Professional Documents
Culture Documents
02 1964 CH-Lubrication
02 1964 CH-Lubrication
LUBRI CATION
The 1964 Chevrolet engine and chassis lubrication CRANKCASE BREATHER CAP
requirements are described below. The time or mileage Clean and re-oil at every oil change.
intervals are intended as a guide for establishing
regular maintenance and lubrication periods. Sus
DISTRIBUTOR CAM LUBRICATOR
tained heavy duty or high speed operations or opera
tion under adverse conditions may necessitate more 6-Cylinder Engine Remove distributor cap and
-
FRONT SUSPENSION
Powerglide
Every 6,000 miles or 6 months lubricate 4 ball joint
Check fluid level every 6,000 miles with engine
fittings with water resistant EP lube.
idling, selector lever in "N" position, parking brake
set and transmission at operating temperature. Add
Automatic Transmission Fluid Type "A" bearing the
mark AQ-ATF, followed by a number and suffix "A" STEERING LINKAGE
to full mark on dipstick. DO NOT OVERFILL. Manual-Every 6,000 miles or 6 months lubricate fit
Lubricate the Powerglide shift linkage at frame and ting at each tie rod and at relay rod 4 fittings with
transmission with water resistant EP lube. water resistant EP lube.
Power-Same as manual plus fittings at valve adapter
REAR AXLE and cylinder 6 fittings.
PARKING BRAKE
Every 6,000 miles apply water resistant EP lube AIR CONDITIONING
to pulley bearing area, cable at the pulleys, cable Every 6,000 miles check sight glass under the hood
guides just behind frame "X" member and at all oper after the system has been in operation for several
ating link and levers. minutes. Sight glass should be clear. Bubbles or dirt
indicate a leak which should be corrected immediately.
STEERING GEAR Every week-during winter months-run the system
Check lube level every 36,000 miles. Add lubricant for 10 to 15 minutes to insure proper lubrication of the
as needed to level of filler plug hole. seals and moving parts.