‘Measurement & Verification Pte Lid Page 1 of 5
‘An Accredited Energy Services Company
CERTIFICATE OF CALIBRATION
sumer: 10K Thenistor CERTIFICATENO: MV1961-003
MANUFACTURER: Measurement Spies DATE OF CALIBRATION: 16-Aug-22
SERIAL NUMBER: ‘Te2230082 DATE OF ISSUE: 29-Aug22
cusrowen: Li Energy Pie Led AMBIENT TEMPERATURE: (21-£3)°C
JOB NUMBER: M1961 RELATIVE HUMIDITY: (35 +10) 9% Relative Humidity
CALIBRATION POINTS (°C: —001_—_15,003
‘Method of Calibration
‘The thermistor has been calibrated in accordance with MAV's technical procedures TP 5.4.2-01(VO), TP $.4.2.02(R1), TP $.42-05R1), TP $4.2
(04(R1), TP 5.4.2-05(R1) under well monitored environmental conditions (at 8 Boon Lay Way, #0902),
‘The thermistor was calibrated at Triple Point of Water (0.01°C), Gallium Meling Point (29.7646°C) and Calibration Bath maintained at 15°C. The
temperature scale used is TTS-90. The fixed point cells from ITS-90 used for the calibration are water triple point cell and gallium melting point
cell, The waterbath temperature was measured by SPRT and super-hermometer as reference. Prior to calibration, an SPRT was used to check on
the stability ofthe calibration equipment for measurement assurance. Upon completion of the calibration with a,b, and ¢ constants computed for
the thermistor, the thermistor dhen goes through a verification test where it is measured again at triple point of water and in waterbath at 21°C.
Standard Used
Equipment Serial Number
‘Triple Point of Water Cell 1TS-90) C-G8IS1
Gallium Cell (178-90) Ga3137
SPRT 4340
Super-Thermometer B2Al0S
Data Acquisition Unit My44080469
‘The reference standants used in this calibration are traceable to the ST units of measurement realised at National Metrology Centre, Singapore oF
other recognised national standards laboratories
‘The results reported herein have been performed in acordance with the tems of accreditation under the Singapore Accreditation Council
Catbrasd By Approved by:
is ‘
S pacman
Khaini Chand Yang Xin Man
Caltbration Officer g Approving Officer
Quality Manager
‘Nat: Copyright ficient owned y the Mere & Vrain Pe Li (M8) adh
oe repo ted il eel whe rien poral of MA
{8 800n Lay Way #09-01/02/08 TradeHub 21 singopore 609964
‘accredited
Tol +65 6684 6640 Fax +65 6795 3873 www.mnw.comsg Laboratory, fi
Company Reg No. 2009164692 GST Reg No, 2007164692 ‘SAC-SINGLAS 4.Page 2 of 5
sumer: 10K Themistor CERTIFICATE NO. M4V1961.003
SERIAL NUMBER: 102250082 DATE OF ISSUE: 2992002
Stability of Calibration Equipment
Before te eaibratons ae caried eu, an SPR is sed to ensue that al ealibaton equipments are in stable conditions.
‘SPRT 4340 in Triple Point of Water Cell-C-G4151
Before Calibration on 08/Aug/2022
‘Stailiy Check at 15°C Caliation Water Bath
PRT 4340 in 15°C Water Bath-B28277
on 16/Jul/2022
SPRT 4340 in Gallium Melting Point Cell Ga-43137
fore Calibration on 20/sul/2022
‘Now Conti of heinous Wye Meson Verio Re Ll NY) and lat edie en infil xy wih he pi rien paosume 10K Thermistor CERTIFICATE NO. MVI961-005
SERIAL NUMBER: TC2230082 DATE OF ISSUE: 29982022
Page3 of 5
Measurement Uncertainty
‘The reported expanded uncertainty is 0.013°C, a coverage factor ofk~2 fora level of confidence interval of approximately 95%
“The measurement esl are a follows
“TemperatureCO. Reianee
‘or 32,687.59
T5005 TS 713.80
39.7686 AEE
Equation Used
UE= a+b (aR) etka Ry
Wher: Ketone C422.)
