Professional Documents
Culture Documents
Please complete the following 25 questions and get them back to me for 08.30 on 7 February for
attendance on Friday 4 Feb 2022.
- Green
3. What is the relationship between the width of the blade of a screwdriver and the screw?
-Correct PPE
-Calibration stickers
6. If you were going to drill a piece of steel what would you use as a holding device?
- Vice
7. What are the two types of drill that can be used in a pillar drill, one might be 10 mm, one
might be 25 mm.
-shape, diameter, width, arbor hole size, abrasive material, grit size, grade and bond.
11. Items to be ground must be supported, but what direction must the grindstone rotate in?
Downwards, or upwards?
-upwards
12. What is the advantage of air powered tools and how can the drill speed be controlled?
Speed control and safe to use when near electrical cables. Speed control achieved by varying trigger
pressure.
14. What is the maximum SWG of sheet steel that a Nibbler can cut, and what size hole must be
drilled to allow access for the Nibbler?
- not exceeding 20 SWG, hole must be 3/8 in. of a template and can be turned in a radius of one
inch.
15. Who is responsible for read the Organisations Health and Safety Policy and Regulations?
- This spanner is used to access areas that are considered to be not possible to reach with other
spanners.
17. What two type of rivets can be milled using a Rivet Miller?
18. What does the spring, fitted to a pneumatic riveting hammer prevent?
19. How can you minimise the work hardening of a rivet as you use a riveting hammer?
21. What size of taper is a morse taper, and which part of a parallel twist drill is slightly raised to
provide clearance?
-morse tapers have a taper of 1 in 20 and run in sizes from 0 to 7*. The part is Land.
22. What do the flutes do on a twist drill and what is the cutting angle?
-fractional sizes
- number drills in sizes corresponding to steel wire gauge sizes no.1 to no.80, followed by letter drills.
-decimal diameters.
24. Which of the following s adjustable, a Washer Cutter, or a Hole Saw?
-washer cutter.
26. What are Slow and Quick Helix drills used to cut holes in?
27. What is the maximum amount of metal a reamer can widen a hole by?
28. What lubricants can be used during reaming and what direction is the reamer turned in
when it is being REMOVED?
- 1 in 48
30. How do you adjust an adjustable reamer, and how is the size of the reamer measured once
it has been adjusted?
- adjustment can be made by slackening one nut and the other tightened by same amount to move
blades along their slots. Size of the reamer measured with a micrometer if reamer has an even
number of blades.