Professional Documents
Culture Documents
Shutdown SIS
Previous Screen
i02856850
Belts - Inspect/Adjust/Replace
SMCS - 1357-025; 1357-040; 1357-510
Inspection
Inspect the alternator belt and any accessory belts for wear and for cracking. Replace the belts if the
belts are not in good condition.
To check the belt tension, apply 110 N (25 lb) of force midway between the pulleys. A correctly
adjusted belt will deflect 13 to 19 mm (0.50 to 0.75 inch).
Slippage of loose belts can reduce the efficiency of the driven components. Vibration of loose belts
can cause unnecessary wear on the following components:
• Belts
• Pulleys
• Bearings
If the belts are too tight, unnecessary stress is placed on the components. This reduces the service life
of the components.
Replacement
For applications that require multiple drive belts, replace the drive belts in matched sets. Replacing
one drive belt of a matched set will cause the new drive belt to carry more load because the older
drive belts are stretched. The additional load on the new drive belt could cause the new drive belt to
fail.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/... 10/3/2022
C32 Marine Engine RNY00001-UP(SEBP4767 - 51) - Documentation Page 2 of 2
Illustration 1 g00960176
(1) Adjusting nuts
(2) Mounting bolt
(3) Mounting bolt
(4) Mounting bolt
2. Loosen mounting bolts (2), (3), and (4). Loosen adjusting nuts (1).
3. Turn adjusting nuts (1) in order to increase or decrease the drive belt tension.
4. Tighten adjusting nuts (1). Tighten mounting bolts (2), (3), and (4).
If new drive belts are installed, check the drive belt tension again after 30 minutes of engine operation
at the rated rpm.
Copyright 1993 - 2022 Caterpillar Inc. Thu Mar 10 16:44:22 EST 2022
All Rights Reserved.
Private Network For SIS Licensees.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/... 10/3/2022