps as transport protection.
Note:
Prior to setup you have to replace these protective caps with ap-
proved cable glands or close the openings with suitable blind plugs.
On plastic housings, the NPT cable gland or the Conduit steel tube
must be screwed into the threaded insert without grease.
Max. torque for all housings, see chapter " Technical data".

Version IP68 (25 bar) The IP68 (25 bar) version of VEGABAR 82 consists of a process as-
sembly and an external electronics. The serial number is stored in the
process assembly and is also available on the type labels of the two
components.
After connecting and applying the voltage supply, the serial number
will be loaded automatically from the process assembly and displayed
on the display and adjustment module.
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 25
5 Connecting to power supply

2
1

Fig. 21: Combination process assembly and external electronics


1 Process module
2 Type label, process assembly
3 External electronics
4 Type label, external electronics

Note:
Keep in mind while connecting that the process assembly and the
external ekectronics must have the same serial number. Otherwise
the serial numbers on the type label and the display and adjustment
module do not correspond.

5.2 Connecting
Connection technology The voltage supply and signal output are connected via the spring-
loaded terminals in the housing.
Connection to the display and adjustment module or to the interface
adapter is carried out via contact pins in the housing.
Information:
The terminal block is pluggable and can be removed from the
electronics. To do this, lift the terminal block with a small screwdriver
and pull it out. When reinserting the terminal block, you should hear it
snap in.

Connection procedure Proceed as follows:


1. Unscrew the housing lid
2. If a display and adjustment module is installed, remove it by turn-
ing it slightly to the left
3. Loosen compression nut of the cable gland and remove blind
plug
4. Remove approx. 10 cm (4 in) of the cable mantle, strip approx.
1 cm (0.4 in) of insulation from the ends of the individual wires
45028-EN-220624

5. Insert the cable into the sensor through the cable entry

26 VEGABAR 82 • 4 … 20 mA/HART
5 Connecting to power supply

1 2
Fig. 22: Connection steps 5 and 6
1 Single chamber housing
2 Double chamber housing

6. Insert the wire ends into the terminals according to the wiring plan
Note:
Solid cores as well as flexible cores with wire end sleeves are insert-
ed directly into the terminal openings. In case of flexible cores without
end sleeves, press the terminal from above with a small screwdriver,
the terminal opening is then free. When the screwdriver is released,
the terminal closes again.
7. Check the hold of the wires in the terminals by lightly pulling on
them
8. Connect the shielding to the internal ground terminal, connect the
external ground terminal to potential equalisation
9. Tighten the compression nut of the cable entry gland. The seal
ring must completely encircle the cable
10. Reinsert the display and adjustment module, if one was installed
11. Screw the housing lid back on
The electrical connection is finished.

5.3 Single chamber housing


The following illustration applies to the non-Ex, Ex-ia and Ex-d ver-
sion.
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 27
5 Connecting to power supply

Electronics and connec-


tion compartment 2

4...20mA
3

(+)1 2(-) 5 6 7 8
4
1

Fig. 23: Electronics and connection compartment - single chamber housing


1 Voltage supply, signal output
2 For display and adjustment module or interface adapter
3 For external display and adjustment unit or Secondary sensor
4 Ground terminal for connection of the cable screening

5.4 Double chamber housing


The following illustrations apply to the non-Ex as well as to the Ex-ia
version.
Electronics compartment
2

4...20mA

(+)1 2(-) 5 6 7 8

1 1

Fig. 24: Electronics compartment - double chamber housing


1 Internal connection to the connection compartment
2 For display and adjustment module or interface adapter
45028-EN-220624

28 VEGABAR 82 • 4 … 20 mA/HART
5 Connecting to power supply

Connection compartment
2

4...20mA Display
3

(+)1 2(-) 5 6 7 8
4
1

Fig. 25: Connection compartment - double chamber housing


1 Voltage supply, signal output
2 For display and adjustment module or interface adapter
3 For external display and adjustment unit
4 Ground terminal for connection of the cable screening

Supplementary electron- To make a second measured value available for use, you can use the
ics - Additional current supplementary electronics " Additional current output".
output
Both current outputs are passive and need a power supply.

I II
4...20mA 4...20mA

(+)1 2(-) ( +)7 8(-)


3
1 2

Fig. 26: Terminal compartment, double chamber housing, supplementary elec-


tronics " Additional current output"
1 First current output (I) - Voltage supply and signal output, sensor (HART)
2 Additional current output (II) - Voltage supply and signal output (without
HART)
3 Ground terminal for connection of the cable screening
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 29
5 Connecting to power supply

Connection compart-
ment - Radio module
PLICSMOBILE 81 SIM

Status

Off On
Send

+1 2- 3

Fig. 27: Connection compartment - Radio module PLICSMOBILE 81


1 Voltage supply

You can find detailed information for connection in the operating


instructions " PLICSMOBILE".

5.5 Ex-d-ia double chamber housing


Electronics compartment
2

4...20mA

(+)1 2(-) 5 6 7 8

1 3

Fig. 28: Electronics compartment - Ex-d-ia double chamber housing


1 Internal connection to the connection compartment
2 For display and adjustment module or interface adapter
3 Internal connection to the plug connector for external display and adjust-
ment unit (optional)

Note:
HART multidrop mode is not possible when using an Ex-d-ia instru-
ment.
45028-EN-220624

30 VEGABAR 82 • 4 … 20 mA/HART
5 Connecting to power supply

Connection compartment

4...20mA

(+)1 2(-) 2
1

Fig. 29: Connection compartment - Ex-d-ia double chamber housing


1 Voltage supply, signal output
2 Ground terminal for connection of the cable screening

5.6 Double chamber housing with DIS-ADAPT


Electronics compartment

Fig. 30: View to the electronics compartment with VEGADIS adapter for connec-
tion of the external display and adjustment unit
1 VEGADIS adapter
2 Internal plug connection
3 M12 x 1 plug connector

Assignment of the plug


connector
4 3

1 2

Fig. 31: Top view of the M12 x 1 plug connector


1 Pin 1
2 Pin 2
45028-EN-220624

3 Pin 3
4 Pin 4

VEGABAR 82 • 4 … 20 mA/HART 31
5 Connecting to power supply

Contact pin Colour, connection ca- Terminal, electronics


ble in the sensor module
Pin 1 Brown 5
Pin 2 White 6
Pin 3 Blue 7
Pin 4 Black 8

5.7 Housing IP66/IP68 (1 bar)


Wire assignment, con-
nection cable 4
1
2

2
3
Fig. 32: Wire assignment, connection cable
1 Brown (+): to voltage supply or to the processing system
2 Blue (-): to voltage supply or to the processing system
3 Shielding
4 Breather capillaries with filter element

5.8 External housing with version IP68 (25 bar)


Overview
3
2

Fig. 33: VEGABAR 82 in IP68 version 25 bar with axial cable outlet, external
housing
1 Transmitter
2 Connection cable
3 External housing
45028-EN-220624

32 VEGABAR 82 • 4 … 20 mA/HART
5 Connecting to power supply

Electronics and connec-


tion compartment for
power supply

1
4...20mA

(+)1 2(-) 5 6 7 8

Fig. 34: Electronics and connection compartment


1 Electronics module
2 Cable gland for voltage supply
3 Cable gland for connection cable, transmitter

Terminal compartment,
housing socket

1 2 3 4
2 4
1 3
5 6

Fig. 35: Connection of the process component in the housing base


1 Yellow
2 White
3 Red
4 Black
45028-EN-220624

5 Shielding
6 Breather capillaries

VEGABAR 82 • 4 … 20 mA/HART 33
5 Connecting to power supply

Electronics and connec-


tion compartment 2

4...20mA
3

(+)1 2 (-) 5 6 7 8 4
1

Fig. 36: Electronics and connection compartment external housing


1 Voltage supply/Signal output
2 For display and adjustment module or interface adapter
3 For external display and adjustment unit or Secondary sensor
4 Ground terminal for connection of the cable screening

5.9 Connection example


Connection example, ad-
ditional current output

I II
4...20mA 4...20mA

(+)1 2(-) ( +)7 8(-)


2

3
Fig. 37: Connection example VEGABAR 82 additional current output
1 Supply and signal circuit, sensor
2 Signal circuit, additional current output
3 Input card PLC

Sensor Circuit Input card PLC


Terminal 1 (+) pas- Supply and signal circuit, Input 1 terminal (+) active
sive sensor
Terminal 2 (-) pas- Supply and signal circuit, Input 1 terminal (-) active
45028-EN-220624

sive sensor
Terminal 7 (+) pas- Signal circuit, additional Input 2 terminal (+) active
sive current output
Terminal 8 (-) pas- Signal circuit, additional Input 2 terminal (-) active
sive current output

34 VEGABAR 82 • 4 … 20 mA/HART
5 Connecting to power supply

5.10 Switch-on phase


After connecting the instrument to power supply or after a voltage
recurrence, the instrument carries out a self-check:
• Internal check of the electronics
• Indication of a status message on the display or PC
• The output signal jumps to the set fault current
Then the actual measured value is output to the signal cable. The
value takes into account settings that have already been carried out,
e.g. default setting.
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 35
6 Set up with the display and adjustment module

6 Set up with the display and adjustment


module
6.1 Insert display and adjustment module
The display and adjustment module can be inserted into the sensor
and removed again at any time. You can choose any one of four differ-
ent positions - each displaced by 90°. It is not necessary to interrupt
the power supply.
Proceed as follows:
1. Unscrew the housing lid
2. Place the display and adjustment module on the electronics in the
desired position and turn it to the right until it snaps in.
3. Screw housing lid with inspection window tightly back on
Disassembly is carried out in reverse order.
The display and adjustment module is powered by the sensor, an ad-
ditional connection is not necessary.

Fig. 38: Installing the display and adjustment module in the electronics compart-
ment of the single chamber housing
45028-EN-220624

36 VEGABAR 82 • 4 … 20 mA/HART
6 Set up with the display and adjustment module

1 2
Fig. 39: Installing the display and adjustment module in the double chamber
housing
1 In the electronics compartment
2 In the connection compartment

Note:
If you intend to retrofit the instrument with a display and adjustment
module for continuous measured value indication, a higher lid with an
inspection glass is required.

6.2 Adjustment system

2
Fig. 40: Display and adjustment elements
1 LC display
2 Adjustment keys

Key functions • [OK] key:


–– Move to the menu overview
–– Confirm selected menu
–– Edit parameter
–– Save value

• [->] key:
–– Change measured value presentation
45028-EN-220624

–– Select list entry


–– Select menu items
–– Select editing position

• [+] key:

VEGABAR 82 • 4 … 20 mA/HART 37
6 Set up with the display and adjustment module

–– Change value of the parameter

• [ESC] key:
–– Interrupt input
–– Jump to next higher menu

Adjustment system The instrument is operated via the four keys of the display and
adjustment module. The individual menu items are shown on the LC
display. You can find the function of the individual keys in the previous
illustration.

Adjustment system - keys With the Bluetooth version of the display and adjustment module you
via magnetic pen can also adjust the instrument with the magnetic pen. The pen oper-
ates the four keys of the display and adjustment module right through
the closed lid (with inspection window) of the sensor housing.

4 3

Fig. 41: Display and adjustment elements - with adjustment via magnetic pen
1 LC display
2 Magnetic pen
3 Adjustment keys
4 Lid with inspection window

Time functions When the [+] and [->] keys are pressed quickly, the edited value,
or the cursor, changes one value or position at a time. If the key is
pressed longer than 1 s, the value or position changes continuously.
When the [OK] and [ESC] keys are pressed simultaneously for more
than 5 s, the display returns to the main menu. The menu language is
then switched over to " English".
Approx. 60 minutes after the last pressing of a key, an automatic reset
to measured value indication is triggered. Any values not confirmed
with [OK] will not be saved.

6.3 Measured value indication


Measured value indica- With the [->] key you can move between three different indication
tion modes.
45028-EN-220624

In the first view, the selected measured value is displayed in large


digits.
In the second view, the selected measured value and a respective
bargraph presentation are displayed.

38 VEGABAR 82 • 4 … 20 mA/HART
6 Set up with the display and adjustment module

In the third view, the selected measured value as well as a second


selectable value, e.g. the temperature, are displayed.

With the " OK" key you move (during the initial setup of the instru-
ment) to the selection menu " Language".

Selection language In this menu item, you can select the national language for further
parameterization.

With the " [->]" button, you can select the requested language, with "
OK" you confirm the selection and move to the main menu.
You can change your selection afterwards with the menu item " Setup
- Display, Menu language".

6.4 Parameter adjustment - Quick setup


To quickly and easily adapt the sensor to the application, select the
menu item " Quick setup" in the start graphic on the display and
adjustment module.

Select the individual steps with the [->] key.


