You are on page 1of 3

Waterproof Speakers

Installation Instructions

Ratings
Type: Full-range, coaxial waterproof speaer
Impedance: 4Ω
Watts (single speaker): 80W max
Weight (single speaker): 16.6 oz (470g)

INSTALLATION
1. Cut a 5-1/4” [133 mm] diameter mounting hole using the attached template and drill holes for the 4 mounting
screws.
• Four stainless steel wood screws are inculded for mounting your speaker.
• Depending on the wall or ceiling material used, you may need to use molly bolts instead. If so, use #6
molly bolts and be sure that the bolts are stainless steel or brass to prevent corrosion later.
2. Remove the speaker grill by using a small screwdriver to pry up in the 4 recesses on the front grill or by
gently prying the two latches on the back side of the speaker (see below).

Pry Point, 4 places

Latch,
2 places

4211-197 11/20/20
Waterproof Speakers
Installation Instructions
Refer to the figures at right for steps 3 to 6.

3. Connect the wires from the amplifier to the speaker. The speaker
wires should already be run to the speaker mounting location and
the wire ends pulled out through the mounting hole. Connect
the + terminal on the amp to the + terminal on the speaker and the
- terminal on the amp to the - terminal on the speaker. When
installing two speakers, make sure the + and - wiring matches
on both speakers for the best sound.
4. Apply silicone to the backside of the speaker on the flat mounting
surface and the flat surfaces around the screw holes. When the
Speaker Wires
speaker is mounted in a wet location, it must be sealed against
the mounting surface in order to prevent moisture damage.
5. Mount the speaker by setting it into its mounting hole. Hold it
in place (painter’s tape may work well to hold the speaker in Silicone
place) while installing the mounting screws. If using moly bolts,
make sure the molys are in place before mounting the speaker.
Tighten the screw firmly and clean any excess silicone, then let
the silicone dry.
6. Test the speaker and if it is working well, carefully snap the
speaker grill in place.

For additional assistance contact

P.O. Box 2258 Woodinville, WA 98072


800-363-0251
Fax: 425-951-1130
email: support@amerec.com

4211-197 11/20/20
Waterproof Speakers
Installation Instructions

OUTSIDE
EDGE OF
SPEAKER

SCREW HOLE
4 PLACES

CUT LINE

5 1/4” [133 mm] DIAMETER

4211-197 11/20/20

You might also like