Professional Documents
Culture Documents
Power Door Lock Control System FOTON - Tunland
Power Door Lock Control System FOTON - Tunland
ir
www.cargeek.ir
www.cargeek.ir
COMPONENTS DRAWING
04
w
w
w
.C
ar
G
ee
www.cargeek.ir
www.cargeek.ir
BASIC INSPECTION
Inspection Measures
Steps
contents
Yes No> go to step 2
Check Battery voltage
1 • Battery voltage shall not be lower than 12V. Charge or replace the battery. Refer
No? to “Chapter 20A, start and charge-
Check whether the result is normal?
04 battery”
Check basic functions Yes No> go to step 3
• Use lock master control switch to control the lock
and unlock of all doors
• Use key to lock the door on the side of the driver,
2
all the doors should be locked. No? Go to defect phenomenon form
w
• Use key to lock the door on the side of the driver,
all the doors should be locked.
Check whether the result is normal?
w
www.cargeek.ir
www.cargeek.ir
doesn’t work
Chapter 4 Diagnosis-power door lock
w
4. Harness circuit control system, central control lock
doesn’t work
Chapter 4 Diagnosis-power door lock
w
1. Central control lock controller control system, only the central lock
Only the central control lock of one of one door doesn’t work
.C
door doesn’t work Chapter 4 Diagnosis-power door lock
2. Harness circuit control system, only the central lock
of one door doesn’t work
ar
G
ee
k.
ir
www.cargeek.ir
www.cargeek.ir
04
w
w
w
.C
ar
G
ee
k.
ir
www.cargeek.ir
www.cargeek.ir
04
w
w
w
.C
ar
G
ee
k.
ir
www.cargeek.ir
www.cargeek.ir
Diagnostic steps
1. Check fuse
(a) Ignition Switch: OFF.
3. Check harness and connector (power window switch, left front door-ground)
www.cargeek.ir
www.cargeek.ir
04
www.cargeek.ir
www.cargeek.ir
04
w
Yes> go to step 5
No> replace body controller
w
5. Check harness and connector (body controller-power window switch, left front door )
.C
(a) Disconnect connector J004 of power window switch, left
front door.
ar
G
ee
www.cargeek.ir
www.cargeek.ir
04
w
w
w
www.cargeek.ir
www.cargeek.ir
Yes> go to step 7
No> Replace power window switch, left front door.
w
www.cargeek.ir
www.cargeek.ir
Yes> go to step 8
No > Maintenance or replace harness.
w
www.cargeek.ir
www.cargeek.ir
9. Check harness and connector (body controller-power window switch, left front door )
(a) Disconnect connector J007, lock assy, left front door.
04
w
www.cargeek.ir
www.cargeek.ir
04
Yes> go to step 11
No> Replace lock assy, left front door.
G
door.
(d) Disconnect connector H005 of door lock motor of right rear
door.
ir
www.cargeek.ir
www.cargeek.ir
Yes> go to step 12
No > Maintenance or replace harness.
w
Battery voltage(Lasts
C033 (B1) - C033 (B2)
about 0.3 ~ 1.1 s)
ee
k.
www.cargeek.ir
www.cargeek.ir
04
w
w
w
.C
ar
G
ee
k.
ir
www.cargeek.ir
www.cargeek.ir
04
w
w
w
.C
ar
G
ee
k.
ir
www.cargeek.ir
www.cargeek.ir
Diagnostic steps
• This diagnostic step follows right front door, and the diagnosis of other door is the same as the
right front door.
(b) Use master control switch to lock the door, meanwhile use
multimeter to measure the voltage between stitch5 of
w
www.cargeek.ir
www.cargeek.ir
www.cargeek.ir