You are on page 1of 3

Page 1 of 3

Climate Control - Passenger Side Register


Removal and Installation

Removal

CAUTION: Do not manually open the registers. Failure to follow this instruction may result in damage to the internal components.

NOTE: If the registers are set to 'Automatic' mode and one or more are disconnected during an ignition cycle, a vehicle battery reset may be required to reconnect the affected
registers to the LIN BUS.

NOTE: Removal steps in this procedure may contain installation details.

1.

2.

3.

4.

https://connect.jlrext.com/topix/service/procedure/145632/ODYSSEY/G1005929/,DanaInf... 8/28/2012
Page 2 of 3

5.

6. Install the clips into the instrument panel.

7. NOTE: Do not disassemble further if the component is removed for access only.

8. NOTE: When removing the component, some of the clips may remain attached. These clips should be removed
and returned to their original positions in the passenger side register carrier.

9.

https://connect.jlrext.com/topix/service/procedure/145632/ODYSSEY/G1005929/,DanaInf... 8/28/2012
Page 3 of 3

Installation

1. To install, reverse the removal procedure.

https://connect.jlrext.com/topix/service/procedure/145632/ODYSSEY/G1005929/,DanaInf... 8/28/2012

You might also like