After the last step, " Quick setup terminated successfully" is displayed
briefly.
The return to the measured value indication is carried out through the
[->] or [ESC] keys or automatically after 3 s
Note:
You can find a description of the individual steps in the quick setup
guide of the sensor.
You can find " Extended adjustment" in the next sub-chapter.

6.5 Parameter adjustment - Extended adjustment


For technically demanding measuring points, you can carry out
extended settings in " Extended adjustment".
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 39
6 Set up with the display and adjustment module

Main menu The main menu is divided into five sections with the following func-
tions:

Setup: Settings e. g. for measurement loop name, application, units,


position correction, adjustment, signal output, disable/enable opera-
tion
Display: Settings, e.g., for language, measured value display, lighting
Diagnosis: Information, for example, of device status, peak value,
simulation
Additional adjustments: date/time, reset, copy function
Info: Instrument name, hardware and software version, calibration
date, sensor features
Note:
For optimum setting of the measuring point, the individual submenu
items in the main menu item " Setup" should be selected one after
the other and provided with the correct parameters. If possible, go
through the items in the given sequence.
The submenu points are described below.

6.5.1 Setup
Measurement loop name In the menu item " Sensor TAG" you edit a twelve-digit measurement
loop designation.
You can enter an unambiguous designation for the sensor, e.g. the
measurement loop name or the tank or product designation. In digital
systems and in the documentation of larger plants, a singular desig-
nation must be entered for exact identification of individual measuring
points.
The available digits include:
• Letters from A … Z
• Numbers from 0 … 9
• Special characters +, -, /, -

Application In this menu item you activate/deactivate the Secondary Device for
electronic differential pressure and select the application.
VEGABAR 82 can be used for process pressure and level measure-
45028-EN-220624

ment. The setting in the delivery status is process pressure measure-


ment. The mode can be changed in this adjustment menu.
If you have connected no Secondary Device, you confirm this with "
Deactivate".

40 VEGABAR 82 • 4 … 20 mA/HART
6 Set up with the display and adjustment module

Depending on the selected application, different subchapters in the


following adjustment steps are important. There you can find the
individual adjustment steps.

Enter the requested parameters via the appropriate keys, save your
settings with [OK] and jump to the next menu item with the [ESC] and
the [->] key.

Units In this menu item, the adjustment units of the instrument are deter-
mined. The selection determines the unit displayed in the menu items
" Min. adjustment (Zero)" and " Max. adjustment (Span)".

Unit of measurement:

If the level should be adjusted in a height unit, the density of the me-
dium must also be entered later during the adjustment.
In addition, the temperature unit of the instrument is specified. The
selection determines the unit displayed in menu items " Peak value,
temperature" and "in the variables of the digital output signal".

Temperature unit:

Enter the requested parameters via the appropriate keys, save your
settings with [OK] and jump to the next menu item with the [ESC] and
the [->] key.

Position correction Especially with chemical seal systems, the installation position of the
instrument can shift (offset) the measured value. Position correction
compensates this offset. In the process, the actual measured value
is taken over automatically. With relative pressure measuring cells a
manual offset can also be carried out.

Note:
45028-EN-220624

If the current measured value is automatically accepted, it must not


be falsified by medium coverage or static pressure.
With the manual position correction, the offset value can be deter-
mined by the user. Select for this purpose the function " Edit" and
enter the requested value.

VEGABAR 82 • 4 … 20 mA/HART 41
6 Set up with the display and adjustment module

Save your settings with [OK] and move with [ESC] and [->] to the
next menu item.
After the position correction is carried out, the actual measured value
is corrected to 0. The corrective value appears with an inverse sign as
offset value in the display.
The position correction can be repeated as often as necessary. How-
ever, if the sum of the corrective values exceeds 20 % of the nominal
measuring range, then no position correction is possible.

Adjustment VEGABAR 82 always measures pressure independently of the pro-


cess variable selected in the menu item " Application". To output the
selected process variable correctly, an allocation of the output signal
to 0 % and 100 % must be carried out (adjustment).
With the application " Level", the hydrostatic pressure, e.g. with full
and empty vessel, is entered for adjustment. See following example:

100% 2

(196.9")
5m

0% 1

Fig. 42: Parameter adjustment example Min./max. adjustment, level measure-


ment
1 Min. level = 0 % corresponds to 0.0 mbar
2 Max. level = 100 % corresponds to 490.5 mbar

If these values are not known, an adjustment with filling levels of e.g.
10 % and 90 % is also possible. By means of these settings, the real
filling height is then calculated.
The actual product level during this adjustment is not important,
because the min./max. adjustment is always carried out without
changing the product level. These settings can be made ahead of
time without the instrument having to be installed.
Note:
If the adjustment ranges are exceeded, the entered value will not be
accepted. Editing can be interrupted with [ESC] or corrected to a
value within the adjustment ranges.
45028-EN-220624

For the other process variables such as e.g. process pressure, differ-
ential pressure or flow, the adjustment is performed in like manner.

Zero adjustment Proceed as follows:

42 VEGABAR 82 • 4 … 20 mA/HART
6 Set up with the display and adjustment module

1. Select the menu item " Setup" with [->] and confirm with [OK].
Now select with [->] the menu item " Zero adjustment" and con-
firm with [OK].

2. Edit the mbar value with [OK] and set the cursor to the requested
position with [->].

3. Set the requested mbar value with [+] and store with [OK].
4. Go with [ESC] and [->] to the span adjustment
The zero adjustment is finished.
Information:
The Zero adjustment shifts the value of the span adjustment. The
span, i.e. the difference between these values, however, remains
unchanged.
For an adjustment with pressure, simply enter the actual measured
value indicated at the bottom of the display.
If the adjustment ranges are exceeded, the message " Outside
parameter limits" appears. The editing procedure can be aborted with
[ESC] or the displayed limit value can be accepted with [OK].

Span adjustment Proceed as follows:


1. Select with [->] the menu item Span adjustment and confirm with
[OK].

2. Edit the mbar value with [OK] and set the cursor to the requested
position with [->].

3. Set the requested mbar value with [+] and store with [OK].
For an adjustment with pressure, simply enter the actual measured
value indicated at the bottom of the display.
45028-EN-220624

If the adjustment ranges are exceeded, the message " Outside


parameter limits" appears. The editing procedure can be aborted with
[ESC] or the displayed limit value can be accepted with [OK].
The span adjustment is finished.

VEGABAR 82 • 4 … 20 mA/HART 43
6 Set up with the display and adjustment module

Min. adjustment - Level Proceed as follows:


1. Select the menu item " Setup" with [->] and confirm with [OK].
Now select with [->] the menu item " Adjustment", then " Min.
adjustment" and confirm with [OK].

2. Edit the percentage value with [OK] and set the cursor to the
requested position with [->].
3. Set the requested percentage value (e.g. 10 %) with [+] and save
with [OK]. The cursor jumps now to the pressure value.
4. Enter the pressure value corresponding to the min. level (e.g.
0 mbar).
5. Save settings with [OK] and move with [ESC] and [->] to the max.
adjustment.
The min. adjustment is finished.
For an adjustment with filling, simply enter the actual measured value
indicated at the bottom of the display.

Max. adjustment - Level Proceed as follows:


1. Select with [->] the menu item Max. adjustment and confirm with
[OK].

2. Edit the percentage value with [OK] and set the cursor to the
requested position with [->].
3. Set the requested percentage value (e.g. 90 %) with [+] and save
with [OK]. The cursor jumps now to the pressure value.
4. Enter the pressure value for the full vessel (e.g. 900 mbar) cor-
responding to the percentage value.
5. Save settings with [OK]
The max. adjustment is finished.
For an adjustment with filling, simply enter the actual measured value
indicated at the bottom of the display.

Damping To damp process-dependent measured value fluctuations, set an


integration time of 0 … 999 s in this menu item. The increment is 0.1 s.
The set damping is effective for level and process pressure measure-
ment as well as for all applications of electronic differential pressure
45028-EN-220624

measurement.

44 VEGABAR 82 • 4 … 20 mA/HART
6 Set up with the display and adjustment module

The default setting is a damping of 0 s.

Linearisation A linearization is necessary for all vessels in which the vessel volume
does not increase linearly with the level - e.g. a horizontal cylindri-
cal or spherical tank - and the indication or output of the volume is
required. Corresponding linearization curves are preprogrammed for
these vessels. They represent the correlation between the level per-
centage and vessel volume. The linearization applies to the measured
value indication and the current output.

With flow measurement and selection " Linear" display and output
(percentage/current) are linear to " Differential pressure". This can
be used, for example, to feed a flow computer.
With flow measurement and selection " Extraction by root"display and
output (percentage/current) are linear to " Flow". 2)
With flow in two directions (bidirectional) a negative differential pres-
sure is also possible. This must already be taken into account in menu
item " Min. adjustment flow".
Caution:
Note the following, if the respective sensor is used as part of an over-
fill protection system according to WHG:
If a linearisation curve is selected, the measuring signal is no longer
necessarily linear to the filling height. This must be considered by the
user especially when setting the switching point on the limit signal
transmitter.

Current output In the menu items " Current output" you determine the properties of
the current output.
On instruments with integrated additional current output, the proper-
ties for each current output are adjusted individually. The following
descriptions apply to both current outputs.

Current output (mode) In the menu item " Current output mode" you determine the output
characteristics and reaction of the current output in case of fault.

The default setting is output characteristics 4 … 20 mA, fault mode


< 3.6 mA.
45028-EN-220624

Current output (min./ In the menu item " Current output Min./Max.", you determine the reac-
max.) tion of the current output during operation.
2)
The device assumes an approximately constant temperature and static
pressure and converts the differential pressure into the flow rate via the
characteristic curve extracted by root.

VEGABAR 82 • 4 … 20 mA/HART 45
6 Set up with the display and adjustment module

The default setting is min. current 3.8 mA and max. current 20.5 mA.

Lock/Unlock adjustment In the menu item " Lock/unlock adjustment" you safeguard the sensor
parameters against unauthorized or unintentional modifications.
This is done by entering a four-digit PIN.

With active PIN, only the following adjustment functions are possible
without entering a PIN:
• Select menu items and show data
• Read data from the sensor into the display and adjustment module
Releasing the sensor adjustment is also possible in any menu item by
entering the PIN.
Caution:
With active PIN, adjustment via PACTware/DTM and other systems is
also blocked.

6.5.2 Display
Language This menu item enables the setting of the requested national lan-
guage.

The following languages are available:


• German
• English
• French
• Spanish
• Russian
• Italian
• Dutch
• Portuguese
• Japanese
• Chinese
• Polish
• Czech
45028-EN-220624

• Turkish
In delivery status, the VEGABAR 82 is set to English.

Display value 1 and 2 In this menu item, you define which measured value is displayed.

46 VEGABAR 82 • 4 … 20 mA/HART
6 Set up with the display and adjustment module

The setting in the delivery status for the display value is " Lin. per-
cent".

Display format 1 and 2 In this menu item you define the number of decimal positions with
which the measured value is displayed.

The setting in the delivery status for the display format is " Automatic".

Backlight The display and adjustment module has a backlight for the display.
In this menu item you can switch on the lighting. You can find the
required operating voltage in chapter " Technical data".

In delivery status, the lighting is switched on.

6.5.3 Diagnostics
Device status In this menu item, the device status is displayed.

In case of error, e.g. the error code F017, e.g. the error description "
Adjustment span too small" and a four digit figure are displayed for
service purposes. You can find the error codes with description, rea-
son as well as rectification in chapter " Asset Management".

Peak value, pressure The respective min. and max. measured values are saved in the
sensor. The two values are displayed in menu item " Peak values,
pressure".
In another window you can carry out a reset of the peak values
separately.
45028-EN-220624

Peak value, temperature The respective min. and max. measured values of the measuring cell
and the electronics temperature are stored in the sensor. In menu
item " Peak value, temperature", both values are displayed.

VEGABAR 82 • 4 … 20 mA/HART 47
6 Set up with the display and adjustment module

In another window you can carry out a reset of the two peak values
separately.

Simulation In this menu item you can simulate measured values. This allows the
signal path to be tested, e.g. through downstream indicating instru-
ments or the input card of the control system.

Select the requested simulation variable and set the requested value.
To deactivate the simulation, you have to push the [ESC] key and
confirm the message " Deactivate simulation" with the [OK] key.
Caution:
During simulation, the simulated value is output as 4 … 20 mA current
value and with instruments 4 … 20 mA/HART in addition as digital
HART signal. The status message within the context of the asset
management function is " Maintenance".

Note:
Without manual deactivation, the sensor terminates the simulation
automatically after 60 minutes.

6.5.4 Additional adjustments


Date/Time In this menu item, you adjust the internal clock of the sensor. There is
no adjustment for summer/winter (daylight saving) time.

