LUBRICANTS DIVISION
TOTAL TOTALFINAELF UK LIMITED
oor
MATERIAL SAFETY DATA SHEET
EQUIVIS ZS 15, 22, 32, 46 & 68
Product label fae
EC labeling
Symbols None
R Phrases. None
S Phrases None
Transport labelling: Not applicable
Hydraulic oi
GENERAL IDENTIFICATION: TOTALFINAELF UK Ltd
Lubricants Division
Pottery Lane
Ferrybridge
West Yorkshire WF11 8JY
l EMERGENCY TELEPHONE NO: 01977 636200
2 COMPOSITIOT
Chemical nature: Petroleum derived severley refined mineral oil based products with a PCA
cepntent <3% when measured by IP346
Ingredients contributing
| tohazards: None to our knowledge in normal use
3 HAZARDS IDENTIFICATION
Adverse human health effects: On the basis of our knowledge of the constituents used in this oil
present no risk of acute toxication,
Environmental effects: Experiments with similar virgin products indicate little danger for
‘aquatic or land living organisms and intrinsic biodegradability
PAGE 10F4
LT-D8-156-03Wash mouth out with water. Do not induce vomiting because of the danger of aspiration. If
aspiration occurs or is expected get immediate medical advice,
]
Skin
Wash skin as soon as pos
before reuse,
Eyes
Wash out thoroughly with)
medical advice,
Inhalation
I inhalation of fumes ir
medical advice if irritation
sible with soap and water. Change contaminated clothing and launder
water for at least 15 minutues. ifredness andlor Initation continues get
1es the nose of throat or causes coughing remove to fresh air. Get,
‘continues.
Extinguish with dry powdr, foam, sand or earth. For small fres use CO2
Do net tackle fires with water. Water may be used to cool the area surrounding fires.
ie econo paces should be tackled by trained personnel who should wear
breathing apparatus.
boots.
Contain spillage — take al
wash spillage down drain
and Fire Brigade,
Use mechanical means s|
suitable absorbent. Dis
collector.
Tay cause sippery surfages. Wear appropriate hydrocarbon proof dthing, goggles, loves and
necessary precautions to prevent water and ground pollution. Do not
Report any escape to public drainage or watercourses to Local Authority
ich as pumps or skimmers. Absorb using absorbent clay, sand or other
Ise of waste and contaminated material through and authorised waste
ee a
7.1 Handling
Skin contact should be
repeated contact is likely
when handling these pro
12 Storage
Drums should be stored
‘well-ventilated conditions,
sunlight in well-ventilated)
Keep containers clearly |
agents, water and moistut
ipt to a minimum and good hygiene standards maintained. If prolonged or
ROTECTIVE CLOTHING, as detailed in Section 8 SHOULD BE WORN
lucts, Keep away from food and beverages.
Nn their sides on racks preferably under cover, out of direct sunlight, in
Other types of containers should be stored under cover out of direct
‘conditions. Care should be taken to avoid over-stacking,
spelled and closed when not in use. Avoid contact with strong oxidising
LT-D8-196-03
PAGE 20F 43 EXPOSURE CONTROL /PERSONAL PROTECTION
Engineering measures Use the product in wellventiated premises
| When working on enclosed place (tanks, reservoirs.)
make sure that atmosphere is not suffocating andlor wear
recommend eqipment
Control parameters:
ccupational exposure limit cil mist: 40mg/m3, for 15 minutes
cil mist: Smg/m3, for 8 hours
Personal protective equipment
= Hand protection Glycol resistant gloves
= Eye protection: Goggles, incase of splashing
= Skin and body different hand protection: Depending on requirements, face mask, boots, clothing
proof against the product, safety shoes (drum
handling).
Dorit wear ring, watch or similar thing which will be able to
hold the product and may aive rise to some skin diseases
Industrial hygiene ‘Avoid prolonged and repeated contact with the skin
Immediately remove all soled or stained clothing,
ifthe product comes into contact with the skin, wash the
affected atea immediately and repeatedly with soap and
water
Use no abrasives, solvents or petroleum spirit
De not use cloths stained with the product to dry hands
Dont put the product-soaked rags in the pockets of
working clothes
Do not eat, drink or smoke while handling the product
Sa ee
= eases ceeoeeeceeteeresa SCOTS
‘Appearance
= Physical state: Liquia
= Colour: Yellow to amber
Odour: Characteristic
pH not applicable
Specific temperatures
of change in state
Flash point °C: 16 22 32468
>= 160 180 190-200-220
Auto-ignition temperature} > 250°C (ASTM E 659)
Explosion limits: Not determined
Density 873 to 900kg/m3 at 15°C.
Solubility
= in water: Insoluble and immiscible
in organic solvents: ‘Soluble in many common solvents
- Viscosity Kinematic viscosity at 40°C: 15 to 68 mm/s
Log P n-octanol / water at 20°C mineral oll > 6
40 7 ae re
ee sears eee
Stablify ~The produc Habe under norma lemperatures of storage, handing and use
Conditions to Avoid — Heat, sparks, ignition points, flames, static electricity ete
Materials to Avoid ~ Strong oxidising materials.
Hazardous Decomposition Products — Oxides of carbon (CO:, CO), various hydrocarbons,
aldehydes and soot
PAGE 30F 4
LT-Ds-156-03oo
Aeute toxicliyflocal :
Inhalation’ isk is improbable under normal conditions of use.
ng concentrations of vapour and spray may be irtating to
respiratory tract and mucous membranes
-Contact with skin: isk is improbable under normal conditions of use
-Ingestion: isk is improbable under normal conditions of use, ingestion of large
mounts may cause abdominal pain, diarrhoea ete
Sensitisation:
Contact with skin: 'o our knowledge the product does not induce sensitisation,
Chronic toxicity or long
-Inhalation:
-Contact with ski:
Special effects:
Carcinogenecit
‘term toxicity:
fapour and spray may be irate the respiratory tract and mucous
yembranes.
haracteristic skin infections (oil blisters) may develop following
rolonged and repeated exposure through contact with contaminated
thing,
jot considered to be carcinogenic when unused.
Ground: ihe product generally shows litle mobilty
Water ihe product is completely soluble
Biodegradabilty: jo data available
Disposal — by incineratior
‘or By methods approved by Local Authority
UN Number
Road (ADR) / Rail (RID)/
Marine (IMO-IMDG)
Airline (ICAO / ATA)
‘unregulated
River (ADNR) Not restricted for transport.
Not restricted for transport.
Not restricted for transport
15 REGULAT
EC labeling
Symbols None
R Phrases None
S Phrases None
[16 OTHER INFORMATION
dS
This data sheet conforms
Data sheet required purst
To standards defined by directives 91/155, S/11EEC & 200 TSBEC
jant to Art. 14 of directive 1999/45/EC.
LT-DS-156.03
le eartts ne ato TOTALFRAELE U Linked ncn apes te dic dat nd mp
PNA Ot andor any teat conpere scope ey ty eon one any espe mates
el #07 wn Soran 7 Corsi Pretec cage of eve cree rtm eee agua
wth ee tp raid or ped by TOTALFMAELE UK Lined wenn compen aaa
inane ean Es ach peace am badge
PAGE 40F 4