Professional Documents
Culture Documents
SECTION3
SECTION3
1. The pH value of fresh sewage is usually D 6. If the peak discharge of a storm water
150 m to 300 m. drain (S.W. Drain) is e.xpected to exceed
A .
equal to 7 150 cumecs, the free board to be
.
provided, is
B A
more than 7 100 cm
. .
C B
less than 7 90 cm
. .
28. Which one of the following gases is most 31. The maximum spacing of manholes D
significant as air pollutant hydraulic characteristics of sewer
specified by Indian standard in sewers .
A upto 0.3 m diameter is
Carbondioxide E. all the above.
. A
20 m
.
B
Oxygen
. B
30 m
.
C
Nitrogen
. C
45 m
. 34. Afive day B.O.D. at 15°C of the sewage of
D a town is 100 kg/day. If the 5 day B.O.D.
Sulphurdioxide.
. D per head at 15°C for standard sewage is
75 m.
29. Which one of the following statements . 0.1 kg/day, the population equivalent is
regarding septic tanks is wrong : A
100
A a gap of 7.5 cm between the .
B C C
1000 28.88 cumecs pneumatic ejector
. . .
C D D
5000 29.88 cumecs. air pressure pump.
. . .
D 37. If the diameter of a sewer is 150 mm, the 40. The sewer which resists sulphide
10000 gradient required for generating self corrosion, is
.
cleansing velocity, is A
35. The density of population over 40 Brick sewer
A .
hectares is 250/hectare. If water supply 1 in 60
.
demand per day is 200 litres and sewage B
discharge is 80% of water supply, the Cast iron sewer
B .
sewage flow in sewers of separate 1 in 100
.
system, is C
R.C.C. sewer
A C .
0.05552 cumec 1 in 120
. .
D
Lead sewer
B D .
0.05554 cumec none of these.
. .
E. None of these.
38. The average temperature of sewage in
C
0.05556 cumec India, is
.
A
10°C 41. For large sewers, maximum distance
D .
0.0556 cumec between manholes may be
.
B A
15°C 50 m
E. 0.0558 cumec. . .
36. For the open drain (N = 0.025) shown in
C B
the below figure, the discharge is 20°C 100 m
. .
D C
25°C 200 m
. .
E. 30°C. D
300 m
.
39. The most widely used pump for lifting
sewage is E. 400 m.
A A
26.88 cumecs centrifugal pump
. .
B B
acid regression shredder
. .
48. Water content of sewage is about
C C
alkaline fermentation both (a) and (b) A
. . 90%
.
D D
none of these. neither (a) nor (b). B
. . 95%
.
43. Lead acetate test in sewer manhole is
done to test the presence of C
99.9%
46. Sewer pipes are designed for maximum .
A
Methane gas discharge with 25% to 33% vacant cross-
. D
sectional area for 9.9%.
.
B A unexpected large scale infiltration
Hydrogen sulphide
. . of stream water
C B unexpected increase in the
Carbondioxide gas 49. Imhoff cone is used to measure
. . population
A
total organic solids
D C under estimates of maximum and .
Diesel vapours.
. . average flows
B
total solids
D .
All of the above.
.
44. Dried sewage after treatment is used as C
total in organic solids
.
A
fertilizer
. D
47. 5 days-biochemical oxygen demand settleable solids.
(BOD5) is taken at a temperature of .
B
building material
. A .
0°C 50. For a grit chamber, if the recommended
.
C velocity of flow is 0.2 m/sec and detention
chemical for lowering B.O.D.
. B period is 2 minutes, the length of the tank,
15°C is
.
D
base material for paints. A
. C 16 m
20°C .
.
45. The use of coarse screens for the B
disposal of sewage, may be dispensed D 20 m
25°C. .
with by .
C
24 m
.
D
30 m.
.