Reset After a reset, certain parameter adjustments made by the user are
reset.
45028-EN-220624

The following reset functions are available:


Delivery status: Restores the parameter settings at the time of
shipment from the factory, incl. the order-specific settings. Any user-

48 VEGABAR 82 • 4 … 20 mA/HART
6 Set up with the display and adjustment module

defined linearisation curve as well as the measured value memory are


deleted.
Basic settings: Resets the parameter settings, incl. special param-
eters, to the default values of the respective instrument. Any pro-
grammed linearisation curve as well as the measured value memory
are deleted.
Note:
You can find the default values of the device in chapter " Menu over-
view".

Copy instrument settings The instrument settings are copied with this function. The following
functions are available:
• Read from sensor: Read data from sensor and store into the
display and adjustment module
• Write into sensor: Store data from the display and adjustment
module back into the sensor
The following data or settings for adjustment of the display and ad-
justment module are saved:
• All data of the menu " Setup" and " Display"
• In the menu " Additional adjustments" the items " Reset, Date/
Time"
• The user-programmable linearization curve

The copied data are permanently saved in an EEPROM memory in


the display and adjustment module and remain there even in case of
power failure. From there, they can be written into one or more sen-
sors or kept as backup for a possible electronics exchange.
Note:
Before the data are saved in the sensor, a safety check is carried out
to determine if the data match the sensor. In the process the sensor
type of the source data as well as the target sensor are displayed. If
the data do not match, a fault message is outputted or the function is
blocked. The data are saved only after release.

Special parameters In this menu item you gain access to the protected area where
you can enter special parameters. In exceptional cases, individual
parameters can be modified in order to adapt the sensor to special
requirements.
Change the settings of the special parameters only after having con-
tacted our service staff.
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 49
6 Set up with the display and adjustment module

Scaling (1) In menu item " Scaling" you define the scaling variable and the scal-
ing unit for the level value on the display, e.g. volume in l.

Scaling (2) In menu item " Scaling (2)" you define the scaling format on the dis-
play and the scaling of the measured level value for 0 % and 100 %.

Current output In the menu items " Current output" you determine the properties of
the current output.
On instruments with integrated additional current output, the proper-
ties for each current output are adjusted individually. The following
descriptions apply to both current outputs.

Current output (meas. In menu item " Current output, variable" you specify which measured
variable) variable is output via the current output.

Current output (adjust- Depending on the selected measured variable, you assign in the
ment) menu item " Current output, adjustment" the measured values that
4 mA (0 %) and 20 mA (100 %) of the current output refer to.

If the measuring cell temperature is selected as measured variable,


then e.g. 0 °C refers to 4 mA and 100 °C to 20 mA.

HART mode The sensor offers the HART modes " Analogue current output" and "
Fix current (4 mA)". In this menu item you determine the HART mode
and enter the address with Multidrop mode.
In the mode " Fixed current output" up to 63 sensors can be operated
45028-EN-220624

on one two-wire cable (Multidrop operation). An address between 0


and 63 must be assigned to each sensor.

50 VEGABAR 82 • 4 … 20 mA/HART
6 Set up with the display and adjustment module

If you select the function " Analogue current output" and also enter
an address number, you can output a 4 … 20 mA signal in Multidrop
mode.
In the mode " Fixed current (4 mA)" a fixed 4 mA signal is output
independently of the actual level.

The setting in the delivery status is " Analogue current output" and the
address 00.

6.5.5 Info
Device name In this menu item, you can read out the instrument name and the
instrument serial number:

Instrument version In this menu item, the hardware and software version of the sensor is
displayed.

Factory calibration date In this menu item, the date of factory calibration of the sensor as well
as the date of the last change of sensor parameters are displayed via
the display and adjustment module or via the PC.

Sensor characteristics In this menu item, the features of the sensor such as approval, pro-
cess fitting, seal, measuring range, electronics, housing and others
are displayed.

6.6 Menu overview


45028-EN-220624

The following tables show the adjustment menu of the instrument.


Depending on the instrument version or application, all menu items
may not be available or some may be differently assigned.

VEGABAR 82 • 4 … 20 mA/HART 51
6 Set up with the display and adjustment module

Setup
Menu item Parameter Default value
Measurement loop name 19 alphanumeric characters/special Sensor
characters
Application Level, process pressure Level
Secondary Device for electronic differen- Deactivated
tial pressure 3)
Units Adjustment unit (m, bar, Pa, psi … user- mbar (with nominal measuring range
defined) ≤ 400 mbar)
bar (with nominal measuring ranges
≥ 1 bar)
Temperature unit (°C, °F) °C
Position correction Offset 0.00 bar
Adjustment Zero/Min. adjustment 0.00 bar
0.00 %
Span/Max. adjustment Nominal measuring range in bar
100.00 %
Damping Integration time 1 s
Linearisation Linear, cylindrical tank, … user-defined Linear
Current output Current output - Mode
Output characteristics: 4 … 20 mA, 4 … 20 mA
20 … 4 mA
Failure mode: ≤ 3.6 mA, ≥ 20 mA, last ≤ 3.6 mA
measured value
Current output - Min./Max.
Min. current: 3.8 mA, 4 mA 3.8 mA
Max. current: 20 mA, 20.5 mA 20.5 mA
Lock adjustment Blocked, released Released

Display
Menu item Default value
Menu language Selected language
Displayed value 1 Pressure
Displayed value 2 Ceramic measuring cell: Measuring cell temperature in °C
Metallic measuring cell: Electronics temperature in °C
Display format Number of positions after the decimal point, automatically
Backlight Switched on
45028-EN-220624

3)
Parameter only active if the instrument is connected to the Secondary Device

52 VEGABAR 82 • 4 … 20 mA/HART
6 Set up with the display and adjustment module

Diagnostics
Menu item Parameter Default value
Device status -
Peak value Pressure Current pressure measured value
Pointer function temp. Temperature Actual measuring cell and electronic tem-
perature
Simulation Pressure, percent, current output, Process pressure
linearized percent, measuring cell tem-
perature, electronics temperature

Additional adjustments
Menu item Parameter Default value
Date/Time Actual date/Actual time
Reset Delivery status, basic settings
Copy instrument settings Read from sensor, write into sensor
Scaling Scaling size Volume in l
Scaling format 0 % corresponds to 0 l
100 % corresponds to 0 l
Current output Current output - Meas. variable Lin. percent - Level
Current output - Adjustment 0 … 100 % correspond to 4 … 20 mA
Current output 2 Current output - Meas. variable Measuring cell temperature (ceramic
measuring cell)
Current output - Adjustment 0 … 100 °C correspond to 4 … 20 mA
HART mode HART address, current output Address 00, analogue current output
Special parameters Service-Login No reset

Info
Menu item Parameter
Device name VEGABAR 82
Instrument version Hardware and software version
Factory calibration date Date
Sensor characteristics Order-specific characteristics

6.7 Save parameter adjustment data


On paper We recommended writing down the adjustment data, e.g. in this op-
erating instructions manual, and archiving them afterwards. They are
thus available for multiple use or service purposes.
45028-EN-220624

In the display and adjust- If the instrument is equipped with a display and adjustment module,
ment module the parameter adjustment data can be saved therein. The procedure
is described in menu item " Copy device settings".

VEGABAR 82 • 4 … 20 mA/HART 53
6 Set up with the display and adjustment module

45028-EN-220624

54 VEGABAR 82 • 4 … 20 mA/HART
7 Setup with PACTware

7 Setup with PACTware


7.1 Connect the PC
Via the interface adapter
directly on the sensor

2
1

Fig. 43: Connection of the PC directly to the sensor via the interface adapter
1 USB cable to the PC
2 Interface adapter VEGACONNECT
3 Sensor

Via the interface adapter


and HART 4

1 2

3
Fig. 44: Connecting the PC via HART to the signal cable
1 Sensor
2 HART resistance 250 Ω (optional depending on evaluation)
3 Connection cable with 2 mm pins and terminals
4 Processing system/PLC/Voltage supply
5 Interface adapter, for example VEGACONNECT 4

Note:
With power supply units with integrated HART resistance (internal
resistance approx. 250 Ω), an additional external resistance is not
necessary. This applies, e.g. to the VEGA instruments VEGATRENN
149A, VEGAMET 381, VEGAMET 391. Common Ex separators are
also usually equipped with a sufficient current limiting resistance. In
such cases, the interface adapter can be connected parallel to the
4 … 20 mA cable (dashed line in the previous illustration).
45028-EN-220624

7.2 Parameterization
Prerequisites For parameter adjustment of the instrument via a Windows PC, the
configuration software PACTware and a suitable instrument driver

VEGABAR 82 • 4 … 20 mA/HART 55
7 Setup with PACTware

(DTM) according to FDT standard are required. The latest PACTware


version as well as all available DTMs are compiled in a DTM Collec-
tion. The DTMs can also be integrated into other frame applications
according to FDT standard.
Note:
To ensure that all instrument functions are supported, you should
always use the latest DTM Collection. Furthermore, not all described
functions are included in older firmware versions. You can download
the latest instrument software from our homepage. A description of
the update procedure is also available in the Internet.
Further setup steps are described in the operating instructions manu-
al " DTM Collection/PACTware" attached to each DTM Collection and
which can also be downloaded from the Internet. Detailed descrip-
tions are available in the online help of PACTware and the DTMs.

Fig. 45: Example of a DTM view

Standard/Full version All device DTMs are available as a free-of-charge standard version
and as a full version that must be purchased. In the standard version,
all functions for complete setup are already included. An assistant for
simple project configuration simplifies the adjustment considerably.
Saving/printing the project as well as import/export functions are also
part of the standard version.
In the full version there is also an extended print function for complete
project documentation as well as a save function for measured value
and echo curves. In addition, there is a tank calculation program as
well as a multiviewer for display and analysis of the saved measured
value and echo curves.
45028-EN-220624

The standard version is available as a download under


www.vega.com/downloads and " Software". The full version is avail-
able on CD from the agency serving you.

56 VEGABAR 82 • 4 … 20 mA/HART
7 Setup with PACTware

7.3 Save parameter adjustment data


We recommend documenting or saving the parameterisation data via
PACTware. That way the data are available for multiple use or service
purposes.
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 57
8 Set up with other systems

8 Set up with other systems


8.1 DD adjustment programs
Device descriptions as Enhanced Device Description (EDD) are
available for DD adjustment programs such as, for example, AMS™
and PDM.
The files can be downloaded at www.vega.com/downloads under "
Software".

8.2 Field Communicator 375, 475


Device descriptions for the instrument are available as EDD for pa-
rameterisation with Field Communicator 375 or 475.
Integrating the EDD into the Field Communicator 375 or 475 requires
the "Easy Upgrade Utility" software, which is available from the manu-
facturer. This software is updated via the Internet and new EDDs are
automatically accepted into the device catalogue of this software after
they are released by the manufacturer. They can then be transferred
to a Field Communicator.
In the HART communication, the Universal Commands and a part of
the Common Practice Commands are supported.

45028-EN-220624

58 VEGABAR 82 • 4 … 20 mA/HART
9 Diagnosis, asset management and service

9 Diagnosis, asset management and service


9.1 Maintenance
Maintenance If the device is used properly, no special maintenance is required in
normal operation.

Precaution measures In some applications, product buildup on the diaphragm can influence
against buildup the measuring result. Depending on the sensor and application, take
precautions to ensure that heavy buildup, and especially a hardening
thereof, is avoided.

Cleaning The cleaning helps that the type label and markings on the instrument
are visible.
Take note of the following:
• Use only cleaning agents which do not corrode the housings, type
label and seals
• Use only cleaning methods corresponding to the housing protec-
tion rating

9.2 Cleaning - hygienic connection with


compression nut
Overview The hygienic connection with compression nut can be disassembled
and the diaphragm cleaned.
The following graphic shows the structure:

1
4
2
5
3
6
7
Fig. 46: VEGABAR 82, structure of the hygienic connection with compression
nut
1 Hexagon
2 Compression nut
3 Process fitting
4 Process module
5 Form seal for the measuring cell
6 O-ring seal for the process fitting
7 Diaphragm

Procedure To do so, proceed as follows:


1. Loosen compression nut and remove the pressure transmitter
45028-EN-220624

from the welded socket


2. Remove the O-ring seal for the process fitting
3. Clean the diaphragm with brass brush and cleaning detergent

VEGABAR 82 • 4 … 20 mA/HART 59
9 Diagnosis, asset management and service

4. Loosen the hexagon and remove the process component from


the process fitting
5. Remove the form seal for the measuring cell and remove it by a
new one
6. Screw the process component into the process fitting, tighten the
hexagon (wrench size see chapter " Dimensions", max. torque
see chapter " Technical data")
7. Insert new O-ring seal for the process fitting
8. Install the process pressure transmitter in the welded socket,
tighten compression nut
The cleaning is finished.
The pressure transmitter is directly ready for operation, a fresh adjust-
ment is not required.

