Professional Documents
Culture Documents
APGCL Assistant Manager Electrical-PH
APGCL Assistant Manager Electrical-PH
Question ID:
Marks 1 124
Question ID:
Marks 1 124
Q.2 .
Question ID:
Marks 1 125
Question ID:
Marks 1 126
Q.4 .
Question ID:
Marks 1 127
Question ID:
Marks 1 128
Q.6 .
Question ID:
Marks 1 129
Question ID:
Marks 1 130
Q.8 .
Question ID:
Marks 1 131
Question ID:
Marks 1 132
Question ID:
Marks 1 133
Question ID:
Marks 1 134
Question ID:
Marks 1 135
Q.13 .
Question ID:
Marks 1 136
Question ID:
Marks 1 137
Q.15 .
Question ID:
Marks 1 138
Question ID:
Marks 1 139
Q.17 .
Question ID:
Marks 1 140
Question ID:
Marks 1 141
Q.19 .
Question ID:
Marks 1 142
Question ID:
Marks 1 143
Q.21 .
Question ID:
Marks 1 144
Question ID:
Marks 1 145
Q.23 A single phase motor connected to 400 V, 50 Hz supply takes 31.7 A at a power factor of 0.7 lagging.
The capacitance required in parallel with the motor to raise the power factor to 0.9 lagging is
Question ID:
Marks 1 146
Question ID:
Marks 1 147
Q.25 The developed electromagnetic force and or torque in electromechanical energy conversion system
act in a direction that tends
Question ID:
Marks 1 148
Q.26 In a 12-pole triplex lap-wound d.c. armature, each conductor can carry a current of 100 A. The rated
current of this armature is ––––––––––––– ampere.
Question ID:
Marks 1 149
Question ID:
Marks 1 150
Q.28 A 4 pole lap wound dc shunt generator has flux per pole of 0.06 wb. The armature winding consists of
200 turns, each turn having a resistance of 0.003 ohm. With armature current of 45 A, the terminal
voltage at 1000 rpm is
Question ID:
Marks 1 151
Q.29 A 200/100 V, 50 Hz transformer is to be excited at 40 Hz from the 100 V side. For the exciting current
to remain same, the applied voltage should be
Question ID:
Marks 1 152
Question ID:
Marks 1 153
Q.31 In a transformer the core loss is found to be 52 W at 40 Hz and 90 W at 60 Hz. Both the losses
measured at the same peak flux density. The hysteresis and eddy current loss at 50 Hz is
Question ID:
Marks 1 154
Q.32 An eight-pole wound rotor induction motor operating on 60 Hz supply is driven at 1800 r.p.m. by a
prime mover in the opposite direction of revolving magnetic field. The frequency of rotor current is
Question ID:
Marks 1 155
Question ID:
Marks 1 156
Q.34 A field excitation of 20 A in a certain alternator results in an armature current of 400 A in short circuit
and a terminal voltage of 2000 V on open circuit. The magnitude of the internal voltage drop within the
machine at a load current of 200 A is
Question ID:
Marks 1 157
Question ID:
Marks 1 158
Q.36 In the Hopkinson’s test on two DC machines. Machine A has field current of 1.4 A and Machine B has
field current of 1.3 A. Which machine acts as generator?
Question ID:
Marks 1 159
Question ID:
Marks 1 160
Q.38 .
Question ID:
Marks 1 161
Q.39 The energy stored in the magnetic field of a solenoid 30 cm long and 3 cm diameter wound with 100
turns of wire carrying a current of 10 A is
Question ID:
Marks 1 162
Question ID:
Marks 1 163
Q.41 Two Wattmeter method is used for measurement of power in a balanced three phase load supplied
from a balanced three phase system. If one of the meters read half of the other (both positive), then
the power factor of the load is
Question ID:
Marks 1 164
Q.42 A manganin Swamping resistance is connected in series with a moving coil ammeter consisting of a
milli-ammeter and a suitable shunt in order to
Question ID:
Marks 1 165
Question ID:
Marks 1 166
Q.44 .
Question ID:
Marks 1 167
Question ID:
Marks 1 168
Q.46 .
Question ID:
Marks 1 169
Q.47 .
Question ID:
Marks 1 170
Question ID:
Marks 1 171
Q.49 .
Question ID:
Marks 1 172
Question ID:
Marks 1 173
Q.51
A 3-phase 11 kV generator feeds power to a constant power unity power factor load of 100 MW
through a 3-phase transmission line. The line-to-line voltage at the terminals of the machine is
maintained constant at 11 kV. The per unit positive sequence impedance of the line based on 100
MVA and 11 kV is j 0.2.The line to line voltage at the load terminals is measured to be less than 11 kV.
The total reactive power to be injected at the terminals of the load to increase the line-to-line voltage
at the load terminals to 11 kV is
Question ID:
Marks 1 174
Question ID:
Marks 1 175
Question ID:
Marks 1 176
Q.54 .
Question ID:
Marks 1 177
Question ID:
Marks 1 178
Q.56 .
Question ID:
Marks 1 179
Q.57 The frequency response of an amplifier can be determined using the step response method, and
measuring the output rise/fall times between
Question ID:
Marks 1 180
Question ID:
Marks 1 181
Question ID:
Marks 1 182
Q.60 Latches constructed with NOR and NAND gates tend to remain in the latched condition due to which
configuration feature?
Question ID:
Marks 1 183
Question ID:
Marks 1 184
Q.62 .
Question ID:
Marks 1 185
Question ID:
Marks 1 186
Q.64 .
Question ID:
Marks 1 187
Question ID:
Marks 1 188
Q.66
‘Green revolution’ is related to plants in the same way as ‘Silver revolution’ is related to ——————?
Question ID:
Marks 1 189
Q.67 ‘Gravity’ is related to pull in the same way as ‘magnetism’ is related to?
Question ID:
Marks 1 190
Question ID:
Marks 1 191
Question ID:
Marks 1 192
Q.70
.
Question ID:
Marks 1 193
Question ID:
Marks 1 194
Q.72
.
Question ID:
Marks 1 195
Question ID:
Marks 1 196
Q.74
.
Question ID:
Marks 1 197
Question ID:
Marks 1 198
Q.76
How many dimension have in Baron’s Model in Emotional intelligence
Question ID:
Marks 1 199
Question ID:
Marks 1 200
Question ID:
Marks 1 201
Question ID:
Marks 1 202
Question ID:
Marks 1 203
Question ID:
Marks 1 204
Question ID:
Marks 1 205
Question ID:
Marks 1 206
Question ID:
Marks 1 207
Q.85
Poly Umrigarh Award was given in 2020 to
Question ID:
Marks 1 208
Question ID:
Marks 1 209
Question ID:
Marks 1 210
Question ID:
Marks 1 211
Question ID:
Marks 1 212
Q.90 Which state of India is exempted from right to information act of India 2005.
Question ID:
Marks 1 213
Question ID:
Marks 1 214
Q.92 .
Question ID:
Marks 1 215
Question ID:
Marks 1 216
Q.94 .
Question ID:
Marks 1 217
Question ID:
Marks 1 218
Q.96 Given are parts of the sentence. One of the parts may have a mistake. Spot the error part.
Question ID:
Marks 1 219
Question ID:
Marks 1 220
Q.98 .
Question ID:
Marks 1 221
Question ID:
Marks 1 222
Question ID:
Marks 1 223