Professional Documents
Culture Documents
Page 1 of 5
Q. 10 Which of the following statement is correct?
A. The sub-surface sources are not B. Infiltration galleries are most suitable for
affected by draught. increasing the surface source supply, in dry season.
C. The rate at which water percolates D. all of the above
into well under safe maximum critical
depression head is called yield of well.
Q. 11 The water mains should be designed for
A. 100% B. 150%
C. 225% D. 250%
Q. 12 The resultant of the two forces P and Q is R. If Q is doubled, the new resultant is perpendicular
to P. Then
A. P = Q B. Q = R
C. Q = 2R D. none of these
Q. 13 Three forces acting on a rigid body are represented in magnitude, direction and line of action by
the three sides of a triangle taken in order. The forces are equivalent to a couple whose moment
is equal to
A. area of the triangle B. twice the area of the triangle
C. half the area of the triangle D. none of these
Q. 14 A smooth cylinder lying on its convex surface remains in
A. stable B. unstable
C. neutral D. none of these
Q. 15 For irrigation purposes, the p-H value of water should be
A. between 3 and 6 B. between 6 and 8.5
C. between 8.5 and 11 D. more than 11
Q. 16 A hydrograph representing one cm of run off from a rainfall of some unit duration and specific
area distribution is known as
A. hyetograph B. flood hydrograph
C. unit hydrograph D. S-hydrograph
Q. 17 Water logging is caused due to
A. inadequate drainage facilities B. over irrigation
C. presence of impermeable strata D. all of these
Q. 18 The ratio of linear stress to the linear strain is called
A. modulus of rigidity B. modulus of elasticity
C. bulk modulus D. Poisson's ratio
Q. 19 The extremities of any diameter on Mohr's circle represent
A. principal stresses B. normal stresses on planes at 450?
C. shear stresses on planes at 45? D. normal and shear stresses on a plane
Q. 20 The surveying used to determine additional details such as boundaries of fields, is called
A. city surveying B. location surveying
C. cadastral surveying D. topographical surveying
Q. 21 The horizontal angle between the true meridian and a survey line is called
A. magnetic bearing B. azimuth
C. dip D. magnetic declination
Q. 22 On kankar road, the camber generally provided is
Page 2 of 5
A. 1 in 24 to 1 in 30 B. 1 in 30 to 1 in 48
C. 1 in 48 to 1 in 60 D. 1 in 60 to 1 in 80
PART – II
Page 3 of 5
GANPAT UNIVERSITY
PH.D. ENTRANCE TEST JULY – 2020 INTAKE
FACULTY OF ENGINEERING & TECHNOLOGY
[CIVIL ENGINEERING]
SECTION – B
Answer Key
Q. 1 C
Q. 2 B
Q. 3 D
Q. 4 C
Q. 5 D
Q. 6 A
Q. 7 D
Q. 8 B
Q. 9 D
Q. 10 D
Q. 11 C
Q. 12 B
Q. 13 B
Q. 14 B
Q. 15 B
Q. 16 C
Q. 17 D
Q. 18 B
Q. 19 B
Q. 20 C
Q. 21 B
Q. 22 A
Q. 23 D
Q. 24 D
Q. 25 D
Page 4 of 5
Page 5 of 5