9.3 Diagnosis memory


The instrument has several memories available for diagnostic pur-
poses. The data remain there even in case of voltage interruption.

Measured value memory Up to 100,000 measured values can be stored in the sensor in a ring
memory. Each entry contains date/time as well as the respective
measured value.
Depending on the instrument version, values that can be stored are
for example:
• Level
• Process pressure
• Differential pressure
• Static pressure
• Percentage value
• Scaled values
• Current output
• Lin. percent
• Measuring cell temperature
• Electronics temperature
When the instrument is shipped, the measured value memory is ac-
tive and stores pressure value and measuring cell temperature every
10 s, with electronic differential pressure also the static pressure.
The requested values and recording conditions are set via a PC with
PACTware/DTM or the control system with EDD. Data are thus read
out and also reset.

Event memory Up to 500 events are automatically stored with a time stamp in the
sensor (non-deletable). Each entry contains date/time, event type,
event description and value.
Event types are for example:
45028-EN-220624

• Modification of a parameter
• Switch-on and switch-off times
• Status messages (according to NE 107)
• Error messages (according to NE 107)

60 VEGABAR 82 • 4 … 20 mA/HART
9 Diagnosis, asset management and service

The data are read out via a PC with PACTware/DTM or the control
system with EDD.

9.4 Asset Management function


The instrument features self-monitoring and diagnostics according
to NE 107 and VDI/VDE 2650. In addition to the status messages in
the following tables there are more detailed error messages available
under the menu item " Diagnostics" via the respective adjustment
module.

Status messages The status messages are divided into the following categories:
• Failure
• Function check
• Out of specification
• Maintenance required
and explained by pictographs:

1 2 3 4
Fig. 47: Pictographs of the status messages
1 Failure - red
2 Out of specification - yellow
3 Function check - orange
4 Maintenance required - blue

Malfunction (Failure):
Due to a malfunction in the instrument, a fault signal is output.
This status message is always active. It cannot be deactivated by the
user.

Function check:
The instrument is being worked on, the measured value is temporarily
invalid (for example during simulation).
This status message is inactive by default.

Out of specification:
The measured value is unreliable because an instrument specification
was exceeded (e.g. electronics temperature).
This status message is inactive by default.

Maintenance required:
Due to external influences, the instrument function is limited. The
measurement is affected, but the measured value is still valid. Plan in
45028-EN-220624

maintenance for the instrument because a failure is expected in the


near future (e.g. due to buildup).
This status message is inactive by default.

VEGABAR 82 • 4 … 20 mA/HART 61
9 Diagnosis, asset management and service

Failure
Code Cause Rectification DevSpec
Text message State in CMD 48
F013 Gauge pressure or low pressure Exchange measuring cell Byte 5, Bit 0 of
No valid measured val- Measuring cell defective Send instrument for repair Byte 0 … 5
ue available
F017 Adjustment not within specifi- Change the adjustment accord- Byte 5, Bit 1 of
Adjustment span too cation ing to the limit values Byte 0 … 5
small
F025 Index markers are not continu- Check linearization table Byte 5, Bit 2 of
Error in the lineariza- ously rising, for example illogical Delete table/Create new Byte 0 … 5
tion table value pairs

F036 Failed or interrupted software Repeat software update Byte 5, Bit 3 of


no operable sensor update Check electronics version Byte 0 … 5
software Exchanging the electronics
Send instrument for repair
F040 Hardware defect Exchanging the electronics Byte 5, Bit 4 of
Error in the electronics Send instrument for repair Byte 0 … 5

F041 No connection to the sensor Check connection between sen- -


Communication error electronics sor and main electronics (with
separate version)
F042 No connection to the Second- Check connection between Pri- -
Communication error ary sensor mary and Secondary sensor
Secondary sensor
F080 General software error Disconnect operating voltage Byte 5, Bit 5 of
General software error briefly Byte 0 … 5

F105 The instrument is still in the Wait for the end of the switch- Byte 5, Bit 6 of
Measured value is de- switch-on phase, the measured on phase Byte 0 … 5
termined value could not yet be deter-
mined
F113 Error in the internal instrument Disconnect operating voltage Byte 4, Bit 4 of
Communication error communication briefly Byte 0 … 5
Send instrument for repair
F260 Error in the calibration carried Exchanging the electronics Byte 4, Bit 0 of
Error in the calibration out in the factory Send instrument for repair Byte 0 … 5
Error in the EEPROM
F261 Error during setup Repeat setup Byte 4, Bit 1 of
Error in the instrument Error when carrying out a reset Repeat reset Byte 0 … 5
settings
45028-EN-220624

62 VEGABAR 82 • 4 … 20 mA/HART
9 Diagnosis, asset management and service

Code Cause Rectification DevSpec


Text message State in CMD 48
F264 Inconsistent settings (e.g.: dis- Modify settings Byte 4, Bit 2 of
Installation/Setup error tance, adjustment units with Modify connected sensor con- Byte 0 … 5
application process pressure) figuration or application
for selected application
Invalid sensor configuration
(e.g.: application electronic
differential pressure with con-
nected differential pressure
measuring cell)
F265 Sensor no longer carries out a Carry out a reset Byte 4, Bit 3 of
Measurement function measurement Disconnect operating voltage Byte 0 … 5
disturbed briefly

Function check
Code Cause Rectification DevSpec
Text message State in CMD 48
C700 A simulation is active Finish simulation "Simulation Active"
Simulation active Wait for the automatic end after in "Standardized
60 mins. Status 0"

Tab. 9: Error codes and text messages, information on causes as well as corrective measures
Out of specification
Code Cause Rectification DevSpec
Text message State in CMD 48
S600 Temperature of the electronics Check ambient temperature Byte 23, Bit 0 of
Impermissible electron- in the non-specified range Insulate electronics Byte 14 … 24
ics temperature
S603 Operating voltage below speci- Check electrical connection -
Impermissible operating fied range If necessary, increase operat-
voltage ing voltage
S605 Measured process pressure be- Check nominal measuring range -
Impermissible pressure low or above the adjustment of the instrument
value range If necessary, use an instrument
with a higher measuring range

Maintenance
Code Cause Rectification DevSpec
Text message State in CMD 48
M500 The data could not be restored Repeat reset Bit 0 of
Error in the delivery during the reset to delivery sta- Load XML file with sensor data Byte 14 … 24
status tus into the sensor
45028-EN-220624

M501 Index markers are not continu- Check linearization table Bit 1 of
Error in the non-active ously rising, for example illogical Delete table/Create new Byte 14 … 24
linearisation table value pairs

VEGABAR 82 • 4 … 20 mA/HART 63
9 Diagnosis, asset management and service

Code Cause Rectification DevSpec


Text message State in CMD 48
M502 Hardware error EEPROM Exchanging the electronics Bit 2 of
Error in the event mem- Send instrument for repair Byte 14 … 24
ory
M504 Hardware defect Exchanging the electronics Bit 3 of
Error at a device in- Send instrument for repair Byte 14 … 24
terface
M507 Error during setup Carry out reset and repeat setup Bit 4 of
Error in the instrument Error when carrying out a reset Byte 14 … 24
settings

9.5 Rectify faults


Reaction when malfunc- The operator of the system is responsible for taking suitable meas-
tion occurs ures to rectify faults.

Fault rectification The first measures are:


• Evaluation of fault messages
• Checking the output signal
• Treatment of measurement errors
A smartphone/tablet with the adjustment app or a PC/notebook with
the software PACTware and the suitable DTM offer you further com-
prehensive diagnostic possibilities. In many cases, the causes can be
determined in this way and the faults eliminated.

4 … 20 mA signal Connect a multimeter in the suitable measuring range according to


the wiring plan. The following table describes possible errors in the
current signal and helps to eliminate them:
Error Cause Rectification
4 … 20 mA signal not stable Fluctuating measured value Set damping
4 … 20 mA signal missing Electrical connection faulty Check connection, correct, if necessary
Voltage supply missing Check cables for breaks; repair if nec-
essary
Operating voltage too low, load resist- Check, adapt if necessary
ance too high
Current signal greater than Sensor electronics defective Replace device or send in for repair de-
22 mA, less than 3.6 mA pending on device version

Reaction after fault recti- Depending on the reason for the fault and the measures taken, the
fication steps described in chapter " Setup" must be carried out again or must
be checked for plausibility and completeness.
45028-EN-220624

24 hour service hotline Should these measures not be successful, please call in urgent cases
the VEGA service hotline under the phone no. +49 1805 858550.
The hotline is also available outside normal working hours, seven
days a week around the clock.

64 VEGABAR 82 • 4 … 20 mA/HART
9 Diagnosis, asset management and service

Since we offer this service worldwide, the support is provided in


English. The service itself is free of charge, the only costs involved are
the normal call charges.

9.6 Exchange process module on version IP68


(25 bar)
On version IP68 (25 bar), the user can exchange the process module
on site. Connection cable and external housing can be kept.
Required tools:
• Hexagon key wrench, size 2

Caution:
The exchange may only be carried out in the complete absence of
line voltage.
In Ex applications, only a replacement part with appropriate Ex ap-
proval may be used.

Caution:
During exchange, protect the inner side of the parts against contami-
nation and moisture.
Proceed as follows when carrying out the exchange:
1. Losen the fixing screw with the hexagon key wrench
2. Carefully detach the cable assembly from the process module

5
4
3

Fig. 48: VEGABAR 82 in IP68 version, 25 bar and lateral cable outlet, external
housing
1 Process module
2 Plug connector
3 Fixing screw
4 Cable assembly
5 Connection cable
6 External housing

3. Loosen the plug connector


45028-EN-220624

4. Mount the new process module on the measuring point


5. Plug the connector back in
6. Mount the cable assembly on the process module and turn it to
the desired position

VEGABAR 82 • 4 … 20 mA/HART 65
9 Diagnosis, asset management and service

7. Tighten the fixing screw with the hexagon key wrench


The exchange is finished.

9.7 Exchanging the electronics module


In case of a defect, the user can replace the electronics module with
another one of identical type.
In Ex applications, only instruments and electronics modules with ap-
propriate Ex approval may be used.
You can find detailed information you need to carry out an electronics
exchange in the handbook of the electronics module.

9.8 Software update


The following components are required to update the instrument
software:
• Instrument
• Voltage supply
• Interface adapter VEGACONNECT
• PC with PACTware
• Current instrument software as file
You can find the current instrument software as well as detailed
information on the procedure in the download area of our homepage:
www.vega.com.
You can find information about the installation in the download file.
Caution:
Instruments with approvals can be bound to certain software versions.
Therefore make sure that the approval is still effective after a software
update is carried out.
You can find detailed information in the download area at
www.vega.com.

9.9 How to proceed if a repair is necessary


You can find an instrument return form as well as detailed information
about the procedure in the download area of our homepage. By doing
this you help us carry out the repair quickly and without having to call
back for needed information.
Proceed as follows in case of repair:
• Print and fill out one form per instrument
• Clean the instrument and pack it damage-proof
• Attach the completed form and, if need be, also a safety data
sheet outside on the packaging
• Ask the agency serving you to get the address for the return ship-
ment. You can find the agency on our homepage.
45028-EN-220624

66 VEGABAR 82 • 4 … 20 mA/HART
10 Dismount

10 Dismount
10.1 Dismounting steps
To remove the device, carry out the steps in chapters " Mounting" and
" Connecting to power suplly" in reverse.
Warning:
When dismounting, pay attention to the process conditions in vessels
or pipelines. There is a risk of injury, e.g. due to high pressures or tem-
peratures as well as aggressive or toxic media. Avoid this by taking
appropriate protective measures.

10.2 Disposal
Pass the instrument on to a specialised recycling company and do not
use the municipal collecting points.
Remove any batteries in advance, if they can be removed from the
device, and dispose of them separately.
If personal data is stored on the old device to be disposed of, delete it
before disposal.
If you have no way to dispose of the old instrument properly, please
contact us concerning return and disposal.
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 67
11 Supplement

11 Supplement
11.1 Technical data
Note for approved instruments
The technical data in the respective safety instructions which are included in delivery are valid for
approved instruments (e.g. with Ex approval). These data can differ from the data listed herein, for
example regarding the process conditions or the voltage supply.
All approval documents can be downloaded from our homepage.

