You are on page 1of 47

SERVICE MANUAL

SRG-1150DN
1. Initial Setting
1-1. Power
DC24V, 30A required. To follow IMO for installation, it needs individual power supply SP-
1250ADC.

1-2. TX
Test with 50Ω dummy load (300W).

2. How to input ID
1-1. Set ID

1. SET – ID 00000000

Ship’s ID (*********)

3. TX output / TX PTT ON / W/R DSC / Output Adjustment /


PCB set
1. TX-ENABLE OFF <- TX PTT set
2. WR-STOP OFF <- DSC RX scan ON/OFF
3. POWER SER <- Auto output adjustment
4. MAIN NEW(T-474) <- PCB kinds selection

= Caution =
Be careful to choose 4. MAIN NEW(T-474).
If T-474 is selected, it won’t be working as this is to use T-454 with old SRG-1150DN.
2. CIRCUIT DESCRIPTION
2-1. SRG-1150DN/1250DN
① System configuration of SRG-1150DN

RX ANT TX/RX ANT

NBDP

W/K SN-100
∙ Power Amplifier

∙ control

∙ DSC ATU
(SAT-100)
∙ MF/HF TX,RX

∙ W/K RX

∙ Power
Printer
② System configuration of SRG-1250DN

RX ANT RX/TX ANT

∙ Power Amplifier
W/K NBDP
∙ control SN-100

∙ DSC

∙ MF/HF TX,RX
ATU
∙ W/K TX (SAT-100)

∙ Power
PRINTER
2-2. Power Board

Power circuit operates by DC input (24V battery) and it consists of a control circuit of power supply
which is being on/off DC 24V to power amplifier, a constant-voltage circuit supplying DC power to
be constant voltage in each unit and audio amp for external speaker.

⑴ Main power circuit and power control circuit

When power on, activate main power DC 24V and convert to constant voltage +15V, +12V.

Supply power to SN-100 if amp of external speaker and SN-100(NBDP terminal) are installed.

⑵ Protection & Alarm


The power will be disconnected at overload +32V and the circuit to prevent a backward voltage
is built in not to damage SSB radio.

(Picture in below [32V check])


2-3. TX board

BIAS voltage operate and maintain fitting voltage to press PTT(transmitting switch) installed in

HAND MIC and virus voltage even in output amp for excitation is supplied and receive sound-input

from MIC installed and after amplify audio-input in AF AMP(T-452 Q34, Q36) in BALANCE

MODULATION, mixed with BFO and in SSB FILTER(XL2) filter low frequency part.

So, this signal is mixed in 49MHz LOCAL and IC3 and amplify in 49MHz + IF =2'nd IF AMP(Q29).

This signal pass 49.455MHz FILTER and is mixed in Fc + 49.455MHz LOCAL and IC4 is amplify in

RF AMP (Q31,Q32) and pass LOW PASS FILTER.

This signal go to external RF AMPLIFIER and pass TX FELTER(T-551) and go to POWER

SPLITER(T-516_1) and pass T1,T2 and is separated as PWR AMP A(T-514) and PWR B(T-514).
This signal go to TX PWR CONBINER(T-516_2) and is combined and after go to DSC TX
FILTER(T-517) and amplify, in the selected TX LOW PASS FILTER, remove spurious and pass
antenna terminal and go to ATU and match transmitting frequency and antenna frequency and
transmit through antenna.

2-4 RX board

Receiving signal in whip antenna pass band filter and after filter, amplify in ultrashort amplifier T-

454(Q13, Q14) and in 1'st MIXER, fC + 49.455MHz LOCAL and BALANCE MIXER and make IF

49.455MHz.

This signal pass 455MHz FILTER to become filtering and in amplifier Q9, amplify and be balance

mixed in 2'nd LOCAL 49MHz and 2'nd MIXER Q7, Q8 and make 455KHz IF.

This signal become filtering through J3E(XL2), H3E(XL1) FILTER according to MODE.

Again, amplify in Q1, IC6 and mix SSB and H3E in IC7.

Mixed signal is divided to 3 species as follows.

① amplify for inner speaker audio.


② amplify for outer speaker audio.

③ FSK MODEM (DSC signal mix)


2-5. MOTHER BOARD T-580

Function of Mother Board (T-570) is connecting PCB.

* T-451(SRG-1150DN TX FILTER)/ T-461(SRG-1250DN TX FILTER)

* T-454(TX/RX EXCITER)

* T-557(CONTROL) , T-553(PLL SYNTHESIZE)

* T-555(POWER SUPPLY UNIT)

* T-552(W/K RECEIVER)
* T-514(SRG-1150DN TX POWER AMP) / T-524(SRG-1250DN TX POWER AMP) each other.

