Professional Documents
Culture Documents
STANDARD
y
nl
Cold-reduced carbon steel sheet and strip of
commercial and drawing qualities
(First revision) O
w
ie
ev
Pr
ICS: 77.140.50
Descriptors: cold-reduced, carbon steel, sheet, strip, drawing
© Copyright 2020
DEPARTMENT OF STANDARDS MALAYSIA
DEVELOPMENT OF MALAYSIAN STANDARDS
The Department of Standards Malaysia (Standards Malaysia) is the national standards
and accreditation body of Malaysia.
The main function of Standards Malaysia is to foster and promote standards, standardisation
and accreditation as a means of advancing the national economy, promoting industrial
efficiency and development, benefiting the health and safety of the public, protecting the
consumers, facilitating domestic and international trade and furthering international
y
cooperation in relation to standards and standardisation.
nl
Malaysian Standards (MS) are developed through consensus by committees which comprise
balanced representation of producers, users, consumers and others with relevant interests, as
may be appropriate to the subject at hand. To the greatest extent possible, Malaysian
O
Standards are aligned to or are adoption of international standards. Approval of a standard as
a Malaysian Standard is governed by the Standards of Malaysia Act 1996 [Act 549]. Malaysian
Standards are reviewed periodically. The use of Malaysian Standards is voluntary except in so
far as they are made mandatory by regulatory authorities by means of regulations, local by-
w
laws or any other similar ways.
63000 Cyberjaya
Selangor Darul Ehsan
MALAYSIA
Contents
y
Foreword .................................................................................................................................... iii
nl
1 Scope ............................................................................................................................ 1
O
3 Terms and definitions ................................................................................................... 2
8 Shape tolerances………………………………………………………………………….. 16
9 Sampling. .................................................................................................................... 20
ev
11 Retests ........................................................................................................................ 20
12 Resubmission ............................................................................................................. 20
Pr
13 Workmanship .............................................................................................................. 21
16 Marking ....................................................................................................................... 21
Bibliography ............................................................................................................................. 24
Committee representation
The National Standards Committee on Metallic Materials and Semi-Finished Products (NSC P) under whose authority
this Malaysian Standard was developed, comprises representatives from the following organisations:
y
Federation of Malaysian Manufacturers
IKRAM QA Services Sdn Bhd
Jabatan Kerja Raya
nl
Malaysia Steel Association
Malaysia Steel Institute
Malaysian Iron and Steel Industry Federation
Master Builders Association Malaysia
Ministry of International Trade and Industry
Pertubuhan Arkitek Malaysia
O
SIRIM Berhad (Previous secretariat)
SIRIM QAS International Sdn Bhd (Civil and Construction Section)
SIRIM QAS International Sdn Bhd (Chemical & Consumer Section)
The Institution of Engineers, Malaysia
Universiti Malaya (Fakulti Kejuruteraan Mekanikal)
Universiti Teknologi Mara
Universiti Sains Malaysia
w
Universiti Teknologi Malaysia
The Technical Committee on Continuous Mill, Flat, Rolled Products which supervised this Malaysian Standard consists
of representatives from the following organisations:
ie
Universiti Malaya
Co-opted members:
Foreword
This Malaysian Standard was developed by the Technical Committee on Continuous Mill, Flat,
Rolled Products under the authority of the National Standards Committee on Metallic Materials
and Semi-Finished Products (NSC P).
y
Major modifications in this revision are as follows;
nl
b) Element in Table 3 has been replace “Carbon” with “C”, “Manganese” with “Mn”,
“Phosphorus” with “P” and “Sulfur” with “S”.
O
This Malaysian Standard cancels and replaces MS 2651:2015, Cold-reduced carbon steel
sheet and strip of commercial and drawing qualities
Compliance with a Malaysian Standard does not of itself confer immunity from legal obligations.
w
ie
ev
Pr