Professional Documents
Culture Documents
SuperControl Programming
G Codes Supported
G00 - Rapid Traverse
G01 - Linear Interpolation
G02 - Arc/Helix Interpolation Clockwise
G03 - Arc/Helix Interpolation Counterclockwise
G04 - Pause
G05 - Begin Spline Marker
G06 - End Spline Marker
G07 - Command Smoothing
G08 - Arc Speed Factor
G09 - Tangency Factor
G10 - Axis Mirror OFF
G11 - Axis Mirror ON
G12 - Ellipse Interpolation Clockwise
G13 - Ellipse Interpolation Counterclockwise
G14 - Feed Rate Profile Override (LSAM Only)
G15 - Rapid Mode
G17 - XY Plane
G18 - XZ Plane
G19 - YZ Plane
G25 - Rotary Axis Unwind
G26 - Axis Transfer
G27 - Cancel Transfer
G31 - Skip Input
G40 - Radius Compensation OFF
G41 - Radius Compensation ON Left
G42 - Radius Compensation ON Right
G43 - Length Compensation OFF
G44 - Length Compensation ON
G45 - Normalize
G46 - Length Compensation Blend OFF
G47 - Length Compensation Blend ON
G48 - Tool Center Point
G51 - Fixture Offset
G52 - Fixture Offset Table
G53 - Fixture Offset Table (with interpolated motion)
G54 - Tool Offset
G60 - Axes Tie OFF
mk:@MSITStore:C:\system\SuperControl_Manual.chm::/Documents/gcodessupported.htm 7/8/2022
G Codes Supported Page 2 of 2
mk:@MSITStore:C:\system\SuperControl_Manual.chm::/Documents/gcodessupported.htm 7/8/2022