BK signal given from external pass PHOTO COUPLER to separate union earthing POLE from

receiver inner circuit and supply in BK control circuit.

BK controlling circuit control BK RELAY of input unit of high frequency and AGC circuit and protect

receiver from over input. Simultaneously, have a muting receiving circuit.

Moreover, it connects several connectors at rear side and do switching power supply of RX and TX.
a) This circuit board incorporates through most circuit board to consist of main unit organically
and electronically and operate.
b) In this circuit board, connecting of front, real and external is carried on each connector pass
filter circuit for noise-clear and is connected.
c) Each circuit board connected by this circuit board arranged connectors mechanically not to
incorporate in wrong-position.

SRG-1150DN’s schematic is as follows.

PSU MF/HF ANT

T-451(561) TX FILTER
T-454(474) MAIN
T-568 KEYBOARD
T-553 PLL
T-552 W/K
T-514 TX PA
SN-100 T-555
TERMINAL External Signal
W/K ANT Input/Output
SRG-1250DN’s schematic is as follows.

PSU MF/HF ANT

T-561 TX FILTER
T-474 MAIN
T-568 KEYBOARD
T-553 PLL
T-552 W/K
T-524 TX PA
SN-100 T-555
TERMINAL External Signal
W/K ANT Input/Output
2-6. TX FILTER
SRG-1150DN : T-451(561)
SRG-1250DN : T-561

If TX+ 12V signal is not showed in the PCB circuit, the main PCB(T-454) and antenna are

connected any time. And if TX+ signal is showed, antenna is connected with TX POWER(SRG-

1150DN : T-514 , SRG-1250DN : T-524) through FILTER circuit.

At this time, a filter is selected by transmitting frequency.

2-7. SYNTHESIZER T-553

This circuit of PCB is divided to two part (MF/HF unit and W/K SYNTESIZER) as SRG-1150DN/SRG-
1250DN FREQUENCY SYNTHESIZER.

① MF/HF synthesizer unit


Output of PLL(IC8) and VCO(2MVCO7) is used as MF/HF 1st LOCAL signal(49.555Mhz ∼
79.4549Mhz) and 7Mhz output signal is converted to 49Mhz by 7 multiplier(T2∼T6).
It is used as 2nd Local signal. DDS5 makes 456.4Khz± 125HZ signal directly as 3rd Local signal.
② W/K SYNTHESIZER UNIT
PLL(IC17) and VCO(VCO & AMP) is output as MF/HF 1'st LOCAL inputting signal
(66.2595MHz,62.0120MHz,57.8695MHz,55.7670MHz,53.6625MHz,51.6425MHz) in output of DDS3,
outputting 7MHz make 49MHz in 7frequency multiplier circuit(T8,9,11,12) and use as 2'nd LOCAL.
3rd LOCAL makes 456.7kHz signal directly from DDS1.
2-8. POWER CONTROL T-555

T-555 has a main constant voltage PCB(+12V) and vertical current (CHECK circuit(IC2)). If PWR
SW is being ON, the relay doesn’t work until becoming 4.5V by IC7, this signal make TX CURRENT
happen through BiMOS Operational Amplifiers(IC3), AUDIO signal(CONNECTOR 6PIN, 5PIN)
connect PHONE JACK through amplifier(IC6).
2-9. PA AMP SRG-1150DN-T-514/ SRG-1250DN-T-524

This PCB consist of TX output power(150W for SRG1150DN & 250W for SRG1250DN) amp.
2-10. CONTROL PCB T-557

이 PCB 회로에는 중앙처리장치 C

Check the basic setting items for display unit, and then confirm following items.
1. Check connectors among LCD, T-568 and T-557.
2. Check output voltage of IC 26(-12V), IC 27(-9V) is normal if there is nothing to show on the
display.

Below description is for each component on PCB T-557.

T-557 consist of CPU(IC1), memory ROM(IC2)/RAM(IC3), Clock Generator(IC4), Buffer(IC5), I/O


Amplifier(IC17), AC/DC Converter(IC15), RS-232C(IC13), Decode Counter(IC28) for convert
10MHZ to 1MHZ, EPROM(IC12), FS MOD EM(M2), DDS(M1), Audio Amplifier(IC20),
MUX/DEMUX(IC24) for controlling LCD contrast.
2-11. FRONT T-568

Switch, LED, voice, sensitivity (VR) controller.