Materials and weights


Materials, wetted parts
Process fitting 316L, PVDF, PEEK, Alloy C22 (2.4602), Alloy C276
(2.4819), Duplex steel (1.4462), Titanium Grade 2
Diaphragm Sapphire-ceramic® (> 99.9 % Al2O3 ceramic)
Joining material measuring cell Glass (with double and form seal, non-wetted parts)
Measuring cell seal
ƲƲ Standard (O-ring seal) FKM (VP2/A, A+P 70.16), EPDM (A+P 70.10-02), FFKM
(Kalrez 6375, Perlast G74S, Perlast G75B)
ƲƲ Hygienic fitting with compression nut FKM (ET 6067), EPDM (EPDM 7076), FFKM (Chem-
(form seal) raz 535), FEPM (Fluoraz SD890)
Seal for process fitting (in the scope of delivery)
ƲƲ Thread G½ (EN 837), G1½ Klingersil C-4400
(DIN 3852-A)
ƲƲ Thread M44 x 1.25 (DIN 13), FKM, FFKM, EPDM
M30 x 1.5
ƲƲ Hygienic connection with compres- FKM, EPDM, FFKM, FEPM
sion nut
Surface quality, hygienic fittings, typ.
ƲƲ Process fitting Ra < 0.8 µm
ƲƲ Diaphragm Ra < 0.5 µm
Materials, non-wetted parts
Sensor housing
ƲƲ Housing Plastic PBT (Polyester), Aluminium AlSi10Mg (powder-
coated, basis: Polyester), 316L
ƲƲ Cable gland PA, stainless steel, brass
ƲƲ Cable gland: Seal, closure NBR, PA
ƲƲ Seal, housing lid Silicone SI 850 R, NBR silicone-free
ƲƲ Inspection window housing cover Polycarbonate (UL-746-C listed), glass 4)
ƲƲ Ground terminal 316L
External housing - deviating materials
45028-EN-220624

ƲƲ Housing and socket Plastic PBT (Polyester), 316L

4)
Glass with Aluminium and stainless steel precision casting housing

68 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

ƲƲ Socket seal EPDM


ƲƲ Seal below wall mounting plate 5) EPDM
ƲƲ Inspection window housing cover Polycarbonate (UL-746-C listed)
Ground terminal 316Ti/316L
Connection cable with IP68 (25 bar) 6)
ƲƲ Cable cover PE, PUR
ƲƲ Type label support on cable PE hard
Connection cable with IP68 (1 bar) 7) PE, PUR
Weights
Total weight VEGABAR 82 approx. 0.8 … 8 kg (1.764 … 17.64 lbs), depending on
process fitting and housing

Torques
Max. torque for process fitting
ƲƲ G½ PVDF 5 Nm (3.688 lbf ft)
ƲƲ G½ PEEK, 10 Nm (7.376 lbf ft)
ƲƲ G½, G¾ 30 Nm (22.13 lbf ft)
ƲƲ Fittings according to 3A with ex- 20 Nm (14.75 lbf ft)
changeable sealing
ƲƲ Hygienic fitting with compression nut 40 Nm (29.50 lbf ft)
(hexagon)
ƲƲ G1, M30 x 1.5 50 Nm (36.88 lbf ft)
ƲƲ G1 for PASVE 100 Nm (73.76 lbf ft)
ƲƲ G1½ 200 Nm (147.5 lbf ft)
Max. torque for screws
ƲƲ PMC 1", PMC 1¼" 2 Nm (1.475 lbf ft)
ƲƲ PMC 1½" 5 Nm (3.688 lbf ft)
Max. torque for NPT cable glands and Conduit tubes
ƲƲ Plastic housing 10 Nm (7.376 lbf ft)
ƲƲ Aluminium/Stainless steel housing 50 Nm (36.88 lbf ft)

Input variable
The specifications are only an overview and refer to the measuring cell. Limitations due to the
material and version of the process fitting as well as the selected pressure type are possible. The
specifications on the nameplate apply. 8)
45028-EN-220624

5)
Only for 316L with 3A approval
6)
Between transmitter and external electronics housing.
7)
Fix connected to the sensor.
8)
Data on overload capability apply for reference temperature.

VEGABAR 82 • 4 … 20 mA/HART 69
11 Supplement

Nominal measuring ranges and overload capability in bar/kPa


Nominal range Overload capability
Maximum pressure Minimum pressure
Gauge pressure
0 … +0.025 bar/0 … +2.5 kPa +5 bar/+500 kPa -0.05 bar/-5 kPa
(only for measuring cell ø 28 mm)
0 … +0.1 bar/0 … +10 kPa +15 bar/+1500 kPa -0.2 bar/-20 kPa
0 … +0.4 bar/0 … +40 kPa +30 bar/+3000 kPa -0.8 bar/-80 kPa
0 … +1 bar/0 … +100 kPa +35 bar/+3500 kPa -1 bar/-100 kPa
0 … +2.5 bar/0 … +250 kPa +50 bar/+5000 kPa -1 bar/-100 kPa
0 … +5 bar/0 … +500 kPa +65 bar/+6500 kPa -1 bar/-100 kPa
0 … +10 bar/0 … +1000 kPa +90 bar/+9000 kPa -1 bar/-100 kPa
0 … +25 bar/0 … +2500 kPa +125 bar/+12500 kPa -1 bar/-100 kPa
0 … +60 bar/0 … +6000 kPa +200 bar/+20000 kPa -1 bar/-100 kPa
0 … +100 bar/0 … +10000 kPa +200 bar/+20000 kPa -1 bar/-100 kPa
(only for measuring cell ø 28 mm)
-1 … 0 bar/-100 … 0 kPa +35 bar/+3500 kPa -1 bar/-100 kPa
-1 … +1.5 bar/-100 … +150 kPa +40 bar/+4000 kPa -1 bar/-100 kPa
-1 … +5 bar/-100 … +500 kPa +65 bar/+6500 kPa -1 bar/-100 kPa
-1 … +10 bar/-100 … +1000 kPa +90 bar/+9000 kPa -1 bar/-100 kPa
-1 … +25 bar/-100 … +2500 kPa +125 bar/+12500 kPa -1 bar/-100 kPa
-1 … +60 bar/-100 … +6000 kPa +200 bar/+20000 kPa -1 bar/-100 kPa
-1 … +100 bar/-100 … +10000 kPa +200 bar/+20000 kPa -1 bar/-100 kPa
(only for measuring cell ø 28 mm)
-0.025 … +0.025 bar/-2.5 … +2.5 kPa +5 bar/+500 kPa -0.05 bar/-5 kPa
-0.05 … +0.05 bar/-5 … +5 kPa +15 bar/+1500 kPa -0.2 bar/-20 kPa
-0.2 … +0.2 bar/-20 … +20 kPa +20 bar/+2000 kPa -0.4 bar/-40 kPa
-0.5 … +0.5 bar/-50 … +50 kPa +35 bar/+3500 kPa -1 bar/-100 kPa
Absolute pressure
0 … 0.1 bar/0 … 10 kPa 15 bar/1500 kPa 0 bar abs.
0 … 1 bar/0 … 100 kPa 35 bar/3500 kPa 0 bar abs.
0 … 2.5 bar/0 … 250 kPa 50 bar/5000 kPa 0 bar abs.
0 … +5 bar/0 … +500 kPa 65 bar/+6500 kPa 0 bar abs.
0 … 10 bar/0 … 1000 kPa 90 bar/9000 kPa 0 bar abs.
0 … 25 bar/0 … 2500 kPa 125 bar/12500 kPa 0 bar abs.
0 … 60 bar/0 … 6000 kPa 200 bar/20000 kPa 0 bar abs.
45028-EN-220624

0 … 100 bar/0 … +10000 kPa 200 bar/20000 kPa 0 bar abs.


(only for measuring cell ø 28 mm)

70 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

Nominal measuring ranges and overload capacity in psi


Nominal range Overload capability
Maximum pressure Minimum pressure
Gauge pressure
0 … +0.4 psig (only for measuring cell ø 28 mm) +75 psig -0.7 psig
0 … +1.5 psig +225 psig -3 psig
0 … +5 psig +375 psig -11.50 psig
0 … +15 psig +525 psig -14.51 psig
0 … +30 psig +725 psig -14.51 psig
0 … +75 psig +975 psig -14.51 psig
0 … +150 psig +1350 psig -14.51 psig
0 … +300 psig +1900 psig -14.51 psig
0 … +900 psig +2900 psig -14.51 psig
0 … +1450 psig (only for measuring cell ø 28 mm) +2900 psig -14.51 psig
-14.5 … 0 psig +525 psig -14.51 psig
-14.5 … +20 psig +600 psig -14.51 psig
-14.5 … +75 psig +975 psig -14.51 psig
-14.5 … +150 psig +1350 psig -14.51 psig
-14.5 … +300 psig +1900 psig -14.51 psig
-14.5 … +900 psig +2900 psig -14.51 psig
-14.5 … +1500 psig (only for measuring cell ø 28 mm) +2900 psig -14.51 psig
-0.7 … +0.7 psig +75 psig -2.901 psig
-3 … +3 psig +225 psi -5.800 psig
-7 … +7 psig +525 psig -14.51 psig
Absolute pressure
0 … 1.5 psi 225 psig 0 psi
0 … 15 psi 525 psi 0 psi
0 … 30 psi 725 psi 0 psi
0 … 75 psi 975 psi 0 psi
0 … 150 psi 1350 psi 0 psi
0 … 300 psi 1900 psi 0 psi
0 … 900 psi 2900 psi 0 psi
0 … 1450 psi (only for measuring cell ø 28 mm) 2900 psi 0 psi

Adjustment ranges
Specifications refer to the nominal measuring range, pressure values lower than -1 bar cannot be
45028-EN-220624

set
Min./Max. adjustment:
ƲƲ Percentage value -10 … 110 %

VEGABAR 82 • 4 … 20 mA/HART 71
11 Supplement

ƲƲ Pressure value -20 … 120 %


Zero/Span adjustment:
ƲƲ Zero -20 … +95 %
ƲƲ Span -120 … +120 %
ƲƲ Difference between zero and span max. 120 % of the nominal range
Max. permissible Turn Down Unlimited (recommended 20 : 1)

Switch-on phase
Start-up time with operating voltage UB
ƲƲ ≥ 12 V DC ≤ 9 s
ƲƲ < 12 V DC ≤ 22 s
Starting current (for run-up time) ≤ 3.6 mA

Output variable
For details on the operating voltage see chapter "Voltage supply"
Output signal 4 … 20 mA/HART
Range of the output signal 3.8 … 20.5 mA/HART (default setting)
Fulfilled HART specification 7.3
Signal resolution 0.3 µA
Fault signal, current output (adjustable) ≤ 3.6 mA, ≥ 21 mA, last measured value 9)
Max. output current 21.5 mA
Load See load resistance under Power supply
Starting current ≤ 10 mA for 5 ms after switching on, ≤ 3.6 mA
Damping (63 % of the input variable), 0 … 999 s
adjustable
HART output values according to HART 7 (default setting) 10)
ƲƲ First HART value (PV) Linear percentage value
ƲƲ Second HART value (SV) Measuring cell temperature (ceramic measuring cell)
ƲƲ Third HART value (TV) Pressure
ƲƲ Fourth HART value (QV) Electronics temperature

Output variable - Additional current output


For details on the operating voltage see chapter "Voltage supply"
Output signal 4 … 20 mA (passive)
Range of the output signal 3.8 … 20.5 mA (default setting)
Signal resolution 0.3 µA
Fault signal, current output (adjustable) Last valid measured value, ≥ 21 mA, ≤ 3.6 mA
Max. output current 21.5 mA
45028-EN-220624

Starting current ≤ 10 mA for 5 ms after switching on, ≤ 3.6 mA


Load Load resistor, see chapter "Voltage supply"

9)
Last measured value not possible with SIL.
10)
The output values can be assigned individually.

