Contactless Potentiometers
The Rotary Smart Angle Sensor is used to detect the
angle or control speed of system which correspondence to the
rotary motion of the shaft of the sensor. In built Signal
conditioner facility makes it a unique product in the market.
The Output signal correspondence to 0 to 360deg. This
full range is programmable based on requirement and
based on the need of the
Since the Product is based on Contactless Magnetic
Technology it has very long life.
For modern microcontrollers RMS-22 is capable to give
‘output in 0 to 3.3Vde, 0-10Vdc, 4-20mA, Quadrature, SPI,
12C, PPR and PWM output version is available.
Wide range of Mechanical and electrical variant makes it
a versatile product in the industry. BUSH MOUNT
Mechanical
parameters Sleeve Bushing
Torque High torque
Maximul Radial 470 gms
Load
Maximum Axial Nil
Load
Maximum Shaft 100 RPM
Toles lrg Wie whi Sve Speed
fa (2 pe
van (P35 cr Bearing Life cycles | 200 X 10%6 @rated radial
fare Load
DT04-4P | Weight of sensor —_| 25 gms
Shaft Dia 6mmContactless Potentiometers
Redundant Analog Output
Shielded Cable
vsupply | Red (Pin 2)
Ground | Green (Pin 3)
‘Output 1 | Yellow (Pin 1)
Output 2] Black (Pin 4)
Paameters Results
Supply Voltage (Vsupply) 8Vde or 6 to 35Vde or 24Vde
Supply Current 50mA
Frequency KHz
Resolution 12bit
Output (Voutput) 0.375Vdc to 2Vde output 2 | 0.75Vdc to 4Vdc Output 1
( Outputt and Output 2 signal level can be changed on request)
Electrical angle of rotation 270 deg
Mechanical angle of rotation | 270 deg
Load Resistance Minimum 10K Ohms
Linearity 1% Independent Linearity ( Available 0.5% on request)