2-12. W/K Receiver T-552

Receiving method is Double-Super Heterodyne Type that 1st intermediate frequency is 49.455MHz
and 2nd intermediate frequency is 455KHz.
All LOCAL signal of receiver is supplied from Digital Control Frequency Synthesizer which is being
PHASE LOCKED LOOP(PLL) system and direct system by using 14MHz VTCXO.

If not receiving of DSC message, please check basic setting for DSC Mode and the below.
1. Check W/K antenna and input power supply.
2. Check the voltage of pin9, 10(Vdd) of CN1 indicates +12V.
3. Check selection of band pass filter is correct (Q9-Q14) and LED1 lights up.
4. Check the 1st local signal is mixed by Q24, Q26. If 1st local signal is not proper, it results from
PLL IC(IC17), VCO in T-553 and indicates the faulty condition with LED2(normal : flickering
regularly)
5. Check the output signal (49.455Mhz) and drain voltage(+12V) of Q4.
6. Check the 2nd local signal is mixed by Q2, Q3. If 2nd local signal is not proper, it results from
multiple circuit(T7 ∼ T11) in T-553.
7. Check the 455Khz IF signal is amplified into 40-50dB at pin1,8 via pin4 in IC1.
8. Check the 3rd local signal sent to pin2 in IC2 is mixed with 455kHz IF signal, and then outputs
demodulated signal to pin1. If 3rd local signal is not proper, it results from DDS Module(DDS1) in
T-553.
9. Check pin8 in IC3 generates square wave signal during receives DSC signal.
10. Try visual checking for T-552,T-553 and replace them if required.

*** DSC demodulation unit


DSC demodulation unit is to detect Dot Pattern and it consists of filter circuit, detection circuit
and Micro Processor to judge Dot Pattern.

DOT PATTERN is a signal repeating MARK, SPACE in every 10mS.

MARK SPACE MARK SPACE

10mS 10mS 10mS 10mS

Dot Pattern
MICRO COMPUTER sample the signal from LIMITING circuit in every 10mS and judge whether this
signal is corresponded to DOT Pattern. When the signal is corresponded to DOT PATTERN,
MICRO COMPUTER output DOT DET signal for DSC unit.
Output of RX frequency information for LED ON of DOT PATTERN IN PROGRESS in panel side and
scanning-cease is carried on CPU circuit T-557.
DOT PATTERN’s detection circuit RESET is done by the RESET signal from DSC unit.
Timing of DOT DET-signal is below.

Main unit detect Dot Pattern.

Response
DOT DET signal
from main
(DSC – Main Unit)
unit

RESET signal
(DSC – Main unit)

Response from DSC


From DSC

Timing of DOT DET signal and RESET signal


2-13. REAR SIDE

① Terminal: Power supply(8v) for printer, GPS data, BK +/-


② MF/HF Antenna: Input jack for Watch-keeping RX antenna (Impedance 50-75ω)
③ ATU: ATU control connector
④ EXT.jack: Connection jack for external speaker
⑤ W/K Antenna: Input jack for W/K RX antenna (Impedance 50-75ω)
⑥ Car connector: Connector for power supply(+24v)
⑦ Fuse: 30A fuse
⑧ Alarm Box: Connector for alarm button box(SD-250)
⑨ Printer: Printer
⑩ GND: Receiver system ground
⑪ AC/DC detector: Power supply detect AC/DC
⑫ Terminal Control: Connector between SRG-1150DN/1250DN and SN-100(NBDP terminal)
INSTALLATION DRAWING - A
INSTALLATION DRAWING - B
STG-1150 1250 배선도 - B
T-451 TX FILETER
T-454 RX/TX IF FOR SSB
T-454 RX/TX FILTER
T-474 RX/TX IF FOR SSB
T-514 TX POWER AMP A&B
T-474 RX/RX FILTER
T-552 RX/TX IF
T-552 MF DSC RX FILTER
T-553 MF-DSC DDS/OVEN/REF ODC
T-553 MF-DSC DDS/OVEN/REF OSC
T-553J MF-DSC DDS/OVEN/REF OSC ( SMD TAPE )
T-555 POWER CONTROL
T-555G MF/HF SSB POWER CONTROL (SMD TAPE)
T-557 CPU BOARD
T-1557 CPU BOARD (SMD TAPE )
T-568 2M SSB FRONT BOARD
T-580 MF-HF SSB MOTHER BOARD
T14MHz REF OSC BOARD
MIC SCH DIAGRAM
T-449 SSB AUTOMATIC TUNER

You might also like