72 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

Damping (63 % of the input variable), 0 … 999 s


adjustable

Dynamic behaviour output


Dynamic characteristics depending on medium and temperature

100 %
90 %

1 2

10 %

tT tA t
tS

Fig. 49: Behaviour in case of sudden change of the process variable. tT: dead time; tA: rise time; tS: jump response
time
1 Process variable
2 Output signal

VEGABAR 82 VEGABAR 82, IP68 (25 bar), connection


cable > 25 m (82.01 ft)
Dead time ≤ 25 ms ≤ 50 ms
Rise time (10 … 90 %) ≤ 55 ms ≤ 150 ms
Step response time (ti: 0 s, 10 … 90 %) ≤ 80 ms ≤ 200 ms

Damping (63 % of the input variable) 0 … 999 s, adjustable via menu item " Damping"

Additional output parameter - Measuring cell temperature


Range -60 … +150 °C (-76 … +302 °F)
Resolution < 0.2 K
Deviation
ƲƲ Range of 0 … +100 °C ±2 K
(+32 … +212 °F)
ƲƲ Range of -60 … 0 °C (-76 … +32 °F) typ. ±4 K
and +100 … +150 °C
(+212 … +302 °F)
Output of the temperature values
ƲƲ Indication Via the display and adjustment module
45028-EN-220624

ƲƲ Analogue Via the current output, the additional current output


ƲƲ Digital Via the digital output signal (depending on the electron-
ics version)

VEGABAR 82 • 4 … 20 mA/HART 73
11 Supplement

Reference conditions and influencing variables (according to DIN EN 60770-1)


Reference conditions according to DIN EN 61298-1
ƲƲ Temperature +15 … +25 °C (+59 … +77 °F)
ƲƲ Relative humidity 45 … 75 %
ƲƲ Air pressure 860 … 1060 mbar/86 … 106 kPa (12.5 … 15.4 psig)
Determination of characteristics Limit point adjustment according to IEC 61298-2
Characteristic curve Linear
Reference installation position upright, diaphragm points downward
Influence of the installation position < 0.2 mbar/20 Pa (0.003 psig)
Deviation in the current output due to < ±150 µA
strong, high-frequency electromagnetic
fields acc. to EN 61326-1

Deviation (according to IEC 60770)


Applies to the digital signal output (HART, Profibus PA, Foundation Fieldbus) as well as to the ana-
logue current output 4 … 20 mA and refers to the set span. Turn down (TD) is the ratio "nominal
measuring range/set span".
The specified values correspond to the value FKl in chapter " Calculation of the total deviation".

Accuracy class Non-linearity, hysteresis and repeata- Non-linearity, hysteresis and repeata-
bility with TD 1 : 1 up to 5 : 1 bility with 5 : 1
0.05 % < 0.05 % < 0.01 % x TD
0.1 % < 0.1 % < 0.02 % x TD
0.2 % < 0.2 % < 0.04 % x TD

Influence of the medium or ambient temperature


Thermal change zero signal and output span through product temperature
Applies to the digital signal output (HART, Profibus PA, Foundation Fieldbus) as well as to the ana-
logue current output 4 … 20 mA and refers to the set span. Turn down (TD) is the ratio "nominal
measuring range/set span".
The thermal change of the zero signal and output span corresponds to the temperature error FT in
chapter " Calculation of the total deviation (according to DIN 16086)".
45028-EN-220624

74 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

Basic temperature error FT

(
F TBasis

Fig. 50: Basic temperature error FTBasis at TD 1 : 1

The basic temperature error in % from the above graphic can increase due to the additional factors,
depending on the measuring cell version (factor FMZ) and the Turn Down (factor FTD). The ad-
ditional factors are listed in the following tables.

Additional factor through measuring cell version


Measuring cell standard, depending on the accuracy class

Measuring cell version 0.05 %, 0.1 % 0.2 % (with measuring 0.2 %


range 0.1 barabs) 0.05 %, 0.1 % with meas-
uring range 25 mbar
Factor FMZ 1 2 3

Measuring cell climate-compensated, depending on measuring range

Measuring cell version -1 … 0 bar, -1 … 1.5 bar, -0.5 … 0.5 bar, 1 bar, 0.4 bar, -0.2 … 0.2 bar


5 bar, 10 bar, 25 bar, 2,5 bar
60 bar, 100 bar
Factor FMZ 1 2 3

Additional factor through Turn Down


The additional factor FTD through Turn down is calculated according to the following formula:
FTD = 0.5 x TD + 0.5
In the table, example values for typical Turn downs are listed.

Turn Down TD 1 : 1 TD 2.5 : 1 TD 5 : 1 TD 10 : 1 TD 20 : 1


Factor FTD 1 1.75 3 5.5 10.5

Thermal change current output through ambient temperature


Applies also to the analogue 4 … 20 mA current output and refers to the set span.
Thermal change, current output < 0.05 %/10 K, max. < 0.15 %, each with -40 … +80 °C
45028-EN-220624

(-40 … +176 °F)
The thermal change of the current output corresponds to the value Fa in chapter " Calculation of the
total deviation (according to DIN 16086)".

VEGABAR 82 • 4 … 20 mA/HART 75
11 Supplement

0,3 %

0,15 %

-40°C -20°C 20°C 40°C 60°C 80°C


-0,15 %

-0,3 %

Fig. 51: Thermal change, current output

Long-term stability (according to DIN 16086)


Applies to the respective digital signal output (e.g. HART, Profibus PA) as well as to analogue cur-
rent output 4 … 20 mA under reference conditions. Specifications refer to the set span. Turn down
(TD) is the ratio nominal measuring range/set span.

Long-term stability zero signal and output span


Measuring cell ø 28 mm Measuring cell ø 17.5 mm
Measuring ranges from Measuring range
Time period
0 … +0.1 bar 0 … +0.025 bar
(0 … +10 kPa) (0 … +2.5 kPa)
One year < 0.05 % x TD < 0.1 % x TD < 0.1 % x TD
Five years < 0.1 % x TD < 0.2 % x TD < 0.2 % x TD
Ten years < 0.2 % x TD < 0.4 % x TD < 0.4 % x TD

Long-term stability zero signal and output span - version climate-compensated


Nominal measuring range in bar/ Nominal measuring Measuring cell Measuring cell
kPa range in psig ø 28 mm ø 17.5 mm
0 … 0.4 bar/0 … 40 kPa 0 … 6 psig
< (1 % x TD)/year < (1.5 % x TD)/year
-0.2 … 0.2 bar/-20 … 20 kPa -3 … 3 psig
0 … 1 bar/0 … 100 kPa 0 … 15 psig
0 … 2.5 bar/0 … 250 kPa 0 … 35 psig
-1 … 0 bar/-100 … 0 kPa -15 … 0 psig < (0.25 % x TD)/year < (0.375 % x TD)/year
-1 … 1.5 bar/-100 … 150 kPa -15 … 25 psig
-0.5 … 0.5 bar/-50 … 50 kPa -7 … 7 psig
0 … 5 bar/0 … 500 kPa 0 … 75 psig
0 … 10 bar/0 … 1000 kPa 0 … 150 psig
0 … 25 bar/0 … 2500 kPa 0 … 350 psig
0 … 60 bar/0 … 6000 kPa 0 … 900 psig
< (0.1 % x TD)/year < (0.15 % x TD)/year
45028-EN-220624

0 … 100 bar/0 … 6000 kPa 0 … 1450 psig
-1 … 10 bar/-100 … 1000 kPa -15 … 150 psig
-1 … 25 bar/-100 … 2500 kPa -15 … 350 psig
-1 … 60 bar/-100 … 6000 kPa -15 … 900 psig

76 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

Ambient conditions
Version Ambient temperature Storage and transport temperature
Standard version -40 … +80 °C (-40 … +176 °F) -60 … +80 °C (-76 … +176 °F)
Version IP66/IP68 (1 bar) -20 … +80 °C (-4 … +176 °F) -20 … +80 °C (-4 … +176 °F)
Version IP68 (25 bar), with connection -20 … +80 °C (-4 … +176 °F) -20 … +80 °C (-4 … +176 °F)
cable PUR
Version IP68 (25 bar), connection ca- -20 … +60 °C (-4 … +140 °F) -20 … +60 °C (-4 … +140 °F)
ble PE

Process conditions

Process temperature - Process fittings stainless steel


Measuring cell seal Sensor version
Standard Extended temperature range 11)
FKM VP2/A -20 … +130 °C (-4 … +266 °F) -20 … +150 °C (-4 … +302 °F)
A+P 70.16 -40 … +130 °C (-40 … +266 °F) -
V70SW - -10 … +150 °C (14 … +302 °F)
EPDM A+P 70.10-02 -40 … +130 °C (-40 … +266 °F) -40 … +150 °C (-40 … +302 °F)
ET 7056 -40 … +130 °C (-40 … +266 °F) -
E70Q - -40 … +150 °C (-40 … +302 °F)
Fluoraz SD890 -5 … +130 °C (-22 … +266 °F) -
FFKM Kalrez 6375 -20 … +130 °C (-4 … +266 °F) -20 … +150 °C (-4 … +302 °F)
Perlast G74S -15 … +130 °C (-4 … +266 °F) -15 … +150 °C (5 … +302 °F)
Perlast G75B -15 … +130 °C (-4 … +266 °F) -15 … +150 °C (5 … +302 °F)
Perlast G92E -15 … +130 °C (-4 … +266 °F) -15 … +150 °C (5 … +302 °F)
Chemraz 535 -30 … +130 °C (-22 … +266 °F) -

Process temperature - Process fittings plastic


Measuring cell seal Process temperature
Process fitting PEEK 12) Process fitting PVDF 13)
FKM VP2/A -20 … +100 °C (-4 … +212 °F)
A+P 70.16
-40 … +100 °C (-40 … +212 °F)
EPDM A+P 70.10-02
-20 … +80 °C (-4 … +176 °F) 14)
FFKM Kalrez 6375 -20 … +100 °C (-4 … +212 °F)
Perlast G74S
-15 … +100 °C (5 … +212 °F)
Perlast G75B
45028-EN-220624

11)
Measuring cell ø 28 mm
12)
Max. permissible process pressure: 30 bar
13)
Max. permissible process pressure: 10 bar
14)
Process pressures > 5 bar: 20 … +60 °C (-4 … +140 °F)

VEGABAR 82 • 4 … 20 mA/HART 77
11 Supplement

Temperature derating

80 °C
(176 °F)

55 °C
(131 °F)

0 °C
(32 °F)
-40 °C
100 °C 130 °C 1
(212 °F) (266 °F)
(-104 °F)
-40 °C
(-104 °F)

Fig. 52: Temperature derating VEGABAR 82, version up to +130 °C (+266 °F)


1 Process temperature
2 Ambient temperature

80 °C
(176 °F)

50 °C
(122 °F)

0 °C
(32 °F)
-40 °C
100 °C 150 °C 1
(212 °F) (302 °F)
(-104 °F)
-40 °C
(-104 °F)

Fig. 53: Temperature derating VEGABAR 82, version up to +150 °C (+302 °F)


1 Process temperature
2 Ambient temperature

SIP process temperature (SIP = Sterilization in place)


Applies to instruments configurations suitable for vapour, i.e. material measuring cell seal EPDM or
FFKM (Perlast G74S).
Vapour stratification up to 2 h +150 °C (+302 °F)
Process pressure
Permissible process pressure see specification " process pressure" on the type label
Mechanical stress15)
Vibration resistance 4 g at 5 … 200 Hz according to EN 60068-2-6 (vibration
with resonance)
45028-EN-220624

Shock resistance 50 g, 2.3 ms according to EN 60068-2-27 (mechanical


shock) 16)

15)
Depending on the instrument version.
16)
2 g with housing version stainless steel double chamber

78 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

Electromechanical data - version IP66/IP67 and IP66/IP68 (0.2 bar) 17)

Options of the cable entry


ƲƲ Cable entry M20 x 1.5; ½ NPT
ƲƲ Cable gland M20 x 1.5, ½ NPT (cable ø see below table)
ƲƲ Blind plug M20 x 1.5; ½ NPT
ƲƲ Closing cap ½ NPT

Material cable gland/Seal insert Cable diameter


5 … 9 mm 6 … 12 mm 7 … 12 mm 10 … 14 mm
PA/NBR ● ● – ●
Brass, nickel-plated/NBR ● ● – –
Stainless steel/NBR – – ● –

Wire cross-section (spring-loaded terminals)


ƲƲ Massive wire, stranded wire 0.2 … 2.5 mm² (AWG 24 … 14)
ƲƲ Stranded wire with end sleeve 0.2 … 1.5 mm² (AWG 24 … 16)

Electromechanical data - version IP66/IP68 (1 bar)


Connection cable, mechanical data
ƲƲ Configuration Wires, strain relief, breather capillaries, screen braiding,
metal foil, mantle
ƲƲ Standard length 5 m (16.4 ft)
ƲƲ Min. bending radius (at 25 °C/77 °F) 25 mm (0.984 in)
ƲƲ Diameter approx. 8 mm (0.315 in)
ƲƲ Colour - version PE Black
ƲƲ Colour - version PUR Blue
Connection cable, electrical data
ƲƲ Wire cross-section 0.5 mm² (AWG 20)
ƲƲ Wire resistance R´ 0.037 Ω/m (0.012 Ω/ft)

Electromechanical data - version IP68 (25 bar)


Connection cable transmitter - external housing, mechanical data
ƲƲ Configuration Wires, strain relief, breather capillaries, screen braiding,
metal foil, mantle 18)
ƲƲ Standard length 5 m (16.40 ft)
ƲƲ Max. length 180 m (590.5 ft)
ƲƲ Min. bending radius at 25 °C/77 °F 25 mm (0.985 in)
ƲƲ Diameter approx. 8 mm (0.315 in)
ƲƲ Material PE, PUR
45028-EN-220624

ƲƲ Colour Black, blue

17)
IP66/IP68 (0.2 bar), only with absolute pressure.
18)
Breather capillaries not with Ex-d version.

