Professional Documents
Culture Documents
182
Control unit
4. Adjustment of current control circuit
l MPU board
P12 (L0) : Turns on when 12V power supply is normal.
P5 (L1) : Turns on when 5V power supply is normal.
STP (L2) : Turns on when microprocessor is stuck.
ST (VR0) : Start current adjustment
CL (VR1) : Current limit adjustment
IP (VR2) : Sensitivity adjustment of plugging current detection
LCD (VR3) : LCD contrast adjustment
CFL (VR4) : Back light brightness adjustment
IP voltage check terminal
(RS0) : Model selection
(RS1) : Monitor selection
(Fig. 5-58)
* Pin locations for connectors are shown from insertion side of pins.
183
Control unit
4. Adjustment of current control circuit
* Each setting parameter should be followed by the adjustment standards list for FB-60.
184