Professional Documents
Culture Documents
1) All questions are Multiple Choice Questions having single correct option.
7) Use only black/blue ball point pen to darken the appropriate circle.
Q.no 1. A negative clipper removes the ___________ half-cycles of the input voltage.
A : Negative
B : Positive
D : No part of
B : core, fiber
C : core; cladding
D : cladding; core
Q.no 4. What are the possible forms of energy transmission that can be
undertaken by a transducer ?
A : Acoustical
B : Electrical
C : Mechanical
Q.no 5. How many bits are required to store one BCD digit ?
A:1
B:2
C:3
D:4
A : Inductive transducer
B : Non-inductive transducer
C : Capacitive transducer
D : Resistive transducer
A : Zener Diode
B : Varactor diode
D : Gunn Diode
A : Clipper
B : Clamper
C : Peak amplifier
A : in a pi configuration
B : in a bridge configuration
A : smoth DC voltage
B : steady DC voltage
C : pulsating Dc voltage
D : AC voltage
A : glass
B : plastic
C : metal
D : A or B
A : X-rays
B : Cosmic waves
C : Radio waves
D : Gamma rays
A : 1.21
B : 1.12
C : 1.32
D : 1.42
Q.no 15. For silicon diode the barrier potential is approximately equals to
A : 0.3 V
B : 0.7 V
C : 6.8V
D : 2.0 V
Q.no 16. Which of the following subsystem provides radio transmission between
mobile station and MSC?
A : BSS
B : NSS
C : OSS
D : BSC
Q.no 20. _______ cable carries signals of higher frequency ranges than _______ cable.
A : Twisted-pair; coaxial
B : Twisted-pair; fiber-optic
C : Coaxial; twisted-pair
A : AC signals only
B : DC signals only
Q.no 22. PSSR is an op-amp parameter which defines the degree of dependence on
variations in _______.
A : temperature
B : pressure
A : Gate current = ∞
B : Gate current = 0
C : Gate current = -∞
Q.no 24. The output of a particular Op-amp increases 8V in 12μs. The slew rate is
…….
A : 90 V/μs
B : 0.67 V/μs
C : 1.5 V/μs
D : none of these
C : Middle digit
A : triangle waveform.
B : pulse waveform.
C : sawtooth waveform.
D : sinusoidal waveform.
Q.no 27. The arrow in the symbol of a transistor indicates the direction of
__________
Q.no 28. Most of the electrons in the base of an NPN transistor flow:
A : Zero
B : Unity
C : Infinite
D : Unpredictable
Q.no 31. Which of these sets of logic gates are designated as universal gates?
A : NOR, NAND.
D : All of these
Q.no 33. Which factor makes twisted-pair cable superior to fiber-optic cable?
A: signal attenuation
B: noise resistance
C: bandwidth range
D: cost
Q.no 34. Average load current (ILdc) for Half Wave Rectifier is _______
A : Im/π
B : 2Im/π
C : Im/2π
D : 2Im
Q.no 36. A single and fundamental form of load cell which is basically used as a
transducer in the operation of a weighing machine undergoes the conversion of
___________.
Q.no 37. Which of the following conversion is correct for load cell?
A : Force to strain
C : Force to voltage
Q.no 39. When a silicon diode is forward biased, what is VBE for a C-E
configuration?
A : voltage-divider bias
B : 0.4 V
C : 0.7 V
D : emitter voltage
B : both the n-type and p-type materials have the same potential
Q.no 41. An inverting amplifier with gain 1 have different input voltage: 1.2v,3.2v
and 4.2v. Find the output voltage?
A : 4.2v
B : 8.6v
C : -4.2v
D : -8.6v
B : 2Vm
C : 3Vm
D : Vm/π
Q.no 43. A circuit whose output is proportional to the difference between the
input signals is considered to be which type of amplifier?
A : common-mode
B : darlington
C : differential
D : operational
Q.no 44. A differential amplifier has a common-mode gain of 0.2 and a common-
mode rejection ratio of 3250. What would the output voltage be if the single-ended
input voltage was 7 mV rms?
A : 1.4 mV rms
B : 650 mV rms
C : 4.55 V rms
D : 0.455 V rms
A : 1111E8
B : 1.1011E8
C : 1.1101E8
D : 1.111E8
A : 500 mA
B : 50 mA
C : 56.56 mA
D : 52 mA
Q.no 48. With a differential gain of 50,000 and a common-mode gain of 2, what is
the common-mode rejection ratio?
A : –87.9 dB
B : –43.9 dB
C : 43.9 dB
D : 87.9 dB
Q.no 49. With full-wave rectification, current through the load resistor must be
D : in opposite directions
C : Bridge Rectifier
B : trivalent-doped material
C : anode lead
Join @SPPUBTECH - Telegram
D : cathode lead
Q.no 52. In a transistor, the base current is about ________ of emitter current.
A : 0.25
B : 0.2
C : 0.35
D : 05
Q.no 53. The static V-I curve for the SCR is plotted for
B : Ia vs Va with Ig as a parameter
C : Va vs Ig with Ia as a parameter
D : Ig vs Vg with Ia as a parameter
Q.no 54. Which of the following memory device stores information such as
subscriber’s identification number in GSM?
A : Register
B : Flip flop
C : SIM
D : SMS
A:4
B:5
C : 16
D:6
Q.no 56. Zener breakdown voltage range can be controlled using _________
Q.no 57. Which of the following modulating signal voltage would cause over-
modulation on a carrier voltage of 10v?