VEGABAR 82 • 4 … 20 mA/HART 79
11 Supplement

Connection cable transmitter - external housing, electrical data


ƲƲ Wire cross-section 0.5 mm² (AWG 20)
ƲƲ Wire resistance 0.037 Ω/m (0.012 Ω/ft)

Interface to the external display and adjustment unit


Data transmission Digital (I²C-Bus)
Connection cable Four-wire

Sensor version Configuration, connection cable


Cable length Standard cable Shielded
4 … 20 mA/HART
50 m ● –
Modbus
Profibus PA, Foundation Fieldbus 25 m – ●

Interface to the Secondary sensor


Data transmission Digital (I²C-Bus)
Configuration, connection cable 4-wire, shielded
Max. cable length 25 m

Integrated clock
Date format Day.Month.Year
Time format 12 h/24 h
Time zone, factory setting CET
Max. rate deviation 10.5 min/year

Additional output parameter - Electronics temperature


Range -40 … +85 °C (-40 … +185 °F)
Resolution < 0.1 K
Deviation ± 3 K
Availability of the temperature values
ƲƲ Indication Via the display and adjustment module
ƲƲ Output Via the respective output signal

Voltage supply
Operating voltage UB 9.6 … 35 V DC
Operating voltage UB with lighting 16 … 35 V DC
switched on
Reverse voltage protection Integrated
Permissible residual ripple
45028-EN-220624

ƲƲ for UN 12 V DC (9.6 V < UB < 14 V) ≤ 0.7 Veff (16 … 400 Hz)


ƲƲ for UN 24 V DC (18 V < UB < 35 V) ≤ 1.0 Veff (16 … 400 Hz)
Load resistor
ƲƲ Calculation (UB - Umin)/0.022 A

80 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

ƲƲ Example - with UB= 24 V DC (24 V - 9.6 V)/0.022 A = 655 Ω

Voltage supply - sensor with integrated PLICSMOBILE 81


Operating voltage 19) 9.6 … 32 V DC
Power consumption 20)
ƲƲ Power saving mode (9 V/12 V) 0.18 mW/0.3 mW
ƲƲ Power saving mode (24 V/32 V) 1.8 mW/3.7 mW
ƲƲ Permanent operation 1.1 W
ƲƲ Peak power (measured value trans- 11 W
mission)
Power requirement 21)
ƲƲ Measurement cycle incl. transmission 15 mWh
Sensor power supply
ƲƲ Off-load voltage 31 V
ƲƲ Max. current 80 mA

Potential connections and electrical separating measures in the instrument


Electronics Not non-floating
Reference voltage 22) 500 V AC
Conductive connection Between ground terminal and metallic process fitting

Electrical protective measures 23)


Housing material Version Protection acc. to Protection acc. to
IEC 60529 NEMA
Plastic Single chamber
IP66/IP67 Type 4X
Double chamber
Aluminium Single chamber IP66/IP67 Type 4X
IP66/IP68 (0.2 bar) Type 6P
IP68 (1 bar) -
Double chamber IP66/IP67 Type 4X
IP66/IP68 (0.2 bar) Type 6P
Stainless steel (electro-polished) Single chamber IP66/IP67 Type 4X
IP69K

When the instrument is powered by an external voltage supply, make sure the voltage supply unit has a suf-
45028-EN-220624

19)

ficient current carrying capacity. With a voltage supply < 9.6 V, current peaks of up to 2 A must be expected.
20)
The listed power specifications include the voltage supply of a HART sensor with 20 mA.
21)
The listed energy requirement includes the voltage supply of a HART sensor with 4 mA (multidrop mode) and
12 V operating voltage.
22)
Galvanic separation between electronics and metal housing parts
23)
Protection rating IP66/IP68 (0.2 bar) only in conjunction with absolute pressure.

VEGABAR 82 • 4 … 20 mA/HART 81
11 Supplement

Housing material Version Protection acc. to Protection acc. to


IEC 60529 NEMA
Stainless steel (precision cast- Single chamber IP66/IP67 Type 4X
ing) IP66/IP68 (0.2 bar) Type 6P
IP68 (1 bar) -
Double chamber IP66/IP67 Type 4X
IP66/IP68 (0.2 bar) Type 6P
Stainless steel Transmitter, version with exter- IP68 (25 bar) -
nal housing

Connection of the feeding power supply Networks of overvoltage category III


unit
Altitude above sea level
ƲƲ by default up to 2000 m (6562 ft)
ƲƲ with connected overvoltage protection up to 5000 m (16404 ft)
Pollution degree 24) 2
Protection rating (IEC/EN 61010-1) II

11.2 Calculation of the total deviation


The total deviation of a pressure transmitter indicates the maximum measurement error to be ex-
pected in practice. It is also called maximum practical deviation or operational error.
According to DIN 16086, the total deviation Ftotal is the sum of the basic deviation Fperf and the long-
term stability Fstab:
Ftotal= Fperf + Fstab
The basic deviation Fperf in turn consists of the thermal change of the zero signal and the output
span FT (temperature error) as well as the deviation FKl:
Fperf = √((FT)2 + (FKl)2)
The thermal change of zero signal and output span FT is specified in chapter " Technical data". The
basic temperature error FT is shown in a graphic. Depending on the measuring cell version and Turn
down, this value must be multiplied with the additional factors FMZ and FTD:
FT x FMZ x FTD
Also these values are specified in chapter " Technical data".
This applies initially to the digital signal output through HART, Profibus PA, Foundation Fieldbus or
Modbus.
With 4 … 20 mA output, the thermal change of the current output Fa must be added:
Fperf = √((FT)2 + (FKl)2 + (Fa)2)
To provide a better overview, the formula symbols are listed together below:
• Ftotal: Total deviation
• Fperf: Basic deviation
• Fstab: Long-term stability
45028-EN-220624

• FT: Thermal change of zero signal and output span (temperature error)
• FKl: Deviation
• Fa: Thermal change of the current output
• FMZ: Additional factor measuring cell version
24)
When used with fulfilled housing protection.

82 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

• FTD: Additional factor Turn down

11.3 Calculation of the total deviation - Practical example


Data
Pressure measurement in the pipeline 4 bar (400 KPa)
Product temperature up to 50 °C
VEGABAR 82 with measuring range 10 bar, deviation < 0.2 %, process fitting G1½ (measuring cell
ø 28 mm)
1. Calculation of the Turn down
TD = 10 bar/4 bar, TD = 2.5 : 1
2. Determination temperature error FT
(

50
F TBasis

Fig. 54: Determination of the basic temperature error for the above example: FTBasis = 0.15 %

Measuring cell standard, depending on the accuracy class


Measuring cell version
0.05 %, 0.1 % 0.2 % (0.1 barabs) 0.2 %
Factor FMZ 1 2 3

Tab. 28: Determination of the additional factor measuring cell for above example: FMZ = 3

Turn Down TD 1 : 1 TD 2.5 : 1 TD 5 : 1 TD 10 : 1 TD 20 : 1


Factor FTD 1 1.75 3 5.5 10.5

Tab. 29: Determination of the additional factor "turn down" for the above example: FTD = 1.75
FT = FTBasis  x FMZ x FTD
FT = 0.15 % x 3 x 1.75
FT = 0.79 %
45028-EN-220624

3. Determination of deviation and long-term stability


The required values for deviation FKl and long-term stability Fstab are available in the technical data:

VEGABAR 82 • 4 … 20 mA/HART 83
11 Supplement

Accuracy class Non-linearity, hysteresis and non-repeatability


TD ≤  5 : 1 TD > 5 : 1
0.05 % < 0.05 % < 0.01 % x TD
0.1 % < 0.1 % < 0.02 % x TD
0.2 % < 0.2 % < 0.04 % x TD

Tab. 30: Determination of the deviation from table: FKl = 0.2 %

Time pe- Measuring cell ø 28 mm Measuring cell ø 17.5 mm


riod
All measuring ranges Measuring range All process fittings Process fitting G½
0 … +0.025 bar (ISO 228-1)

(0 … +2.5 kPa)
One year < 0.05 % x TD < 0.1 % x TD < 0.1 % x TD < 0.25 % x TD
Five years < 0.1 % x TD < 0.2 % x TD < 0.2 % x TD < 0.5 % x TD
Ten years < 0.2 % x TD < 0.4 % x TD < 0.4 % x TD < 1 % x TD

Tab. 31: Determination of the long-term stability from the table, consideration for one year: Fstab = 0.05 % x TD

4. Calculation of the total deviation - HART signal


- 1. step: Basic deviation Fperf
Fperf = √((FT)2 + (FKl)2)
FT = 0.79 %
FKl= 0.2 %
Fperf = √(0.79 %)2 + (0.2 %)2)
Fperf = 0.81 %
- 2. step: Total deviation Ftotal
Ftotal = Fperf + Fstab
Fperf = 0.81 % (result of step 1)
Fstab = (0.05 % x TD)
Fstab = (0.05 % x 2.5)
Fstab = 0.125 %
Ftotal = 0.81 % + 0.13 % = 0.94 %
5. Calculation of the total deviation - 4 … 20 mA signal
- 1. step: Basic deviation Fperf
Fperf = √((FT)2 + (FKl)2 + (Fa)2)
FT = 0.79 %
FKl= 0.2 %
Fa = 0.15 %
Fperf = √(0.79 %)2)2 + (0.2 %)2) + (0.15 %)2)
45028-EN-220624

Fperf = 0.83 %
- 2. step: Total deviation Ftotal
Ftotal = Fperf + Fstab
Fstab = (0.05 % x TD)

84 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

Fstab = (0.05 % x 2.5)
Fstab = 0.13 %
Ftotal = 0.83 % + 0.13 % = 0.96 %
The total deviation of the measurement is hence 0.96 %.
Deviation in bar: 0.96 % of 4 bar = 0.038 bar
The example shows that the measurement error in practice can be considerably higher than the
basic deviation. Reasons are temperature influence and Turn down.

11.4 Dimensions
The following dimensional drawings represent only an extract of the possible versions. Detailed
dimensional drawings can be downloaded at www.vega.com under " Downloads" and " Drawings".

Plastic housing
~ 69 mm ~ 84 mm
(2.72") (3.31")
ø 79 mm ø 79 mm
(3.11") (3.11")

M16x1,5
112 mm

112 mm
(4.41")

(4.41")
M20x1,5/
½ NPT
M20x1,5/
1 ½ NPT 2
Fig. 55: Housing versions in protection IP66/IP67 (with integrated display and adjustment module the housing is
9 mm/0.35 in higher)
1 Plastic single chamber
2 Plastic double chamber

Aluminium housing
~ 116 mm ~ 87 mm
(4.57") (3.43")
ø 86 mm ø 86 mm
(3.39") (3.39")

M16x1,5
120 mm
(4.72")

120 mm
(4.72")

M20x1,5/ M20x1,5
½ NPT
M20x1,5/
1 ½ NPT 2
45028-EN-220624

Fig. 56: Housing versions with protection rating IP66/IP68 (0.2 bar), (with integrated display and adjustment mod-
ule the housing is 18 mm/0.71 in higher)
1 Aluminium - single chamber
2 Aluminium - double chamber

VEGABAR 82 • 4 … 20 mA/HART 85
11 Supplement

Aluminium housing with protection rating IP66/IP68 (1 bar)


~ 150 mm ~ 105 mm
(5.91") (4.13")
ø 86 mm
ø 86 mm
(3.39")
(3.39")
M16x1,5

120 mm
(4.72")

120 mm
(4.72")
M20x1,5 M20x1,5

M20x1,5/
1 ½ NPT 2
Fig. 57: Housing version with protection rating IP66/IP68 (1 bar), (with integrated display and adjustment module
the housing is 18 mm/0.71 in higher)
1 Aluminium - single chamber
2 Aluminium - double chamber

Stainless steel housing


~ 59 mm ~ 69 mm ~ 87 mm
(2.32") (2.72") (3.43")
ø 80 mm ø 86 mm
ø 79 mm
(3.15") (3.39")
(3.11")

M16x1,5
117 mm

120 mm
112 mm

(4.61")

(4.72")
(4.41")

M20x1,5/
½ NPT
M20x1,5/ M20x1,5/
½ NPT 1 2 ½ NPT 3
Fig. 58: Housing versions in protection rating IP66/IP68 (0.2 bar), (with integrated display and adjustment module
the housing is 9 mm/0.35 in or 18 mm/0.71 in higher)
1 Stainless steel single chamber (electropolished)
2 Stainless steel single chamber (precision casting)
2 Stainless steel double chamber housing (precision casting)
45028-EN-220624

86 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

Stainless steel housing with protection rating IP66/IP68 (1 bar)