bye = coefficionts derived fom measurement
‘in =natwal logit of resistance in bis
ed From Measurement
= TIDSeHTE OT
2 347099F-08
i407220-08
‘Temperature - Resistance Table
Feap CO) Temp) RVaiue @)
0 16 15,003.83
1 17 14,3265,
2 20.592.40 1 13683.08
3 28,091.37, 19 1307237,
4 26,719.99, 20 1249234
s 25.03.46, 21 941.28
6 2419731 2 HaI759
7 237.32 23 0919.78
5 31,939.59 2 1044642
9 30,900.45 25 9.99621
Ta 916.46 26 3567.88
198837 2 3.16026
1.10121 2s 577228
1726414 29 '3.402.80,
163470.52 0 5.05093
15,717.86
None Cop heen oe yh Mewneme & Veil MeL MY) anal epi hn flee we ite speaof MAYsumiecr: 10K Therion
SERIAL NUMBER: TC2230082
CERTIFICATE NO: MVI961-005
DATE OF ISSUE:
2992022
Page 4 of 5
Verification Test (VT)
‘The computed a,c consant forms the characteristic of ti thermistor. The constants ae we for verison test on the thesmistr using a TTS90 fined
point eel (TPW Cell and a 21°C. The verification test should show deviation les than {ink
Verification at Trine Pint of Water
Teas Tew Taw Tew
Date =| -Temp | Date [Time [Temp
2022 | Ts:1000] 0.0098 wix2029 | 1825.00 O08
82022 [18:11:00] 0.0098, ‘2022 [19:26:00 00105
‘982022 [18:12:00] 0.0100 ‘si2m29 1827.00 0.0102
182022 [18.13.00] 0.0095 ‘wana [1828.00] 0.0009
1782022 [1814.00] 0.0100 ‘i82022| 1829.00] 0.0097
‘i82n22 [181500] 0.0094 wi8022 | 183000[ 0102
wi82022 [11600 0.0008 ‘82002 1831.00 | 0.0100.
‘182002 Pist700 | 00006 ‘83009 [18:32:00 | 00102
182022 [18:18:00 | oo101 1182022 [18:33:00 0.0097
19812022 | 18:19:00] 0.0004 wi82022 [18:34:00] 0.0102
‘82022 [182000] 0.0100 wi82022 | 1835.00] 0.0106
‘82022 | 18:00] 0.0105 82022] 18:36:00] 0.0099
‘872022 [1822.00 | o.0102 ‘182022 [1837-00 | 0.0099,
1982022 [1825.00] .0008 1182029 [18:38:00 | 0.0097
13913022 [18:24:00] 0.0090 32022 [18:39:00 0.0103
Average] 0.0099
Verification at Triple Point of Watersumecr:
SERIAL NUMBER: 1€2230082
10K Themisor
CERTIFICATE NO,
DATE OF ISSUE:
+ MVI961-003|
2svsn022
rage 5 of $
‘Netfcaion at 21°C in Calibration Water Bath
Town aa Tom — aA
Dace | Tie] Temp Dit Ta
Taaz0as_| oom 30ST Tana [es | 3099
taaa0zs [igor 905576 Tana [e160 | 90H
Taa2oo2-[Te020 | 50557 Tamane3 [Tw | 20550
iao23 [Tes | 9m Tana0zs [1880 | 905978
iawa02s-[ ost | 30SHR7 Taai2002_[ 19.00 | 30S9HE
taanes [sO SOT Tan [ ean. | 305868
Taaoes | ibe] 309085 innanas [Tea on 30954
Taxoa2_ [gor | S0SHRT tananas [1523.0 | 305907
Tawan2s [ost | 30S tawa0es 183500] 305875
Tawanes [sa 305766 Tao [nae SEF
iawaees [T1900] 309060 Ta ao3 [Eason TET
goa [Tem | 305965 taney [Tea 305065
iawan23 [| 305867 Tana02s [13700 305559
Tawanes [ss] 205577 Tawaoes [180 30S
aaa? [Te 1800 | 309570 Tex [e390 305
Average] 309976
SPRL Reese Temps 21° can tah
TRB aI ware are
Date | Time] Temp Date Time] Temp
Tanna [oo | arm Tanne [ST aT
Tawa0es | ore 3} ian [ E1617] STOTT
Tawa [eos [STE iagand [E17 STOTT
iawaoas [eos at0rt taney [TERT STOTT
tawaoas_[isoete att Tana0ey [Tee at
rawanes_[ nose SUS Tans [SOIT SLT
Tai [ ee 311s Taaoa2 [E3117] Om
iagaoa2-[igo7tT | 3tmie Texans [e3 3 oe
Tawa02s [OST Sa tamao2y [Tea3.17 [Se
tawanes-[isosT7] 3 ianaory [e273 me
rawa0es sO TT[ SL Taia003-[ 1351791 Oe
Tawa022- [win FST ingao2s [T3617 91 onT
tawanes_[isdtT ae iawavas[Tea7 [aT ome
tawanes_ [iss ats iawa0as [ean rats
rawanes [ise STS Taianaa-[ 9301731 0s
‘Average 31017
Verification a 21°C
sere aesrerae
a = = =
a =
isa
fitom
Er
HS
Le
ino
-
‘Tne
88.
Sette
PSPS P8882
arre)
0.0036
oe Cop of hi ef ony the Manne & Veen Pei (MK) ash beep hn leper we el eV