EPAO7/10/GHG14 DD Platform General Information / Preventive Maintenance Workshop Manual
Monitoring the Lubricating Oil
Perform the following maintenance on the lubricating oit
1. Check the oil level daily with the engine stopped and on a level surface. If the engine has just been
stopped and is warm, wait approximately 20 minutes to allow the oil to drain back into the oil pan before
checking
vt Note: the dipstick has a positive locking device such as a lever or twistlock
design that must be disengaged before pulling the dipstick out of the guide tube.
Use a shop rag to wipe off the end of the dipstick. Wait 15 seconds to allow any
crankcase pressure to dissipate through the guide tube and let the oil level settle
inthe oll pan
2. Add the proper grade of oil to maintain the correct level on the dipstick. Remove the dipstick from the
guide tube. Before adding lubricating oil, refer to "How to Select Lubricating Oil”
@ Notice: Do NOT fill beyond the maximum fill evel on the dipstick, since
overfilling may result in high oil consumption and possible severe engine damage.
sf Note: if the engine operating temperature is below 60° C (140° F), the engine
must be on a level surface and then shut down for 60 minutes for an accurate oil
level reading. Otherwise, the engine must be brought up to an operating
‘temperature of 60° C (140° F), parked on a level surface and then shut down for
five minutes for an accurate oll level reading,
3. Reinstall the dipstick and make sure itis fully inserted into the guide tube. Remove the dipstick and read
the oil level dipstick.
@ Notice: Do not add oil if the oil reading is in the crosshatch area on the dipstick.
‘There are approximately 5.0 L. (5.2 qts) from the minimum mark to the maximum
mark on the dipstick. Overfilling the oil pan can cause engine damage.
@ Notice: If the oil level is constantly above normal and excess oil has not been
added to the crankcase, consult with an authorized Detroit service outlet for the
cause, Fuel or coolant dilution of lubricating oll can result in serious engine
damage.
4. Check the oil level daily. With the engine stopped, use the oil dipstick and measure the oil level on
crosshatch area on the dipstick. Figure below shows Maximum oil level (1) and Minimum oil level (2). Ifthe
1oll reading is in the crosshatch area or between the bends of the dipstick, then the oil is at the proper level
for engine operation.
42141
5. Add the proper grade of oil to maintain the satisfactory range on the dipstick. All diesel engines are
designed to use some oil, so the periodic addition of oil is normal. Before adding lubricating oil, refer to
"How to Select Lubricating Oil.”
ote:
Numer deDecunert0000622996
Fecha de pubieacsn 2023-0808
Comentar osirunconentaa
22.