~ 103 mm ~ 105 mm (4.13")
~ 150 mm (5.91")
(4.06") ø 84 mm
ø 77 mm
ø 84 mm (3.31") (3.31")
(3.03")

M16x1,5

116 mm (4.57")

117 mm (4.61")

120 mm (4.72")
M20x1,5 M20x1,5 M20x1,5

M20x1,5/
1 2 ½ NPT 3
Fig. 59: Housing versions in protection rating IP66/IP68 (1 bar), (with integrated display and adjustment module
the housing is 9 mm/0.35 in or 18 mm/0.71 in higher)
1 Stainless steel single chamber (electropolished)
2 Stainless steel single chamber (precision casting)
3 Stainless steel double chamber housing (precision casting)

Stainless steel housing with protection rating IP69K


~ 59 mm
(2.3")
ø 80 mm
(3.15")
104 mm
(4.1")

M20x1,5/
½ NPT

Fig. 60: Housing version with protection rating IP69K (with integrated display and adjustment module the housing
is 9 mm/0.35 in higher)
1 Stainless steel single chamber (electropolished)
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 87
11 Supplement

External housing on IP68 version

82 mm
(3.23")

80 mm
(3.15")
41,6 mm
(1.64")

1
3

59 mm
(2.32")
108 mm
(4.25")

41,6 mm 110 mm x 90 mm
(1.64") (4.33" x 3.54")
~ 66 mm
(2.60")
2

90 mm
(3.54")
70 mm
(2.76")
3mm 8 mm
(0.12") (0.32") 4

mm
3,5 ")
R 0.14
(
51 mm
(2.01")
110 mm

93 mm
(4.33")

(3.66")

110 mm x 90 mm
(4.33" x 3.54")

Fig. 61: VEGABAR 82, IP68 version with external housing


1 Lateral cable outlet
2 Axial cable outlet
3 Plastic single chamber
4 Stainless steel single chamber
5 Seal 2 mm (0.079 in), (only with 3A approval)
45028-EN-220624

88 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

VEGABAR 82, threaded fitting not front-flush 25)

ø 40 mm
(1.57") ø 54 mm
73 mm
(2.87")

70 mm
(2.76")
SW 27 mm (2.13")

17 mm
(0.67")

85 mm
(3.35")

(1.06")

17 mm
(0.67")

23 mm
(0.91")


20 mm
(0.79")

(0.12")

3 mm
(0.12")
3 mm

ø 3 mm

20 mm

(0.08")
(0.79")

2 mm
(0.12") ø 6 mm ø 17,5 mm
(0.24") (0.69") ø 17,5 mm
(0.69")
DU/9Q DI DQ

75 mm
(2.95")
73 mm
(2.87")

75 mm
(2.95")
15 mm
(0.59")

½ NPT
G½ M20x1,5
23 mm

25 mm
(0.91")

(0.98")
25 mm
(0.98")
(0.12")

(0.20")
3 mm

ø 3 mm
5 mm

¼ NPT ø 3 mm
(0.12") ø 6 mm (0.12") ø 6 mm
(0.24") (0.24")
DD LF C2

Fig. 62: VEGABAR 82, threaded fitting not front-flush


DU/9Q G½, EN 837; manometer connection 316L/PEEK
DI G½, inside G¼ A, ISO 228-1
DQ G½, inside G¼ A, ISO 228-1 (PVDF)
DD G½, EN 837; volume-reduced
LF ½ NPT, inside ¼ NPT, ASME B1.20.1
C2 M20 x 1.5 EN 837, manometer connection
45028-EN-220624

Notes:
For the version with " Second Line of Defense", the measure of length increases by 17 mm (0.67 in).

25)

VEGABAR 82 • 4 … 20 mA/HART 89
11 Supplement

VEGABAR 82, threaded fitting front-flush

SW 36 mm SW 41 mm
SW 27 mm (1.42")
(1.06") (1.61")

44 mm
(1.73")
45 mm
(1.77")

44 mm
(1.73")
G½ G1

ø 30 mm

21 mm
(0.83")
ø 18 mm ø 24 mm
22 mm
(0.87")
21 mm
(0.83")

(0.71") (0.95") (1.18")


ø 27 mm ø 40 mm
(1.06") (1.58")
C3 N9 C5

SW 46 mm SW 55 mm
(1.81") (2.17")
SW 46 mm
(1.81")
50 mm
(1.97")
50 mm
(1.97")

G1½
55 mm
(2.17")

1½ NPT
G1 ½
22 mm
(0.87")

22 mm
(0.87")
25 mm
(0.87")

ø 55 mm
(2.17") ø 60 mm ø 55 mm
(2.36") (2.17")

DA DV C9

Fig. 63: VEGABAR 82, threaded fitting front-flush


C3 G½, ISO 228-1; front-flush
N9 G¾, DIN 3852-E
C5 G1, ISO 228-1
DA G1½, DIN 3852-A
DV G1½, DIN 3852-A-B, PVDF
C9 1½ NPT, ASME B1.20.1

Notes:
For the version with temperature range up to 150 °C/302 °F, the measure of length increases by
28 mm (1.1 in).
For the version with " Second Line of Defense", the measure of length increases by 17 mm (0.67 in).
45028-EN-220624

90 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

VEGABAR 82, hygienic fitting

SW 46 mm
(1.81")

55 mm
(2.17")
51 mm
(2.01")

ø 48 mm 60 mm
(1.89") (2.36")

ø 64 mm ø 66 mm
(2.52 ") (2.60")
ø 78 mm
AR (3.07") ø 105 mm
(4.13")
ES AA
51 mm

51 mm
(2.01")

(2.01")

50 mm
(1.97")

ø 84 mm ø 78 mm (3.07") ø 92 mm
(3.31") ø 92 mm (3.62") (3.62")

FR EZ/NB E3

Fig. 64: VEGABAR 82, hygienic fitting


AR Clamp 2" PN 16 (ø 64 mm) DIN 32676, ISO 2852
ES Hygienic connection with compression nut F40 PN 25
AA DRD PN 40
FR Varivent N50-40 PN 25
EZ Collar socket DN 40 PN 40, DIN 11851
NB Collar socket DN 50 PN 25, DIN 11851
E3 Collar socket DN 50 acc. to DIN, Form A, DIN 11864-1; for tube 53 x 1.5

Notes:
45028-EN-220624

For the version with temperature range up to 150 °C/302 °F, the measure of length increases by
28 mm (1.1 in).
For the version with " Second Line of Defense", the measure of length increases by 17 mm (0.67 in).

VEGABAR 82 • 4 … 20 mA/HART 91
11 Supplement

VEGABAR 82, flange connection

(0.04...11.81")
1...300 mm
d2
H

b
f
d4
k
D ø 32...90 mm
(1.26...3.54")
A8 / B2 / R5 NC / F2

mm DN PN D b k d2 d4 f H
1 A8 40 40 150 18 110 4xø18 88 3 50
B2 50 40 165 20 125 4xø18 102 3 50
R5 80 40 200 24 160 8xø18 138 3 51
2 CA 2” 150 lbs 152,4 19,1 120,7 4xø19,1 91,9 3,2 51
CB 3” 150 lbs 190,5 23,9 152,4 8xø19,1 127 3,2 51

inch DN PN D b k d2 d4 f H
1 A8 40 40 5.91" 0.71" 4.33" 4xø 0.71" 3.46" 0.12" 1.97"
B2 50 40 6.50" 0.79" 4.92" 4xø 0.71" 4.02" 0.12" 1.97"
B5 80 40 7.87" 0.95" 6.30" 8xø 0.71" 5.43" 0.12" 2.01"
2 CA 2” 150 lbs 6" 0.75" 4.75" 4xø 0.75" 3.62" 0.13" 2.01"
CB 3” 150 lbs 7.5" 0.94" 6" 8xø 0.75" 5” 0.13" 2.01"

Fig. 65: VEGABAR 82, flange connection


1 Flange connection according to DIN 2501
2 Flange connection according to ASME B16.5
F7 Flange DN 50 PN 40 Form C, DIN 2501; with extension
F2 Flange DN 80 PN 40 Form C, DIN 2501; with extension

Notes:
For the version with temperature range up to 150 °C/302 °F, the measure of length increases by
28 mm (1.1 in).
For the version with " Second Line of Defense", the measure of length increases by 17 mm (0.67 in).
45028-EN-220624

92 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

VEGABAR 82, extension fitting

SW 32 mm SW 46 mm SW 36 mm
(1.26") (1.81") (1.42")
52 mm
48 mm

(2.05")
(1.89")

M30x1,5
G1
M 44 x 1,25

106 mm
(4.17")
30 mm
(1.18")
ø 25 mm
21 mm
(0.83")
29 mm
(1.14")

(0.98")
ø 27,4 mm
(1.08")

AL/AP AF/AG ø 24,7 mm


(0.97")

ø 29,9 mm
(1.18")
F9

(0.24")
6 mm

ø 36 mm
45,5 mm

(1.42")
51 mm
(1.79")

(2.01")

M8

ø 26,3 mm ø 48 mm
(1.04") (1.89")
ø 85 mm
(3.35")

EW BS

Fig. 66: VEGABAR 82, extension fitting


AL/AP M30 x 1.5 DIN 13; completely front-flush/for headbox
AF/AG M44 x 1.25 DIN 13; pressure screw: Aluminium/316L
F9 G1, ISO 228-1 suitable for PASVE
EW PMC 1" front-flush PN 6
BS DN 48 with tension flange PN 25
45028-EN-220624

Notes:
For the version with temperature range up to 150 °C/302 °F, the measure of length increases by
28 mm (1.1 in).
For the version with " Second Line of Defense", the measure of length increases by 17 mm (0.67 in).

VEGABAR 82 • 4 … 20 mA/HART 93
11 Supplement

VEGABAR 82, extension fitting for headbox

84 mm
(3.31")
43 mm
(1.69")

23 mm
(0.91")

ø 48 mm
(1.89")

CL 115 mm
(4.53")
84 mm
(3.31")

115 mm
(4.53")
43 mm
(1.69")

23 mm
(0.91")

ø 48 mm
(1.89")
50 mm
50 mm
(1.97")
(1.97")
BR

Fig. 67: VEGABAR 82, extension fitting for headbox


CL Completely front-flush for headbox
BR Completely front-flush for headbox (flange 2-times flattened)
45028-EN-220624

94 VEGABAR 82 • 4 … 20 mA/HART
11 Supplement

VEGABAR 82, connection acc. to IEC 61518


70 mm
(2.76")
60 mm
(2.36")

105 mm
(4.13")
63,5 mm
(2.50")
7/16 - 20 UNF
1/4 - 18 NPT

75 mm 40 mm
(2.95") (1.57")
39 mm
(1.54")

45 mm
(1.77")

41 mm
(1.63")
65 mm
(2.56")

SJ SK

Fig. 68: VEGABAR 82, connection acc. to IEC 61518


SJ Oval flange adapter
SK Top flange

Notes:
For the version with temperature range up to 150 °C/302 °F, the measure of length increases by
28 mm (1.1 in).
For the version with " Second Line of Defense", the measure of length increases by 17 mm (0.67 in).
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 95
11 Supplement

11.5 Industrial property rights


VEGA product lines are global protected by industrial property rights. Further information see
www.vega.com.
VEGA Produktfamilien sind weltweit geschützt durch gewerbliche Schutzrechte.
Nähere Informationen unter www.vega.com.
Les lignes de produits VEGA sont globalement protégées par des droits de propriété intellec-
tuelle. Pour plus d'informations, on pourra se référer au site www.vega.com.
VEGA lineas de productos están protegidas por los derechos en el campo de la propiedad indus-
trial. Para mayor información revise la pagina web www.vega.com.
Линии продукции фирмы ВЕГА защищаются по всему миру правами на интеллектуальную
собственность. Дальнейшую информацию смотрите на сайте www.vega.com.
VEGA系列产品在全球享有知识产权保护。
进一步信息请参见网站< www.vega.com。

11.6 Trademark
All the brands as well as trade and company names used are property of their lawful proprietor/
originator.

45028-EN-220624

96 VEGABAR 82 • 4 … 20 mA/HART
Notes
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 97
Notes

45028-EN-220624

98 VEGABAR 82 • 4 … 20 mA/HART
Notes
45028-EN-220624

VEGABAR 82 • 4 … 20 mA/HART 99
Printing date:

45028-EN-220624

All statements concerning scope of delivery, application, practical use and operat-
ing conditions of the sensors and processing systems correspond to the information
available at the time of printing.
Subject to change without prior notice

© VEGA Grieshaber KG, Schiltach/Germany 2022

VEGA Grieshaber KG
Am Hohenstein 113 Phone +49 7836 50-0
77761 Schiltach E-mail: info.de@vega.com
Germany www.vega.com

You might also like