A : 9.5
B : 9.99
C : 10
D : 12
Q.no 58. A certain OP-amp has bias currents of 50 μA. The input offset current is
……..
A : 700 nA
B : 99.3 μA
C : 49.7 μA
D : none of these
A : Vm
B : 2Vm
C : 3Vm
D : Vm/π
Q.no 60. If the feedback/input resistor ratio of a feedback amplifier is 4.6 with 1.7
V applied to the noninverting input, what is the output voltage value?
A : 7.82 V
B : saturation
C : cutoff
D : 9.52 V
Q.no 1. The element that has the biggest size in a transistor is _______
A : collector
B : base
Join @SPPUBTECH - Telegram
C : emitter
D : collector-base junction
Q.no 2. All of the following are basic op-amp input modes of operation EXCEPT
A : inverting mode
B : common-mode
C : double-ended
D : single-ended
A : biological signals
B : chemical signals
C : physical signals
D : electrical signals
A : 0.4
B : 0.42
C : 0.46
D : 0.48
B : quiescent point
C : saturation point
D : center point
A : NOR, XNOR
B : OR, NOR
D : XOR, OR
A : Inverted mode
B : Active
C : Cut off
D : Saturation
Q.no 8. The rate at which fluid flows through a closed pipe can be determined by
D : None of these
A : four
B : three
C : one
D : two
C : Regulate voltage
D : Emit light
Q.no 11. The device which changes from serial data to parallel data is
A : COUNTER
B : MULTIPLEXER
D : FLIP-FLOP
Q.no 12. _______ has an inner conductor and an outer conductor separated by
insulation.
A : twisted-pair cable
B : fiber-optic cable
C : coaxial cable
D : Both A and B
Q.no 15. Maximum rectification efficiency for Half Wave Rectifier is ________
A : 0.4
B : 0.6
C : 0.45
D : 0.48
A:0
B:1
Join @SPPUBTECH - Telegram
C:2
D : 10
A : Set Q = 1 and Q = 0.
B : Set Q = 0 and Q = 1.
D : No change in output.
A : Decimal
B : Octal
C : Hexadecimal
D : None
A : Holes
B : Electrons
C : Neutrons
D : Ions
Q.no 20. An output that is proportional to the addition of two or more inputs is
from which type of amplifier?
A : differentiator
B : difference
C : summing
D : analog subtractor
Q.no 21. In LED, when electron meets hole, it falls into a lower energy level and
releases energy in the form of ____
A : EM wave
C : Neutron
D : Photon
A : VBE
B : 2 VBE
C : 1.5 VBE
D : 3 VBE
A : Very low
B : As high as possible
Q.no 24. In a full wave rectifier the DC load current flows for
D : more than half cycle but less than complete cycle of the input signal
C: Smaller bandwidth
A : acceptor ions
C : free electrons
D : holes
B : Equal to Rc/ re
D : Impossible to determine
A : Diode
B : Capacitor
C : Resistor
D : Independent DC Supply
A : reverse
B : forward
Q.no 31. When matching polarity connections have been made and the potential
difference (PD) is above 0.7 V, the diode is considered to be:
B : an open switch
C : reverse biased
D : forward biased
Q.no 32. The voltage where current may start to flow in a reverse-biased pn
junction is called the
A : forward voltage
B : biasing voltage
C : barrier potential
D : breakdown voltage
Q.no 33. A current ratio of IC/IE is usually less than one and is called
A : beta
B : alpha
C : omega
D : theta
Q.no 34. A cordless telephone using separate frequencies for transmission in base
and portable units is known as
A : duplex arrangement
Q.no 35. When an input of NAND gate is combined ,the gate formed is
A : OR gate
B : AND Gate
C : NOT Gate
D : None of these
A : collector voltage
B : emitter voltage
C : base current
D : collector resistance
Q.no 39. Which among the following is/are the feature/s characteristic/s of an
integrated op-amp?
A : Small size
B : High reliability
A : 10Khz
B : 24Khz
C : 32khz
D : 12khz
Q.no 42. A ________ is thermally sensitive resistor that exhibits a large change in
resistance
A : Thermistor
B : Resistance Thermometer
C : Thermo couple
Q.no 43. What is the percentage of modulation if the modulating signal is of 7.5V
and carrier is of 9V?
A : 100
B : 91
C : 83.33
D:0
A : 001
B : 004
C : 100
D : 1000
A : 1010
B : F0F0
D : 5050
A : voltage
B : current
C : resistance
D : power
A : 5 legs
B : 2 legs
C : 4 legs
D : 3 legs
A : Forward voltage
B : Doping Level
C : Reversed voltage
D : Forward current
A : J = 0, K = 0.
B : J = 1, K = 1.
C : J = 0, K = 1.
D : J = 1, K = 0.
A : Zero
B : Infinite
C : few MΩ
D : few GΩ
A:9
B : 0.9
C : 900
D : 90
A : In a positional number system, each symbol represents the same value irrespective
of its position
B : The highest symbol in a position number system as a value equal to the number of
symbols in the system
Q.no 56. In an SR latch built from NOR gates, which condition is not allowed
A : S=0, R=0
B : S=0, R=1
C : S=1, R=0
D : S=1, R=1
Q.no 57. At 100% modulation, the power in each sideband is ………………… of that
of carrier
A: 50%
B : 0.6
C : 0.4
D : 0.25
Q.no 58. Which of the following indicates the correct set of combination in radio
waves?
A : Pressure sensor
B : Humidity sensor
C : Temperature sensor
D : Touch sensor
B : Bridge Rectifier