Professional Documents
Culture Documents
1 Introduction
This instruction has been written to assist clients maintain the windcube v2.1 lidar. Basic
maintenance is required to keep the lidars running at peak performance. This maintenance
is not difficult to perform. What is generally more difficult is gaining access to lidar’s which
are often in remote locations. Therefore, this maintenance is the responsibility of the client,
as they are better placed than ART to arrange maintenance with local landholders,
stakeholders, or other relevant service providers frequenting the proposed development
site.
1 – Check Window
This relates to window cleaning. Recommended interval is once per month:
• If necessary, clean Windcube window with water or isopropanol (isopropyl rubbing
alcohol) and optical tissues.
2 – Fill Container
This relates to Wiper liquid tank refilling. Recommended interval depends on climate and
location. As a guide, filling once per two months is recommended. If you are leasing a lidar
and power trailer from ART, then the trailer will most likely have 2 x 20L water containers
on board:
• Fill the active 20L container (one that has the Windcube submersible pump in it)
Page | 1
from the non-active 20L container. Refill the non-active 20L container ready for the
next refill. Use clean town water or tank water. Do not use ground water of any kind.
• Isopropanol (isopropyl rubbing alcohol) should be added to the mixture if
temperatures below zero°C are expected (30% if < 10°C, 15% if <0°C).
Note that hard water may affect measurements by leaving a lime scale deposit on the
window. ART recommends that you use soft water (mineral concentration under 60mg/L)
and the client is responsible for damages due to (hard) water quality.
If using wiper fluids, always follow the manufacturers instructions to determine the amount
of wiper fluid to use for 20L of water.
Page | 2