Professional Documents
Culture Documents
Project 13CA04099
REPORT
on
UL LLC authorizes the above named company to reproduce this Report either in its
entirety or the portion of this Report consisting of the Cover Page up to (but not
including) the Construction Details descriptive pages.
DESCRIPTION
PRODUCT COVERED:
Cat. Nos.:
Standard Polymeric - Nylon
HTS-3X80 HTS-4X150 HTS-5X180 HTS-8X250
HTS-3X100 HTS-4X180 HTS-5X200 HTS-8X300
HTS-3X120 HTS-4X200 HTS-5X250 HTS-8X350
HTS-3X150 HTS-4X300 HTS-5X300 HTS-8X380
HTS-3X160 HTS-4X370 HTS-5X350 HTS-8X400
HTS-3X200 HTS-5X380
HTS-5X400
GENERAL:
MARKING:
INSTRUCTIONS:
CONDITIONS OF ACCEPTABILITY –
Use – For use only in (or with) complete equipment where the acceptability
of the combination is determined by UL LLC.
1. The end-use application shall be examined for correct alignment. The arrangement
shall be such as to prevent wires and/or cables from being cut during securement
and latching.
2. The end-use application shall also be examined to insure that the cable ties
maintain the wires and/or cables in place and do not cause undue compression
or tension.
3. The diameter of the wire bundles are to coincide with the limits established
for the individual cable tie.
4. These cable ties have been investigated for their constructional and mechanical
features only. No tests have been conducted to determine suitability for use
as electrical insulation.
6. Reference should be made to the end-product standards and most current guides
to the use of plastics (such as Subject 746) with regard to other requirements,
which should be considered in judging the suitability of these materials in
end-products.
7. The suitability for use when exposed to oil, chemicals, refrigerant, soap,
x-rays, ultraviolet light, etc. have not been determined by this investigation
unless otherwise indicated.
9. The Type 11 devices are molded from compounds meeting a minimum V-2 flammability
rating. Flame tests were not conducted on the cable ties.
RATINGS:
CONSTRUCTION DETAILS:
SAMPLES:
The samples were molded from R/C QMFZ2 Plastic, PA66 Grade
“21SPC”, manufactured by Ascend Performance (E70062), black color.
GENERAL:
Representative Testing:
CONCLUSION
This Report is intended solely for the use of UL and the Applicant for
establishment of UL certification coverage of the product under UL’s Follow-
Up Service. Any use of the Report other than to indicate that the sample(s)
of the product covered by the Report has been found to comply with UL’s
applicable requirements is not authorized and renders the Report null and
void. UL shall not incur any obligation or liability for any loss, expense,
or punitive damages, arising out of or in connection with the use or reliance
upon the contents of this Report to anyone other than the Applicant as
provided in the agreement between UL and Applicant. Any use or reference to
UL’s name or certification mark(s) by anyone other than the Applicant in
accordance with the agreement is prohibited without the express written
approval of UL. Any information and documentation involving UL Mark services
are provided on behalf of UL LLC (UL) or any authorized licensee of UL.
Report by:
TERESA TANG
Associate Project Engineer