Professional Documents
Culture Documents
HYPERSELF
Styrene-butadiene-styrene (SBS) Modified Bituminous Self Adhesive Membrane
1
R
HYPERSELF
HYPERSELF is a self adhesive membrane manufactured Before application, the surface should be primed with
to meet the highest international standards. It is a single coat of Coldstick R Primer. The substrate is
topped with a cross-laminated polyethylene sheet allowed to dry for 30 minutes till it becomes touch dry.
providing superior puncture and damage resistance. After application of primer, Hyperself membrane is
Hyperself membranes need to be topped with a unrolled over the substrate from the lowest point and
protective screed or reflective coating, if required to to work upwards. Care must be taken to ensure that
protect from harmful UV radiation. counter-gradient overlaps are not created. For more
details on the application guide* please visit our official
Uses website or contact our technical team for assistance.
Finally, Hyperself Membrane applied substrate can
● Ideal for waterproofing basements with horizontal or be topped with a protective screed.
vertical underground structures, insulation
systems or multi - level floors, tunnels, terraces, flat Coverage
/ sloped roofs, etc.
IWL’s Coldstick R primer: 3-4 sq.m. / Litre on a
● Recommended as anti-corrosive tapes. standard smooth surface.
Advantages Limitation
● Easy and fast application. ● Smooth and clean surface is required to apply the
● No s p e c i a l e q u i p m e n t ( flame t o r c h ) i s membrane.
r e q u i r e d during application.
● Good chemical resistance and highly resistant to ● Not s u i t e d f o r p a v e m e n t s , as the membrane
ageing, tearing and perforation. is unable to bear loads.
● Excellent adhesive property and good dimensional
stability. Packing
● Maintains greater flexibility even at low temperatures.
IWL’s Coldstick R primer : 20 litre Container
Application Hyperself Membrane is supplied at 1.00 to 2.00
mm thickness. Also, available with varying thickness
Surface Preparation and weight as per customer requirement. For
special applications, it is supplied with release paper
on both sides.
Any substrate should be cleaned to remove all dust,
foreign matters, loose materials or any deposits that
affects bonding. The surface is first cleaned to eliminate
Storage
all sharp projection. Any surface defect should be
To be stacked in horizontal form in pallets with
repaired and should be smooth prior to application of
maximum height half meter with a maximum time of
Hyperself (self adhesive) membrane.
six months from the date of manufacturing, in
complete pack. Store in a cool and dry place.
2
R
HYPERSELF
Technical Information
500
Safety Precautions
3
R
HYPERSELF
DELHI
MUMBAI
VISAKHAPATNAM
CHENNAI
- Factory